2012 CHEVROLET EXPRESS Complaints

ABS Valve Body / Pump Harness chafed through brake hydraulic line near transmission crossmember. This resulted in a hydraulic leak and loss of brake pedal feel / partial loss of brakes. Fortunately failure occurred in the driveway--I had 4500 Lbs of sailboat trailer hitched to the van and was about to go on a long trip. Design issue. Wiring harness should not be located so as to chafe on hydraulic lines. This is not the first chafe related failure on this vehicle.

About 6:45 in the morning on November 10th, the vehicle was in a high-speed. Front end collision with adult cow elk at 70 miles an hour on the freeway, and the airbags failed to deploy in the Van on both front seats and the vehicle was severely damaged. Injuries were sustained.

Vehicle is upfitted as a school bus. Forward fuel tank strap failed in operation. Our company operates more than 100 of these vehicles and we experience a failure of fuel tank straps at a rate of about one vehicle per month. If the 2nd strap would also fail the gasoline tank would become dislodged and present a re hazard. This is even more critical as these vehicles are carrying students as a school bus. We perform visual inspections of the straps at 6 month intervals (per Pennsylvania these vehicles are subject to Semi-Annual State Inspection). There were no symptoms of the problem before this failure. There are never symptoms of the problem.

Vehicle is upfitted as a school bus. Forward fuel tank strap failed in operation. Our company operates more than 100 of these vehicles and we experience a failure of fuel tank straps at a rate of about one vehicle per month. If the 2nd strap would also fail the gasoline tank would become dislodged and present a fire hazard. This is even more critical as these vehicles are carrying students as a school bus. We perform visual inspections of the straps at 6 month intervals (per Pennsylvania these vehicles are subject to Semi-Annual State Inspection). There were no symptoms of the problem before this failure. There are never symptoms of the problem before any failure. Failed fuel tank straps on this were repaired by GM Dealer (Faulkner GMC, 705 Auto Park Blvd, West Chester, PA 19382) (Invoice #677658 - Invoice Date Feb 25 2025).

UNKNOWN...THE VEHICLE VEARED OFF ROAD AN INTO ON COMING TRAFFIC. Did not seam like steering was working properly. The final out come there were 2 deceased operators. In 2 different vehicles. I'm not sure if the recalls were ever repaired.

TL* THE CONTACT OWNS A 2012 CHEVROLET EXPRESS 4500. IN COLD WEATHER, THE DIESEL EXHAUST FLUID (DEF) FROZE, WHICH CAUSED THE VEHICLE TO DECELERATE UNTIL IT EVENTUALLY IDLED. THE DEALER (KUPPER CHEVROLET, 1500 2ND ST NE, MANDON, ND 58554) STATED THAT THEY NEEDED TO KEEP THE VEHICLE IN A HEATED SHOP TO PREVENT THE DEF FROM FREEZING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS ALSO CONTACTED AND WAS UNABLE TO PROVIDE ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 86,000. THE VIN WAS UNAVAILABLE.

HAVE A 2012 CHEVROLET CUT AWAY VAN FOR A SCHOOL BUS USE. STARTED LEAKING GASOLINE OUT OF THE PRESSURE SIDE LINE ON THE FURL MODULE. HAD TO HAVE TOWED TO CHEVY DEALER FOR REPAIRS. THEY HAD TO REMOVE FUEL TANK TO MAKE REPAIRS . THEY REPLACED FUEL MODULE IN THE TANK. THE COST OF REPAIRS WAS 1166.41$.

THE VAN IS A 2012 CUT AWAY SCHOOL BUS. ON 1-20-2018 DEVELOPED A GASOLINE LEAK ON THE VENT SIDE OF THE FUEL MODULE ON TOP OF THE FUEL TANK.TOOK TO CHEVY DEALER FOR REPAIRS. THEY REPLACED THE FUEL MODULE INTHE TANK. THEY HAD TO REMOVE THE TANK TO PERFORM REPAIRS. AT A COST OF 1188.39$.

HAVE 2 2012 CHEVY CUT AWAY VAN SCHOOL BUSES WITH THE FUEL PUMP MODULE START LEAKING. 1 LEAKED ON THE PRESSURE LINE,THE OTHER ON THE VENT LINE. BOTH BUSES HAVE LESS THAN 150000 MILES.

WHEEL BEARINGS AND TIRES ARE BECAUSE OF RE-CALL ON THE TORG IS NOT ALIGN PUT BRAND NEW TIRES ON AND THE TIRES ARE ALREADY BALD IN THE FRONT.