GOODYEAR WRANGLER ALL TERRAIN ADVENTURE TIRES Complaints

The contact owns a 2017 Ford F-350 equipped with Goodyear Tires, Tire Line: Wrangler All Terrain Adventure, Tire Size: LT275/70/R18, DOT Number: (N/A). While the contact's friend was driving 55 MPH, there was a blowout of the rear passenger’s side tire. The driver prevented a crash; however, the failure caused a significant amount of damage when the truck bed lowered and nearly separated from the chassis, the hubcap detached, and the exhaust pipe was bent in half. The driver pulled over to a truck stop and installed the spare and secured the truck bed to the frame with harness straps to prevent the truck bed from separating. The contact notified the manufacturer about the failure and requested that the tire be shipped for inspection to determine any potential liability. The contact had not yet submitted the tire or any documentation to the manufacturer. The failure mileage was approximately 10,000.

Goodyear Wrangler All-Terrain Adventure, LT265/70R18. On [XXX] at 113806 miles, I discovered that the driver's side front tire on the vehicle was flat in my driveway. Investigation revealed a puncture in the tread of the tire, caused by a gravel stone still lodged in the tire. Based on the amount of protrusion of the stone and the lack of any visible wear on it, I concluded that the stone must have originated in my gravel driveway when returning home the night before. The tire had been installed on 6/20/2023 at 104513.5 miles, being in service for 1 year and 9293 miles, not even 20% into its expected life. Initial assessment of the damage to the tire, including the puncture size and longitudinal shape, suggests that repair will not be feasible and the tire will require replacement. While a flat tire due to foreign objects is commonplace, the safety concern here is that a simple small stone from a gravel driveway should not have been able to cause the failure of a 'Kevlar reinforced' all-terrain truck tire. I believe the materials or construction of these tires may be defective and may have insufficient tensile strength in the tread material, causing them to yield and fail at much lower forces than are to be expected from tires in highway use. At any rate a well-packed gravel driveway that has been in use for many years should not be a challenge to the safety and performance of a truck tire rated for highway use. This tire failure comes less than a month and 1000 miles after a more dramatic and catastrophic failure of another tire of the same model on the same vehicle. While coincidence cannot be ruled out, two failures of the same model tire, both related to weak or defective tread sections, points to possible defects that should be investigated. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Goodyear Wrangler All-Terrain Adventure, LT275/70R18 Tire installed new on [XXX] at 79892 miles. Tires were properly maintained including proper inflation and rotated. On [XXX] at 112745 miles the driver side rear tire suffered a sudden and catastrophic tread separation failure. At the time of failure, tire had been in service for 33 months and 32,853 miles, and had significant tread life remaining. Vehicle was travelling at approximately 55 mph on an asphalt highway on a hot, dry day. The separated tread damaged the rear body panel and severed the body structural support member in half. The vehicle was brought to a controlled stop, the separated tread was retrieved from the roadway, and the spare tire was installed. The tire was replaced the following day. Given that the tire was only about 50-60% into its usable life and well within the 50,000 mile warranty, this failure was unexpected. Goodyear has not provided any method to contact them directly and instead referred me to local retailers who have been unable to process the warranty claim. A second, much newer tire of the same model on the same vehicle failed in a different manner just 3 weeks and 1000 miles later, causing me concern of structural or material defects with these tires. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

LT275/70R18 E While driving west on I10 near Thermal California, the rear driver side tire lost 100% of its thread at a 65 MPH speed. When the thread separated from the tire it damaged fender area of the truck extensively and caused a violent throw and shake of the rear of the truck. The interesting fact is that even after losing 100% of the thread he tire steel belts exposed the tire stayed inflated at 80PSI. This fact is know because I was actively monitoring TPMS tire pressure while safely pulling over. The tries were inspected and pressure levels were checked prior taking off for the trip to Thermal CA to pick up the family 5th wheel camper. These tires supposed to have a thread life of 60,000 miles, mine had reached 32000 miles. At this point there is a huge concern and low confidence in Goodyear brand tire and this may happen to the other tires on my truck and may happen under the load of the 35 foot family RV. No one was injured, and no one reproduced this problem and the manufacturer hasn't yet inspected the tire. As it was stated there was zero warning from TPMs system prior to the failure.

A severe crack formed around the full circumference of tire near where the sidewall joins to the tread. The tire started leaking air and the severe crack was found while mounting the spare tire. The crack was present on the inside of the tire and therefore not visible until the wheel was removed. This crack was on its way to a catastrophic failure of the tire. The crack was found at 23500 miles on a tire with claimed treadlife of 60,000. This was the tire sold with my new 2019 Tacoma: Goodyear Wrangler AT Adventure with Kevlar 265/70R16. The Toyota dealership said to take the problem to GY but GY has no recall on this tire and I do not want any new GY tire if offered a replacement.