FORD Recalls

Jul 28, 2008 – KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.

Jul 03, 2008 – FORD IS RECALLING 142 MY 2008 EDGE AND LINCOLN MKK ALL WHEEL DRIVE VEHICLES. THE FUEL TANK WELD FIXTURE MAY HAVE BEEN EXPOSED TO A CONTAMINANT DURING PRODUCTION WHICH COULD CAUSE A DIMPLE IN THE BOTTOM OF THE FUEL TANK AT A SPOT WELD.

Jun 27, 2008 – WHEELED COACH IS RECALLING 215 MY 2008 F-350, F-450, AND F-550 RESCUE VEHICLES BUILT ON FORD CHASSIS AND EQUIPPED WITH 6.4L DIESEL ENGINES. IT HAS BEEN DETERMINED THAT THE CONNECTION OF THE MASTER SWITCH YELLOW 16GA WIRE TO THE OEM PTO ENABLE CIRCUIT DISRUPTS THE REGENERATION MODE WHEN THE MASTER SWITCH IS IN THE "ON" POSITION. THE REGENERATION MODE FAILURE WILL EVENTUALLY CAUSE THE 6.4L DIESEL ENGINE TO REDUCE POWER AND ENTER IN TO A LIMP HOME MODE.

May 07, 2008 – FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.

Apr 25, 2008 – FORD IS RECALLING 64,754 MY 2008 F-250 AND F-350 SINGLE REAR WHEEL, 4X4, 156 INCH WHEEL BASE PICK UP TRUCKS EQUIPPED WITH A TWO PIECE DRIVE SHAFT FOR FAILING TO CONFORM TO THE FUEL SPILLAGE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY." DURING A 30 MPH FRONTAL IMPACT INTO A RIGID BARRIER, THE FUEL TANK CAN MOVE FORWARD AND CONTACT A FRAME CROSS MEMBER, POTENTIALLY CAUSING DAMAGE TO THE FUEL DELIVERY MODULE WHICH CAN RESULT IN FUEL SPILLAGE.

Apr 14, 2008 – FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.

Apr 11, 2008 – FORD IS RECALLING 3,331 MY 2008 E-350 VEHICLES BUILT WITH A 138 INCH WHEEL BASE. THE DRIVE SHAFT MAY HAVE BEEN MANUFACTURED WITH A SLIP YOKE THAT HAS CRACKS. THE EFFECT OF THE CRACKS ON FATIGUE PERFORMANCE IS VARIABLE, BUT ON SOME YOKES WITH CRACKS, THE PERFORMANCE IS REDUCED BELOW DESIGN SPECIFICATION.

Apr 11, 2008 – FORD IS RECALLING 158 MY 2008 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES EQUIPPED WITH A TIRE PRESSURE MONITORING SYSTEM (TPMS) AND THE LIMO BUILDERS PACKAGE FOR FAILING TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, Z"TIRE PRESSURE MONITORING SYSTEMS." THE TIRE PRESSURE WAS INCREASED FROM 35 PSI TO 40 PSI WITHOUT A COMMENSURATE UPDATE TO THE TPMS CALIBRATIONS.

Mar 27, 2008 – TRUXXX IS RECALLING 338 AFTERMARKET REPLACEMENT WELDED 3" LIFT BLOCKS FOR REAR SUSPENSIONS, PART NO. 206073, INCLUDED IN SUSPENSION KIT NOS. 108035 AND 108036, SOLD BETWEEN JULY 26, 2007 AND MARCH 4, 2008, FOR USE ON FORD MY 2005-2008 F-250 SUPERDUTY 4X4 LIGHT TRUCKS. COMPRESSIVE FORCES OF THE WELDED LIFT BLOCKS RESULTING FROM FORESEEABLE AND EXCESS VEHICLE PAYLOADS AS WELL AS OVER-TIGHTENING OF THE U-BOLTS DURING INSTALLATION MAY DISTORT THE BLOCKS, REDUCING THE INTENDED CLAMPING FORCE OF THE U-BOLTS.

Mar 06, 2008 – INTERCONTINENTAL AUTO PARTS IS RECALLING 1,937 FUEL FILTERS, P/NOS ALG 44/1 AND PUROLATOR F10024, SHIPPED BETWEEN JANUARY 14 AND FEBRUARY 13, 2008, SOLD FOR USE ON THE VEHICLES LISTED ABOVE. THE FILTER'S OUTLET CAP MAY NOT BE SECURELY CRIMPED TO THE HOUSING. THIS COULD RESULT IN A SEPARATION OF FILTER'S OUTLET CAP FROM THE HOUSING.