GENERAL TIRE TIRES Complaints

The suspected failed component is on 3-4 General Altimax GT45 tires. After approximately 15,000 miles of use and regular tire rotations every 5,000 miles, a steering wheel vibration developed immediately following a tire rotation. Multiple tire balances and a road-force balance did not identify a problem or correct the condition. Multiple, independent mechanics advised that the vibration may be caused by an internal tire belt defect, such as a shifted belt or belt separation. After the tires were rotated again, the vibration changed in character and became worse, further suggesting that the condition is related to a tire rather than the vehicle's suspension or alignment. The tires are still available for inspection upon request. The vehicle develops a noticeable steering wheel vibration at highway speeds between approximately 60 and 70 mph. The vibration affects steering feel and driver confidence while operating the vehicle at normal highway speeds. If caused by an internal tire defect, there is concern that the condition could worsen and potentially affect vehicle control or lead to tire failure. Yes, the problem has been reproduced. The vibration has been repeatedly reproduced during normal driving and has been evaluated by multiple independent service centers. The tires were rebalanced multiple times, including road-force balancing, without resolving the vibration. Multiple mechanics advised that the condition appears consistent with a possible internal tire belt defect. After an additional tire rotation, the vibration changed and became more severe, which mechanics indicated is consistent with a tire-related problem moving to a different position on the vehicle. The tires have been inspected by 4 independent service centers and tire technicians. The manufacturer, Continental/General Tire, has not physically inspected the tires. No inspection was performed by police or insurance representatives. No warning lamps or vehicle messages were displayed.

The contact owns a 2020 Chevrolet Silverado LD Crew with General Grabber RST/LT-T1. Tire Size: 255/70R17. DOT Number: A3E8hn002320. The contact stated that while spouse was driving approximately 30 mph they heard a stranger noise and noticed that rear passenger tire had split. The tire was remove and replaced with the spare the contact then stated that a week later contact's husband was driving around 50 mph and abnormal sound was heard again and that is when they noticed that the rear driver side had a blowout. Triple A was contacted and vehicle was towed to their home. The contact stated that they contacted tire manufacturer General and tire manufacturer stated that they would need to contact the dealer, dealer stated that the tires were bad and that General would not assist on replacing the tires. Contact stated tires are original tires of vehicle. Vehicle and tire failure damage was about 40,000.

A shake or shimmy at 49 ,50 mph. Ase mechanic confirmed all four tires belts have shifted.

Tire size is a P275 / 70 / R18 On 10/11/2025 I experienced a belt separation on my driver side rear tire which resulted in a noticeable bulge in the tread area. I had similar issues with two other matching tires in this set and one of them blew out leading to a rapid loss of air. I am sure if I wouldn't have been hyper-aware of early tell tale signs of this potential issue from the previous incidents, this tire may have also blown out on me. This is three out of the five General ATP tires in this set of five that have failed from the same belt separation issue.

DRIVING THE SPEED LIMIT OF 55 ON A PAVED ROAD, NO WEATHER CONDITIONS AND THE REAR DRIVER SIDE TIRE EXPLODED. WHEN THIS HAPPENED THE TRUCK SLID ACROSS THE ROAD INTO THE OTHER LANE. LUCKILY NO ONE WAS COMING IN THE OTHER LANE AND I WAS ABLE TO GET THE TRUCK UNDER CONTROL. THE TIRE WAS FINE, TIRE PRESSURE WAS CORRECT BUT THE ENTIRE TREAD OF THE TIRE FLEW/BLEW OFF AND CAUSED EXTREME DAMAGE TO THE REAR DRIVER SIDE TIRE WHEEL WELL AND BACK BODY PANEL OF THE TRUCK. THE TIRE IS STILL FULL OF AIR AT THE CORRECT PRESSURE TO THIS DAY. THE TIRE SIZE IS LT 275/70 R 18 125/122 R LOAD RANGE E

The contact owns a 2016 Lexus ES350 equipped with General Tires, Tire Line: ReliaTrek, Tire Size: 225/45/R18, DOT Number: VY4FWJ85. The contact stated that while driving 60 MPH, the vehicle was vibrating abnormally. The contact pulled over and called Roadside Assistance. The Roadside Assistance technician made the contact aware of a blowout of the driver's side rear tire. The contact was shown that the entire sidewall had detached from the tread. The spare tire was installed by Roadside Assistance. The contact stated that the tires had recently been purchased by the previous owner however, the contact was unsure of the failure mileage on the tires. The contact had not taken the vehicle to a dealer or independent mechanic. The failure was not diagnosed nor was the tire replaced. The manufacturer was not made aware of the failure. The approximate vehicle failure mileage was 100,000.

Tire 235/55 R-17 99 T. the steering wheel started to shimmy while driving. I took the vehicle into the service shop found that the a section of the tire was indented and the inside of the tire had a bubble. The repair shop stated this was caused by the tread separating. The tire had to be replaced. The tire is 2.5 years old and the tread on the inside was heavily worn while the outside tread was in good shape. The replace tire indicator was still intact. I purchased this tire at the same time i purchased the driver side tire.

While driving home from work at highway speeds in less than 1 minute I went from Total normal Driving Experience to feeling like I had a vibration likely a flat. Luckily it was the back tire so I was able to safely steer off the highway. Upon inspecting the tire it was completely gone! Only minimal sidewall attached to the rim on both inside and outside of the wheel. The sidewall failed approximately 1 in Above the Rim lip. All the way around on both sides. This is on a general gmax as-05 215/50/ ZR 17 purchased in 2021 from tirerack.com. these tires are used seasonally in addition to winter tires so they have minimal miles for being a little over 2 years old. I also recently had the car New York State inspected in the last 30 days. upon reaching out to Tire Rack I learned there was a substantial recall of almost 100,000 continental and general brand tires that were " over cured". This tire is not on the list but did exactly what the description of the recalled tires had done. I do not feel safe traveling on the remaining tires and I feel other people could be in danger of this happening to this model Tire. I just want to keep myself and other safe and feel like I'm going to get stonewalled with a retailer on warranty. Also want to keep others from potential harm as this had happened on my front wheel in the middle of rush hour traffic it could have been disastrous and deadly! Up until this I loved these tires they were sporty, great handling, quiet and wearing very evenly and seem to be long-lasting so far. I hope Continental/general does the right thing by adding this tire to the recall list. Also this car was recently New York State inspected less than 30 days ago there is ample tread and the tires have been diligently rotated and they are only on the car for 7 months at a time as I have a set of General winter tires that I switch between seasonally.

The contact owns a 2006 Honda Accord equipped with General Tires, Tire Line: G-Max AS-05, Tire Size: 215/50/R17, DOT Number: CN6AWD8R4020. The contact stated that while driving at approximately 65-70 MPH, the vehicle was vibrating and making an abnormal sound. The contact pulled over to the side of the roadway. Upon inspection, the contact noticed that the rear passenger's side tire had an inch of tread remaining on the sidewall. The contact replaced the tire with the spare tire. The tire retailer was made aware of the failure. The tire manufacturer was made aware of the failure. The tire failure mileage was approximately 15,000. The vehicle failure mileage was 139,000. The VIN was unavailable.

Driving at 45 mph and rear General Tire Altimax RT43 tire blew out. No accidents or injuries but consider myself lucky as this could of been serious at highway speeds and if a front tire blew out. Tire is available for inspection. Tire shop noticed dry rot in bottom of outer tread grooves and vehicle was garage parked approximately 50% of time. Tire was manufactured in November 9-15, 2020; installed on vehicle on 8-2-21 with 137,739 miles; tire replaced on 8-23-23 with 160,103 miles. Tire had 22,364 miles to failure, and was driven 2 years and 16 days to failure. No low pressure tire warning on vehicle at or before tire blew out. Tire mechanic said all 3 remaining tires had normal pressure. Tire separated into three sections, the thread area, and both sidewalls. Looks like there are safety recalls on various General Altimax RT43 tires due to manufacturing defect from over curing, but this tire size was not mentioned. Tire size is 215/60R16. I have copies of installation paperwork documenting tire DOT number, odometer readings, and install date as well as final replacement paperwork documenting odometer reading and dates.