2003 BMW 325I Complaints

TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT STATED THAT THE EXTERIOR TAIL LIGHTS BURNED THROUGH THE HOUSING HARNESS. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THE CONTACT THAT HIS VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING: TAIL LIGHTS). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 60,250.

THE REAR STOPLIGHTS, TAILLIGHTS, AND TURN SIGNALS HAVE FAILED ON MULTIPLE OCCASIONS. *TR

TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT STATED THAT THE TAIL LIGHTS FAILED INTERMITTENTLY AND WOULD SHUT OFF WHILE DRIVING WITHOUT WARNING. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:TAIL LIGHTS) BUT WAS ADVISED BY THE DEALER ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 73,346 AND THE APPROXIMATE FAILURE MILEAGE WAS 65,000. THE VIN WAS UNAVAILABLE.

XENON LIGHTS WENT OUT SHORTLY AFTER THE 50,000 MARK. SHORTLY AFTER CAR KEPT GOING INTO FAIL SAFE MODE, KEPT GETTING LOW VOLTAGE READINGS ON DIAGNOSTICS. ONE BMW DEALERS KEPT TELLING ME I NEEDED TO REBUILD TRANSMISSION. ALL THEY WOULD DO IS PLUG THE CAR INTO THE COMPUTER AND SEE THE TRANNY READING ON THE SCANNER. THE REASON THERE WAS A TRANNY READING WAS BECAUSE THE CAR WAS IN FAIL SAFE MODE. I EVENTUALLY HAD THE TRANNY REBUILT AND I STILL HAD THE SAME ISSUE. I WOULD CYCLE THE IGNITION AND RESTART THE CAR AND CAR WOULD DRIVE FINE. IT KEEPS GOING INTO FAIL SAFE MODE EVERYTIME I START THE CAR. ITS HARDER TO GET IT OUT OF FAIL SAFE MODE IN THE WINTER WITH COLDER STARTS. *TT

TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT STATED THAT THE VEHICLE WOULD EXHIBIT AN ABNORMAL GRINDING WHEN THE BRAKES WERE DEPRESSED. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED THAT THE BRAKES AND THE ROTORS FAILED. THE BRAKE SENSOR LIGHT NEVER ILLUMINATED TO WARN THE DRIVER THAT THE PADS NEEDED TO BE REPLACED AND THE DEALER WAS UNSURE AS TO WHY THE WARNING LIGHT NEVER ILLUMINATED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 84,000.

MY 2003 BMW 325I SEDAN WAS T-BONED ON DRIVERS SIDE DOORS, AND SENT ACROSS THE INTERSECTION AND SMASHED INTO UTILITY POLE ON REAR PASSENGER SIDE WITH ENOUGH FORCE TO BEND THE FRAME. NO SIDE OR CURTAIN AIR BAGS DEPLOYED. OTHER DRIVER RAN A RED LIGHT AT ABOUT 40 MPH AND NEVER HIT THE BRAKES. MY HEAD SLAMMED TO THE TOP OF THE DRIVER'S DOOR WHERE AN AIR BAG SHOULD HAVE BEEN, CAUSING SWELLING AND NUMBNESS TO THIS DAY. THE DOOR SLAMMED INTO MY ENTIRE LEFT SIDE WHERE THE AIR BAG IN THE DOOR SHOULD HAVE BEEN. I WAS WEARING A SEAT BELT. THE CAR IS TOTALED. BMW IS SENDING AN ENGINEER TO EXAMINE THE CAR IN A FEW DAYS. *TR

THE DOORS WILL NOT UNLOCK IN MY 2003 325I 4 DOOR SEDAN. APPARENTLY, A MODULE GOES BAD AND COULD TRAP PEOPLE IN THE CAR WITH NO WAY TO GET OUT. *KB

GROUND WIRE ON REAR LIGHT WIRING HARNESS HAS BURNT THROUGH DAMAGING PLUG AND SOCKET. POTENTIAL FOR FIRE. UPDATED 09/07/11 *BF *TR

MY CURRENT VEHICLE IS A 2003 BMW 325I WITH BI-XENON HEADLIGHTS MANUFACTURED BY ZKW. OVER THE LAST YEAR OR TWO, THE LIGHT OUTPUT FROM THE XENON HEADLIGHTS HAD DROPPED TO THE POINT WHERE I GET ALMOST NO NOTICEABLE ILLUMINATION OF THE ROAD AT NIGHT (IN AVERAGE CITY LEVELS OF STREET ILLUMINATION). I TURNED TO USING MY FOGLAMPS TO BE ABLE TO SEE ANYTHING. AFTER RESEARCHING THIS PROBLEM ON ONLINE FORUMS, I EXAMINED THE HEADLIGHTS MYSELF AND FOUND THAT THE UPPER PORTION OF THE PROJECTOR BOWLS SEEM BURNED. THEY ARE MADE OF PLASTIC AND PAINTED WITH REFLECTIVE PAINT, BUT THE UPPER ~40% OF THE BOWL IS NOW BROWNED AND NONREFLECTIVE. APPARENTLY THIS IS DUE TO AN INABILITY OF THE PAINT TO WITHSTAND THE HIGH TEMPERATURES GENERATED BY THE XENON BULBS. ALSO, THIS SEEMS TO BE COMMON TO MANY/ALL ZKW BRAND HEADLIGHTS UTILIZED IN 2003-2004 MODEL YEARS OF 3 SERIES (E46) BMW VEHICLES, ACCORDING TO POSTINGS ON THE BMW-OWNER FORUMS. FOR NOW, I HAVE TRIED TO REMEDY THIS BY LINING THE BURNT PORTION OF THE BOWL WITH ALUMINUM FOIL AND CAN NOW NOTICE SOME ILLUMINATION OF THE ROAD AT NIGHT. THIS FURTHER ARGUES THAT THE BURNING/LOSS OF REFLECTIVE COATING IS WHAT CAUSES THE LOSS OF LIGHT OUTPUT. *TR

BRAKE LIGHTS AND TURN SIGNALS RANDOMLY NOT WORKING. 2003 BMW 325I. REPLACED LIGHT BULBS AND NOTICED BURNT WIRES AND LIGHT SOCKETS. RESEARCHED REPAIR AND FOUND NUMEROUS OTHER OWNERS OF SAME YEAR AND MAKE VEHICLE WITH SAME ISSUE. *TR