GENERAL COACH Recalls

Dec 21, 2010 – CHAMPION BUS IS RECALLING CERTAIN VEHICLES BUILT ON FREIGHTLINER S2 CHASSIS AND EQUIPPED WITH TRW IGEN3 INTERMEDIATE STEERING COLUMNS. THE WELD AROUND THE IGEN3 STEERING SHAFT TUBE THAT SECURES THE SPLINE TUBE TO THE INTERMEDIATE TUBE MAY BE MISLOCATED (I.E., NOT FULLY OVER THE SEAM CREATED WHEN THE TUBES ARE PRESSED TOGETHER.)

Feb 25, 2010 – GENERAL COACH IS RECALLING CERTAIN MODEL YEAR 2005-2006 LO-TRANS, MODEL YEAR 2007 EZ-TRANS AND MODEL YEAR 2009-2010 IC-LC BUSES BUILT ON INTERNATIONAL 3200IM CHASSIS MANUFACTURED FROM JULY 2003 THROUGH FEBRUARY 2010. WHEN THE BUSES ARE USED IN A SEVERE DUTY APPLICATION, SUCH AS BUSES IN HEAVY TRANSIT USE, THERE CAN BE OVERHEATING OF THE BRAKES.

Jun 05, 2008 – GENERAL COACH IS RECALLING 1 MY 2000 CORSAIR EXCELLA TRAILER EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

Jul 02, 2007 – ON CERTAIN TRAVEL AND PARK TRAILERS, THE GROSS AXLE WEIGHT RATING (GAWR) ON THE FEDERAL CERTIFICATION LABEL IS INCORRECT.

Dec 23, 2004 – CERTAIN BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, 'BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE.' THE OPERATING INSTRUCTION DECALS FOR THE EMERGENCY LATCHES MAY NOT HAVE BEEN PLACED ON THE EMERGENCY EXIT WINDOWS.

Nov 02, 2004 – ON CERTAIN BUSES EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.

Jun 07, 2004 – CERTAIN BUSES INVOLVED IN THIS CAMPAIGN FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE DRIVER'S SEAT TETHER STRAP WAS NOT INSTALLED.

Nov 12, 2003 – ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Nov 12, 2003 – ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Dec 02, 2002 – CERTAIN TRAVEL TRAILERS AND FIFTH WHEEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS. THESE REFRIGERATORS CAN EXPERIENCE A BREAK DOWN IN A RUBBER SEAL WITHIN THE GAS VALVE. AS THE RUBBER SEAL AGES, A LEAK MAY OCCUR, ALLOWING PROPANE GAS TO ACCUMULATE IN THE BURNER AREA.