2003 FORD F-150 Complaints

I moved my vehicle from driveway to park on the street so my husband could park in the driveway. I then turned my vehicle off and roughly 2 hours later, a lady came screaming "fire fire fire!" I went to see where she was talking about and my truck was smoking under the hood, I then called the fire department and they came to extinguish the fire. I was unaware of any recalls as I am the 3rd owner of this vehicle.

The contact owns a 2003 Ford F-150 equipped with Firestone Tires, Tire Line: Firestone, Tire Size: 265/70/R17, DOT Number: (N/A). The contact stated that while the vehicle was parked and occupied, there was a burning rubber odor coming from the outside of the vehicle. The contact exited the vehicle to inspect the tires and became aware that the tread of the tires was loose. Neither the dealer nor an independent mechanic was contacted. The vehicle was not taken to the dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 277,144.

UNKNOWN - however there were NO warning lights or any other indication of malfunction or to service the truck. I took the truck to an independent service center & they did a full inspection & I did receive an estimate for repairs.

My husband was shoveling snow off of our vehicles and seen smoke coming from under the hood of his truck. When he opened the hood the truck was on fire on the right side. The truck was turned off when this happened. He threw snow on top of it to put the fire out and unplugged the battery to prevent further fire damage.

Well the passenger side in front seat seat belt needs replaced due to getting stuck after front airbags in dash and steering wheel after deployment from barley tapping a vehicle in front of the truck

The engine continues to shoot out the spark plugs. This is continued to happen with different cylinders. I’ve had it at the mechanic most of the time I’ve owned it.

The contact owns a 2003 Ford F-150. The contact stated that while driving at an undisclosed speed, the steering wheel became inoperable. There was no warning light illuminated. The contact stated that the steering wheel felt very loose and was difficult to turn. The vehicle was restarted. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 175,000.

The contact owns a 2003 Ford F-150. The contact stated that upon attempting to enter the vehicle, the contact became aware that the driver’s and passenger’s side rear doors failed to open after several attempts. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was unknown.

I purchased this F150 in November, 2023. The only code shown was a lean code, P0171. I removed the bed first to begin my inspection. Upon removing the original fuel tank, I discovered a gash in the top of the tank,about 1/8" wide by 3" long. It should have set a code like a missing gas cap would, but there was none. The gash appeared to be several years old due to the rust pitting. I believe the gash was a result of the cross member rubbing against the tank. The previous owner did not mention the defect. Fuel would have spilled out if the tank was completely filled. I did not find any service alerts for this though they may exist. The truck currently has 225k miles.

Our truck has been great but we have a major problem. It is leaking water when it rains. Getting front floor carpet wet and now it is getting the fuse box wet and causing electrical systems to not work. Like today the odometer won't light up. Also dripping from top of windshield. We are having the windshield and seal replaced on Thursday but the glass company says they can't guarantee m of seal will stop the Problem. He said the drain system was factory installed backwards and it's not draining properly.