2005 BMW 330I Complaints

TL* THE CONTACT OWNS A 2005 BMW 330I. WHILE DRIVING AT NIGHT, THE HEADLIGHTS ILLUMINATED EXTREMELY DIMLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE REFLECTOR INSIDE THE HEADLIGHT HOUSING MELTED AND CAUSED THE LIGHT TO ILLUMINATE DIMLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000...UPDATED 01/21/15 *BF UPDATED 9/11/2017*CN

THE PROJECTOR BOWLS ON MY 2005 E46 330I SHOW SIGNS OF BURNING. THIS PROBLEM SEEMS TO AFFECT ALL E46 MODELS WITH ZKW XENON HEADLIGHTS. THE BURN BOWLS EFFECT THE LIGHT OUTPUT OFTEN RESULTING IN A POORLY LIT VIEW OF THE ROAD AHEAD. *TR

PURCHASED THE CAR IN APRIL 2012. NOTICED THAT THE XENON HEADLIGHTS WERE NOT OUTPUTTING AS MUCH LIGHT AS I THOUGHT THEY SHOULD. INSPECTED THE AREA BEHIND THE HEADLIGHTS (THE REFLECTIVE BOWLS) AND DISCOVERED THAT THEY WERE BURNED. UPON RESEARCHING ONLINE, I HAVE FOUND THAT THIS IS A COMMON PROBLEM FOR THE ZKW XENON EQUIPPED BMW 3 SERIES (E46) VEHICLES, AND THE NHTSA HAS MANY COMPLAINTS ABOUT THIS PROBLEM ALREADY. THIS IS A SAFETY DEFECT IN MY MIND. HEADLIGHT REFLECTORS SHOULD NOT BURN FROM THEIR DESIGNED USAGE. THIS WILL COST THOUSANDS OF DOLLARS TO REPLACE THE HEADLIGHT ASSEMBLIES. BMW SHOULD ISSUE A RECALL FOR THIS SERIOUS PROBLEM . *TR

TL* THE CONTACT OWNS A 2005 BMW 330I. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE HEADLIGHTS WERE ACTIVATED BUT APPEARED VERY DIM. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THE TECHNICIAN STATED THAT THE HEADLIGHT ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 130,000.

ZKW BRAND XENON HEADLIGHTS - THE BACK OF THE PROJECTOR BOWL IS MADE OF PLASTIC (VS. METAL IN THE AL/BOSCH BRAND, ALSO USED BY BMW), WHICH OVER TIME BURNS FROM THE HEAT PUT OUT BY THE HEADLIGHTS. THE BURN TURNS THE PLASTIC FROM WHITE TO BROWN/ORANGE, WHICH SEVERELY REDUCES LIGHT OUTPUT, MAKING NIGHT DRIVING DANGEROUS. THE HEADLIGHT FROM MY CAR IS SO POOR THAT AT NIGHT I CAN SEE THE SHADOW OF MY CAR PRODUCED FROM CARS BEHIND ME. SEVERE TIRE DAMAGE HAS BEEN CAUSED DUE TO POOR LIGHT. *TR

DASH MOUNTED WARNING LIGHT INDICATED TAIL LIGHT ISSUES. CHECKED THE LIGHT AND ALL THE BULBS WERE FINE BUT THE ENTIRE TAIL LIGHT WAS NOT WORKING. I THEN NOTICED THE THE BROWN WIRE IN THE CONNECTOR HAD MELTED THROUGH THE CASE AND WAS TOUCHING OTHER WIRES IN THE CONNECTOR WHICH CAUSED IT TO SHORT OUT THE ENTIRE LIGHT. THE BROWN WIRE HAS VISIBLE SIGNS OF MELTING. I HAVE SINCE FOUND OUT THAT THIS IS A COMMON PROBLEM WITH MY TYPE BMW AND A RECALL HAS BEEN ISSUED. RIGHT NOW MY VIN NUMBER DOES NOT FALL UNDER THE NOTICE BUT I HAVE NO TAIL LIGHTS. *KB

TL* THE CONTACT OWNS A 2005 BMW 330I. WHILE PARKED, THE CONTACT NOTICED THAT THE EXTERIOR LIGHT WARNING GAUGE WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT REPLACED THE EXTERIOR LIGHTING BULBS BUT THE FAILURE CONTINUED INTERMITTENTLY AND BECAME MORE CONSTANT OVER TIME. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:BRAKE LIGHTS). THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. UPDATED 11/28/11 *BF THE CONSUMER STATED BOTH REAR LAMPS STOPPED FUNCTIONING, INCLUDING THE TAIL LIGHTS AND TURN SIGNALS. UPDATED 11/30/11

REAR TAILLIGHTS INTERMITTENTLY WORK. NOTICED THAT THE REAR CONNECTORS, SPECIFICALLY THE GROUNDING WIRE WAS MELTED. THE TURN SIGNALS WILL INTERMITTENTLY NOT TURN ON. *TR

TL* THE CONTACT OWNS A 2005 BMW 330I. WHILE DRIVING APPROXIMATELY 30 MPH, THE REAR TAIL LIGHT ASSEMBLY WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE REAR TAIL LIGHT CONNECTING WIRES WERE MELTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:TAIL LIGHTS) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

ZKW BRAND XENON HEADLIGHTS - THE BACK OF THE PROJECTOR BOWL IS MADE OF PLASTIC (VS. METAL IN THE AL/BOSCH BRAND, ALSO USED BY BMW), WHICH OVER TIME BURNS FROM THE HEAT PUT OUT BY THE HEADLIGHTS. THE BURN TURNS THE PLASTIC FROM WHITE TO BROWN/ORANGE, WHICH SEVERELY REDUCES LIGHT OUTPUT, MAKING NIGHT DRIVING DANGEROUS. I DON'T FEEL COMFORTABLE DRIVING AT NIGHT UNLESS MY HI-BEAMS ARE ON, WHICH IS HARD TO PULL OFF UNLESS I'M THE ONLY CAR ON THE ROAD. THIS ISSUE IS MOST PREVALENT IN 2002-2005 3 SERIES SEDANS, AND THE ISSUE IS WELL DOCUMENTED IN THE BMW COMMUNITY. *KB