ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES

Mar 06, 2007 — Recall Campaign #07V078000

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

The recall was influenced by the Office of Defects Investigation with about 155,584 units affected.

See recall notice

NHTSA Safety Recall Notice

07V078000

Manufacturer:	Ford Motor Company
Recall date:	March 06, 2007
NHTSA Campaign #:	07V078000
Units affected:	155,584

Description:: ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequeces:: OVERHEATING COULD RESULT IN SMOKE, BURN, OR AN UNDERHOOD FIRE.
Corrective action:: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MARCH 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017, 05V388, AND 06V286)
Notes:: FORD RECALL NO. 05S28. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2003 FORD E-550 Complaints
TL*THE CONTACT OWNS A 2003 FORD E-550. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 43,000.;
2003 FORD EXCURSION Complaints
My wife, two young daughters, and I were traveling out of town for the New Year. As we were traveling southbound on I-85 between Greensboro, North Carolina and Thomasville, North Carolina, I started to notice that the vehicle was starting to vibrate. Over the course of the next +\- 10 miles the vibration became much worse and eventually forced me to get off of the highway. I exited the highway at exit 103 on I-85 southbound (NC-109) and was able to get the vehicle to a National Tire and Battery Shop located at 2 Cloniger Dr, Thomasville, NC 27360. Upon inspection, they noticed a large bulge in the driver side rear tire and told me that they thought that I might have broken a belt inside of the tire. They were able to get it off and put on the full size spare, thus allowing us to get to our destination. I strongly believe that had I not exited the highway when I did, there was a high likelyhood that the tire could have blown thus causing us to crash. With that said, this failure put my entire family at risk. The problem has not been reproduced or confirmed by a dealer or independent service center. The tire has only been inspected by the National Tire and Battery that took it off and replaced it with the full size spare. There were no warning lamps, messages or other symptoms of the problem prior to the failure. The problem started they day of the incident as we were traveling southbound on I-85 between Greensboro, North Carolina and Thomasville, North Carolina. Tire Size - LT 265/75 R 16;
2003 FORD F-150 Complaints
I moved my vehicle from driveway to park on the street so my husband could park in the driveway. I then turned my vehicle off and roughly 2 hours later, a lady came screaming "fire fire fire!" I went to see where she was talking about and my truck was smoking under the hood, I then called the fire department and they came to extinguish the fire. I was unaware of any recalls as I am the 3rd owner of this vehicle.;
2003 FORD F-250 SD Complaints
TL* THE CONTACT OWNS A 2003 FORD F-250 SD. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE FUEL TANK WAS HANGING DOWN. THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND SAW THAT THE FUEL TANK STRAP WAS FRACTURED AND THE FUEL GAUGE WAS DAMAGED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 49,000.;
2003 FORD F-350 SD Complaints
FUEL TANK DELAMINATION LEADING TO STALLING AND EVENTUAL REPLACEMENT OF THE TANK AT MY COST;