YAMAHA Complaints

I HAVE AN YAMAHA V-STAR 1100 AND THE MIDDLE DRIVE SHAFT BROKE. THE SHAFT SHEARED OFF WHERE THE NUT TIGHTENS THE UNIVERSAL JOINT TO THE SHAFT. THIS CAUSED THE REAR TIRE TO LOCK UP. LUCKILY I WAS MOVING AT A VERY LOW SPEED OR I WOULD HAVE SERIOUSLY BEEN HURT.

TL* THE CONTACT OWNS A 2006 YAMAHA XVS11. WHILE DRIVING APPROXIMATELY 30 TO 35 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THERE WAS A LOOSE NUT IN THE MID-DRIVE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 17,000.

THIRD GEAR STARTED GRINDING. RIDING ALONG AT NORMAL SPEED AND NORMAL RPM AND ANY TIME I DECELERATE OR DOWNSHIFT IN OR INTO THIRD GEAR IT MAKES A GRINDING NOISE.

DRIVING 75MPH ON HIGHWAY, LOSS OF POWER, LOUD BANG! REAR TIRE LOCKED UP FOR A SECOND. ALMOST CAUSED ME TO CRASH. ENGINE WOULD NOT START. VEHICLE PUSHED TO SIDE OF ROAD AND TRAILERED HOME. TOOK ENGINE APART TO FIND OIL PUMP GEAR BROKEN. VERY COMMON ISSUE BUT NO RECALL FROM YAMAHA! IF YOU HAVE A 99-2002 ROAD STAR YOU ARE AFFECTED! THANKS FOR NOTHIN YAMAHA!

TRAVELING AT APPROX 45 MPH VEHICLE SHUT OFF. UPON RESTART SEVERAL MINUTES LATER IT WOULD ONLY IDLE FOR A FEW SECONDS BEFORE STALLING AGAIN. TOWED TO DEALER, UNABLE TO DIAGNOSE A PROBLEM. BIKE WAS RETURNED 2 DAYS LATER WITH ASSURANCES IT WAS RUNNING FINE. ON THE RIDE HOME, APPROX 5 MILES FROM THE DEALERSHIP AND WHILE TRAVELING APPROX 60 MPH, IT SHUT OFF AGAIN AND WOULD NOT RESTART. TOWED AGAIN TO THE DEALER AND DIAGNOSED AS A FAULTY ECU. EXTREMELY DANGEROUS CONDITION. THE SECOND INCIDENT OCCURRED ON A NARROW TWO LANE COUNTRY ROAD WITH TRAFFIC BEHIND ME AND NO WHERE TO EXIT THE PAVEMENT.

CAM CHAIN TENSIONER FAILED TO ADJUST CORRECTLY CAUSING CAM CHAIN TO OVER TIGHTEN WHICH LED TO CHAIN GUIDE DAMAGE. ENGINE OIL CONTAMINATED WITH METAL FILINGS

TL* THE CONTACT OWNS A 2001 YAMAHA XV16A MOTORCYCLE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 03V09000 (POWER TRAIN); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

WAS RETURNING FROM A VACATION TRIP AND BIKE STARTED SOUNDING FUNNY. THEN ON HIGHWAY LIGHTS AND GAUGES STARTED GOING ON THE INTERSTATE BIKE STALLED LALMOST LOCKING UP BIKE IN CURVE WHILE RIDING ON WET ROAD. SEVERAL TRACTOR TRAILERS WERE BEHIND ME AND NEARLY ALMOST KILLED ME FROM THE SUDDEN CHANGE OF SPEED DUE TO BIKE KILLING POWER. MANAGED TO GET TO SIDE OF INTERSTATE. KILLED MY BATTERY TO NO RETURN 80+$. OPEN SEARCHING WEB AFTER GETTING HOPE LOOKED AT THE STATOR AND FLYWHEEL(ROTAR) MAGNETS ARE EVERYWHERE!!!!!!! THIS ALMOST KILLED ME!!! NOT TO MENTION IT DESTROYED MY STATOR AND IT HARD TELLING WHERE ELSE THE MAGNETS WENT. YAMAHA HAS REVISED THIS PART AND KNOWS THE ISSUE BUT NO RECALL!!!!!! THIS NEEDS TO BE RECALLED AND FIXED!!!!!!!

WHEN RIDING IN BRIGHT DAYLIGHT IT WAS HARD TO SEE MY DRIVING SPEED. I WOULD HAVE TO REMOVE ONE HAND FROM HANDLEBARS TO SHADE THE SPEEDOMETER TO BE ABLE TO SEE, GIVING ME LESS CONTROL. IT CAUSED ME TO BE UNABLE TO TELL HOW FAST I WAS GOING AND IF I WAS IN COMPLIANCE WITH POSTED SPEED LIMITS. UPDATED 09/17/15*LJ

I BEGAN ACCELERATING ON TO THE HIGHWAY WHEN I NOTICED A RATTLING WHINING NOISE COMING FROM THE MIDDLE OF THE MOTORCYCLE ONCE AS I APPROACHED AN EXIST TO INSPECT THE MOTORCYCLE MY REAR WHEEL LOCKED UP . ONCE I HAD IT TOWED HOME COME TO FIND OUT THE MIDDLE GEAR SHAFT NUT HAD BROKEN OFF WITH PART OF THE SHAFT INSIDE AND FEEL IF THOUGH REPLACING IT AND MAY CAUSE ME SERIOUS INJURY.