2010 MERCURY MILAN Complaints

The contact owned a 2010 Mercury Milan. The contact stated that while driving at an undisclosed speed, the vehicle was involved in a crash. The contact stated that the vehicle flipped over and landed on its roof of the vehicle. The air bags did not deploy. The vehicle was towed to a local tow yard. The contact was later taken to the local medical center. The contact sustained pain and bruises to the chest area, the left and right knees from the impact of the steering wheel, the middle back, and the left side hip. A Police report was filed. The vehicle was deemed a total loss by the insurance company. In addition, the contact stated that an unknown recall for the air bag was completed in 2025. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.

While driving at low speed performing a turn in a residential area, the vehicle suddenly displayed a “Steering Assist Fault” warning message and the steering wheel became completely locked with essentially no movement possible. I attempted to turn the wheel with extreme force but it would barely move, creating a serious safety hazard. I was fortunately driving slowly at the time. If this had occurred at higher speed or in traffic, it could have caused a crash, serious injury, or even death. Prior to the incident, there had occasionally been a slight amount of unusual tension/resistance felt while turning the steering wheel, although it was minor and inconsistent before the complete failure occurred. The failure happened suddenly while driving normally. The issue appears related to the electronic power steering (EPAS) / steering assist system. Similar steering assist failure complaints and recalls/investigations have existed on related Ford Fusion/Mercury Milan vehicles involving sudden loss of steering assist and steering control concerns. The vehicle is also currently affected by brake recall 19S54/19V904 involving braking performance concerns, increasing overall safety concerns regarding the vehicle. At the time of filing this complaint, the steering issue has not yet received a complete repair or confirmed diagnosis because the manufacturer and dealer stated the VIN is not currently included under steering recall coverage.

I was driving on the freeway and the steering began to stiffen. I got to my destination and decided to check the tires for any ice or snow, thinking that might be why it was difficult to drive but there was no buildup. I made it home and parked the car. The next day, I can't even turn the steering and a warning comes up that says service power steering and advancetrac.

Bought this car less then a year ago with 38k miles and just last week after coming back from vacation my power steering system went while on the expressway. The advancetrac warning light came on and then the service power steering now. The steering wheel was impossible to turn and to make matters worse it was snowing out.

The electric power steering has failed again this will make it twice in 18 months the last time it cost 1800 dollars to fix it know that only some of the 2010 Mercury Milans are on a recall list unfortunately mine is not on that list why because it is absurd that I should I have to make this repair for 1800 dollars again you cant safely drive this car it takes everything I have to turn the steering wheel

The safety recall 19S54 is affecting my vehicle. It was made at the same plant at the approved date range as the other vehicles on the recall list but it seems my vehicle wasnt added to the list because it is a hybrid but it has the same exact issue as the non hybrid models

The contact's mother owns a 2010 Mercury Milan Hybrid. The contact stated that while his mother was attempting to stop, the brake pedal was depressed but went to the floorboard, and the vehicle responded slowly. The ABS warning light was illuminated. The contact related the failure to NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic). The vehicle was taken to an independent mechanic who determined that the Hydraulic Electronic Control Unit (HECU) had failed. The local dealer confirmed that the VIN was not under recall for the failure. The vehicle was not diagnosed or repaired. The manufacturer stated that the vehicle was built a month after the recall date and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 70,000.

The contact owns a 2010 Mercury Milan. The contact stated that while driving approximately 30 MPH, the "Service Traction Control" and “Power Steering Sensor” warning lights illuminated. The contact stated that the steering wheel became difficult to turn to the left or the right. The contact was able to drive the vehicle back to the residence. The local dealer was contacted and sent an agent to the residence to drive the vehicle to the dealer. The vehicle was diagnosed, and it was determined that the power steering assist had failed, and the steering gears and rack, and pinion needed to be replaced. The vehicle was repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 60,562.

I collided with three parked vehicles and my airbags did not deploy causing me to hit my head

The contact owns a 2010 Mercury Milan. The contact stated that while depressing the brake pedal to the floorboard, the vehicle failed to immediately stop. The vehicle was taken to the local brake service center, but the cause of the failure was not yet determined, and the vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 19V904000 (SERVICE BRAKES, HYDRAULIC). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was approximately 140,000.