2003 FORD F-250 SD Complaints

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE FUEL TANK WAS HANGING DOWN. THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND SAW THAT THE FUEL TANK STRAP WAS FRACTURED AND THE FUEL GAUGE WAS DAMAGED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 49,000.

I HAVE AMERICAN EAGLE - 20 " EAGLE ALLOY WHEELS. THEY ARE APPROXIMATELY 24 MONTHS OLD. THIS SUMMER A SPOKE CRACKED ALL THE WAY THROUGH ON ONE WHEEL. THE DEALER WOULD NOT WARRANTY IT AND I HAD TO PURCHASE A REPLACEMENT. THIS WEEK I NOTICED ANOTHER OF THE WHEELS CRACKED ALL THE WAY THROUGH. I HAVE NOT HIT ANY MAJOR POT HOLES, CURBS OR ANYTHING ELSE. MY TRUCK IS NOT A WORK TRUCK OR USED FOR MUDDING OR OFF ROAD, IT IS A PAVEMENT PRINCESS DRIVEN BACK AND FORTH TO WORK. I AM WORRIED THERE IS A MANUFACTURER DEFECT AND THAT THE WHEELS ARE NOT SAFE.

I HAVE HAD SEVERAL PROBLEMS WITH THE SPARK PLUGS BLOWING OUT OF MOTOR AND BREAKING COIL CAUSING IT TOO LEAK FUEL VAPORS OUT POSSIBLY CAUSING A FIRE THIS HAS HAPPENED SEVERAL TIMES. THREE DIFFERENT CERTIFIED MECHANICS HAVE ADVISED THIS IS CAUSED TO DEFECT IN THE ALUMINUM HEADS FROM FACTORY NOT HAVING ENOUGH THREADS CAUSING THE SPARK PLUG TO BLOW OUT. POSSIBLY CAUSING INJURY OR FIRE. THIS ISSUE NEEDS ADDRESSED AS IT IS A SAFETY CONCERN. WE HAD A SMALL ENGINE FIRE CAUSING SLIGHT DAMAGE TO ENGINE COMPARTMENT THAT HAD TO BE REPAIRED.

TL* THE CONTACT OWNS A 2003 FORD F-250 SUPER DUTY. WHILE ATTEMPTING TO USE THE CRUISE CONTROL, THE VEHICLE SPEED FUNCTION WOULD NOT WORK. THE CONTACT STATED THAT THE SWITCH BECAME HOT AND FAILED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 85,000.

5.4 LITER MOTOR BLOWS SPARK PLUGS OUT OF THE ENGINE, BECAUSE SOME MORON AT FORD DESIGNED AN ENGINE WITH 2 OR 3 THREADS PER PLUG PORT ON ALUMINUM HEADS. FORD IS PAYING A CLASS-ACTION LAWSUIT FOR MODEL YEARS 2004 - 2008, BUT MINE IS A 2003. THANKS FOR THE SCREW-JOB, FORD.

A SPARK PLUG BLEW OUT WHILE ACELERATING FROM A STOP SIGN, THIS HAS HAPPENED 3 SEPARATE OCCASIONS. A SMELL OF UNBURNT FUEL WAS PRESENT WHILE DRIVING TO FORD DEALER FOR REPAIR.

1 OF THE TANK STRAPS BUSTED OFF AND THE TANK BEGAN SAGGING AND ALMOST TOUCHING THE GROUND, THUS CAUSING A SEVERE FIRE HAZARD.

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT NOTICED SMOKE FROM THE REAR OF THE VEHICLE AND THERE WAS A LOUD POPPING NOISE. THE VEHICLE WAS COMPLETELY SURROUNDED BY SMOKE RESULTING IN A FIRE. THE VEHICLE STALLED. THE FIRE WAS EXTINGUISHED INDEPENDENTLY. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE AND WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V553000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 81,000. UPDATED 7/1/15*CN THE CONSUMER STATED THERE WAS NO FIRE, JUST EXCESSIVE PRESSURE IN THE CRANKCASE CAUSING THE ENGINE TO BLOW OIL OUT THE GLOW PLUG. UPDATED 03/31/16.*JB

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE TRANSMISSION HAD TO BE SHIFTED INTO NEUTRAL AND THEN TO DRIVE BEFORE THE VEHICLE WOULD RESUME NORMAL FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP RELAY BOX NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 89,919.

TL* THE CONTACT OWNS A 2003 FORD F-250 EQUIPPED WITH BF GOODRICH ULTRA ALL RANGE TIRES, LINE SIZE: P235/85/R16. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE REAR PASSENGER SIDE TIRE BLEW OUT. THE CONTACT MENTIONED THAT AFTER INSPECTING ALL THE TIRES, HE NOTICED THAT THE TIRE TREAD WAS WEARING PREMATURELY AND HAD STARTED SEPARATING. THE VEHICLE WAS TAKEN TO A TIRE SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE TIRES WERE NOT REPLACED. THE TIRE FAILURE MILEAGE WAS 85,151. THE VEHICLE CURRENT MILEAGE WAS 86,000. UPDATED 03/17/15*LJ UPDATED 08/25/2017*CT