2002 BMW 325XI Complaints

BMW 2002 325XI AT LOW TEMPERATURES LIKE 5 OR 6 F. THE CRANKCASE VENT VALVE FROZE AND THE HIGH PRESSURE BUILT UP CAUSED THE VALVE TO BLOW AND COUPLE OF GASKETS BURNT. OIL SPILLED OVER TO THE EXHAUST CAUSING SMOKE COMING OUT OF THE ENGINE COMPARTMENT. IF DRIVEN COUPLE OF MORE MILES THE CAR WOULD HAVE BEEN ON FIRE. THE CAR JUST HAS 67000 MILES WHICH IS FAIRLY LOW MILES AND NEW CAR. ALL THE MECHANICS I TALKED TO QUICKLY RECOGNIZED THE PROBLEM AND ASKED ME NOT TO DRIVE AT ALL. THEY SAID IT CAN CATCH FIRE IF DRIVEN LITTLE MORE. ITS A COMMON PROBLEM THAT MOST OF THE MECHANICS RECOGNIZE AND FREQUENCY IS HIGH BUT IN COLD STATES NOT IN WARMER STATES. *TR

THIS IS FOR A POTENTIAL FIRE HAZARD OR POSSIBLE REAR END ACCIDENT DUE TO A KNOWN FAILURE IN THE TERMINAL BLOCK ON THE TAIL LIGHTS. *TR

DT*: THE CONTACT STATED VEHICLES TIRES BLEW OUT ON SEVERAL OCCASIONS. DURING ONE OF THE INCIDENCES, THE VEHICLE HIT A POTHOLE ON THE HIGHWAY TRAVELING AT 65 MPH BEFORE THE TIRE BLEW OUT. ON ANOTHER OCCASION, THE VEHICLE WAS TRAVELING 35 MPH IN RESIDENTIAL AREA WHEN A POTHOLE CAUSED ANOTHER BLOWOUT. THE TIRES HAVE BEEN REPLACED MORE THAN NINE TIMES BY AN INDEPENDENT TIRE COMPANY WHO DETERMINED PROBLEMS WERE WITH THE SIDEWALLS. THE CONTACT EXPRESSED THAT THE TIRES ARE DEFECTIVE. THE DEALERS AND MANUFACTURER WERE CONTACTED BUT OFFERED NO RESOLUTION. UPDATED 7/18/2006 - *NM

(1) PARKED AT A LIGHT. (2) LIGHT CHANGED, I ACCELERATED, THE ENGINE LOST POWER, VARIOUS DASH WARNING LIGHTS CAME ON, I NURSED THE CAR THROUGH THE INTERSECTION, AND PULLED OVER. TURNED THE CAR OFF, RESTARTED, DASH WARNING LIGHTS CAME ON AGAIN. AFTER TALKING WITH THE SERVICE DEPARTMENT I REACHED THE CONCLUSION THAT THE CAR WAS DRIVEABLE. WARNING LIGHTS STAYED ON BUT ENGINE POWER WAS BACK AND I WAS ABLE TO GET THE CAR HOME. (3) DEALER RESEARCHED THE PROBLEM AND FOUND A SERVICE BULLETIN WHICH EXPLAINED THE ENGINE FAILURE AS AN ELECTRICAL FAULT INVOLVING "DEFECTIVE CRIMPING" IN THE THROTTLE MOTOR, RESISTENCE FLUCTUATION DUE TO PIN CONTAMINATION, OR "FAULTY CRIMPING OR DEFECTIVE FEMALE PINS" ON A CONNECTOR. WIRING HARNESS AND THROTTLE MOTOR WERE REPLACED.*AK

PROBLEMS WITH VEHICLE'S TIRE EQUIPMENT.*MR THE CONSUMER HAS REPLACED FOUR TIRES BECAUSE OF BLOWOUTS INCURRED WHEN HITTING POTHOLES. (GOODYEAR EAGLE RS-A, HIGH PERFORMANCE TIRES). *NM

WHILE DRIVING 50 MPH DRIVER RAN OVER PIECES OF DEBRIS ON THE HIGHWAY AND BOTH FRONTAL AIR BAGS WENT OFF INADVERTENTLY. DRIVER SUSTAINED HEAD AND BACK INJURIES , AND WAS TRANSPORTED BY AMBULANCE TO THE HOSPITAL. VEHICLE WAS TOWED TO THE DEALER. *AK

VEHICLE HAD 2 GOODYEAR TIRES, WHERE THE SIDEWALL HAD BLOWN OUT WHILE DRIVING AT A MODERATE SPEED. OLD TIRES WERE THROWN OUT, THEREFORE THE D.O.T. # FOR THE TIRES WERE UNAVAILABLE. PROVIDE FURTHER DETAILS. *PH

THE SEAT BELT LATCH TRIGGERED THE AIR BAG DEFAULT AND THE AIR BAG HAD BECOME INOPERATIVE. THE SERVICE CHECK FAILED TO CORRECT THE PROBLEM. EVEN THOUGH THE SYSTEM WAS CLEARED, DEFAULT/INOPERATIVE AIR BAG OCCURRED WITH THE NEXT SEAT BELT LATCH. (MODEL 325XI) *JB *SCC *JB

DRIVING ON INTERSTATE-95 IN NEW YORK I FELT A VIBRATION START IN THE BACK OF THE CAR WHICH GREW VERY QUICKLY. I PULLED OVER TO FIND THE RIGHT REAR TIRE FLAT. I FOUND THE TIRE HAD A SLIT IN THE SIDE WALL HALF WAY AROUND THE TIRE WITH A GAP BETWEEN THE TREAD AND THE BODY CORE OF THE TIRE. IT APPEARS THAT THE TREAD STARTED TO SEPARATE FORM THE TIRE. I CHECK THE TIRE PRESSURES REGULARLY AND KEEP THEM AT THE MANUFACTURES RECOMMENDED PRESSURES. *JB