GM IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES MANUFACTURED FROM JUNE

Nov 08, 2011 — Recall Campaign #11V543000

GM IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES MANUFACTURED FROM JUNE 2, 2011, THROUGH OCTOBER 17, 2011. THE SECOND STAGE OF THE DUAL-STAGE AIR BAG WILL NOT INFLATE IN A SEVERE FRONTAL IMPACT. ACCORDINGLY, THE AIR BAGS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY NO. 208, "OCCUPANT CRASH PROTECTION."

The recall was influenced by the manufacturer with about 1,798 units affected.

See recall notice

NHTSA Safety Recall Notice

11V543000

Manufacturer:	General Motors, LLC
Recall date:	November 08, 2011
NHTSA Campaign #:	11V543000
Units affected:	1,798

Description:: GM IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES MANUFACTURED FROM JUNE 2, 2011, THROUGH OCTOBER 17, 2011. THE SECOND STAGE OF THE DUAL-STAGE AIR BAG WILL NOT INFLATE IN A SEVERE FRONTAL IMPACT. ACCORDINGLY, THE AIR BAGS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY NO. 208, "OCCUPANT CRASH PROTECTION."
Consequeces:: AN IMPROPERLY DEPLOYED AIR BAG WILL INCREASE THE RISK OF INJURY TO THE OCCUPANT.
Corrective action:: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL A NEW FRONT PASSENGER AIR BAG FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 29, 2011. OWNERS MAY CONTACT GMC AT 1-800-462-8782 OR CHEVROLET AT 1-800-222-1020.
Notes:: GM'S RECALL CAMPAIGN NUMBER IS 11302.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Affects the following:

2012 CHEVROLET EXPRESS Complaints
ABS Valve Body / Pump Harness chafed through brake hydraulic line near transmission crossmember. This resulted in a hydraulic leak and loss of brake pedal feel / partial loss of brakes. Fortunately failure occurred in the driveway--I had 4500 Lbs of sailboat trailer hitched to the van and was about to go on a long trip. Design issue. Wiring harness should not be located so as to chafe on hydraulic lines. This is not the first chafe related failure on this vehicle.;
2012 GMC SAVANA 1500 Complaints
ON MY SECOND GMC SAVANNA 1500 VAN, I HAVE DISCOVERED THAT FUEL IS LEAKING OUT THE SIDE OF MY FUEL FILLER PIPE, SLOWLY THEN HEAVILY WHEN I FUEL IT UP. THIS IS THE SAME ISSUE I HAD WITH MY OLD 2003 GMC SAVANNA 1500 VAN. THERE WAS A NATIONAL RECALL ON THE 2003 GMC SAVANNA, YET THERE IS NOT ONE FOR MY 2012. I DID NOT REALIZE THERE WAS A PROBLEM WITH THE FILLER TUBE UNTIL I BROUGHT IT IN FOR SERVICE, TO CHECK THE "CHECK ENGINE" LIGHT. A MONTH AGO, THE ERROR CODE WAS A SMALL EVAP LEAK. THE SERVICE TECHNICIAN SAID THAT THE FILLER TUBE NEEDS TO BE REPLACED SINCE IT IS RUSTED OUT OF THE SIDES. I AM A WHEELCHAIR USER, WHERE I NORMALLY DON'T HAVE TO FILL UP MY TANK. YET, AFTER GETTING THE DIAGNOSIS, I HAD TO FILL UP MY TANK SINCE IT WAS ON EMPTY. WHILE FILLING IT UP, I SMELLED GAS. I THEN NOTICED A PUDDLE FORMING UNDERNEATH THE VEHICLE. I THOUGHT ABOUT STOPPING, YET I WENT SLOWER. THIS DID NOT SLOW DOWN THE RAPID DRIPPINGS. SO I CONTINUED AS USUAL. IT WAS GETTING BIGGER WHERE IT WAS STARTING TO EXTEND BEYOND THE SIDE OF THE VEHICLE. THEN IT WAS NEARLY FILLED UP WHEN I HEAR THE GAS SPILLING OUT ONTO THE LEFT REAR TIRE. I QUICKLY SHUT OFF THE NOZZLE, AND WIPED UP THE EXCESS FUEL OFF THE TIRE.;