VOLVO XC60 Recalls

Feb 28, 2012 – VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60, XC60, S80 AND XC70 VEHICLES MANUFACTURED FROM MAY 16, 2011, THROUGH OCTOBER 6, 2011. IN THESE VEHICLES, THE WIRE HARNESS UNDER THE FRONT SEATS MAY HAVE NOT BEEN ATTACHED PROPERLY TO THE SEAT FRAME. AS A RESULT, WHEN THE SEATS ARE MOVED TO ADJUST THE SEATING POSITION, THE WIRE HARNESS MAY GET PULLED, CAUSING IT TO DISCONNECT.

Nov 22, 2010 – VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.

Nov 17, 2010 – VOLVO IS RECALLING CERTAIN MODEL YEAR 2011, S80, S60, XC70 AND XC60 VEHICLES. THE SOFTWARE CALIBRATION FOR THE FUEL CUT-OFF FUNCTIONALITY IN THE ENGINE CONTROL MODULE (ECM) IS TOO SENSITIVE.

Nov 10, 2010 – VOLVO IS RECALLING CERTAIN MODEL YEAR 2010 XC60 VEHICLES. THE CURTAIN AIR BAGS MAY HAVE BEEN MIS-ASSEMBLED DURING THE MANUFACTURING PROCESS. THIS MAY CAUSE AN AIR BAG TO NOT DEPLOY OR NOT DEPLOY AS INTENDED.

Oct 13, 2010 – VOLVO IS RECALLING CERTAIN MODEL YEAR 2010-2011 S80, XC70, MODEL YEAR 2011 XC60 AND MODEL YEAR 2010 V70 VEHICLES. THERE MAY BE AN INTERMITTENT FAULT IN THE DRIVER'S AIRBAG CLOCKSPRING WIRING CONNECTOR FOR THE SUPPLEMENTAL RESTRAINT SYSTEM.

Dec 15, 2009 – VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES. THE FUEL LINE RAIL COVER THAT PROTECTS THE FUEL LINES UNDER THE VEHICLE MAY NOT BE PROPERLY ATTACHED EXPOSING THE FUEL LINES TO DAMAGE.

Dec 01, 2009 – VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES BUILT WITHOUT THE PANORAMIC ROOF AND DELIVERED TO PUERTO RICO FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."

Nov 18, 2009 – VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES. THE DRIVER'S SEAT SIDE COVER PANEL (SEAT CONTROL PANEL) IN CERTAIN DRIVER'S SIDE IMPACTS MAY RELEASE THE ATTACHMENT OF THE SEATBELT TO THE SEAT FRAME.

Sep 01, 2009 – VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE FUEL PUMP. THE DRIVER MAY BE ABLE TO START THE ENGINE IN SPITE OF THE FUEL PUMP NOT BEING ACTIVATED DUE TO RESIDUAL PRESSURE IN THE FUEL SYSTEM. IN SOME CASES, THE DRIVER MAY BE ABLE TO DRIVE THE VEHICLE A SHORT DISTANCE AT IDLE BUT THEN THE ENGINE MAY STALL.