Ford Motor Company is recalling certain 2006-2010 Ford Fusion

Dec 18, 2019 — Recall Campaign #19V904000

Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.

The recall was influenced by the Office of Defects Investigation with about 600,166 units affected.

See recall notice

NHTSA Safety Recall Notice

19V904000

Manufacturer:	Ford Motor Company
Recall date:	December 18, 2019
NHTSA Campaign #:	19V904000
Units affected:	600,166

Description:: Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.
Consequeces:: If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.
Corrective action:: Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing the HCU as necessary. All services will be performed free of charge. The recall began April 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S54.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2010 FORD FUSION HYBRID Complaints
2020 Ford Escape wipers keep stuttering, moving very slowly, freezing midway through cycle, or fail to operate during adverse weather conditions. This results in poor to no visibility sometimes with the wiper blocking vision directly. This is a known recall and Ford has refused to repair the wiper until the unveil their solution for all potentially impacted vehicles. They acknowledge that a wiper motor would repair our vehicle right now but told us to wait for months while they determine a global fix. Recall number we believe is 26S14. Both Ford America and local dealer will not perform work. Communications were via phone call with both dealer and Ford America.;
2010 LINCOLN MKZ Complaints
The contact owns a 2010 Lincoln MKZ. The contact stated that upon starting the vehicle, the ABS and the Traction Control warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the ABS had failed and needed to be replaced. The local dealer was contacted, but the vehicle was not diagnosed and the contact was advised that the VIN was not included in a recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 110,000.;
2010 MERCURY MILAN Complaints
The contact owned a 2010 Mercury Milan. The contact stated that while driving at an undisclosed speed, the vehicle was involved in a crash. The contact stated that the vehicle flipped over and landed on its roof of the vehicle. The air bags did not deploy. The vehicle was towed to a local tow yard. The contact was later taken to the local medical center. The contact sustained pain and bruises to the chest area, the left and right knees from the impact of the steering wheel, the middle back, and the left side hip. A Police report was filed. The vehicle was deemed a total loss by the insurance company. In addition, the contact stated that an unknown recall for the air bag was completed in 2025. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.;