2005 BMW 330I Complaints

ZKW REFLECTORS ON HID HEADLIGHT ASSEMBLY DEGRADE, GREATLY REDUCING THE HEADLIGHT EFFICIENCY AT NIGHT. THE PLASTIC OF WHICH THE REFLECTOR BOWLS ARE MADE DEGRADES FROM HEADLIGHT HEAT, AND THE REFLECTIVE COATING BURNS. *TT

IN 2002-2005 BMW 330I SEDANS WITH THE XENON HEADLIGHT FEATURE, BMW OPTED TO USE ZKW BRAND HEADLIGHT ASSEMBLIES INSTEAD OF AL/BOSCH BRAND ASSEMBLIES. THE ZKW BRAND ASSEMBLIES HAVE PLASTIC PROJECTOR REFLECTOR BOWLS WHEREAS THE AL/BOSCH ASSEMBIES HAVE METAL PROJECTOR REFLECTOR BOWLS. AS A RESULT OF CONSTANT HEAT AND CONCENTRATION OF THE XENON BULB ON THE PLASTIC PROJECTOR BOWL, THE REFLECTIVE SURFACE BEGINS TO DETERIORATE. SOON ENOUGH (AFTER A FEW YEARS OF USE) THE BOWLS RECEIVE BROWN/BLACKISH BURN MARKS FROM THE CONCENTRATION OF LIGHT. THE BURN MARKS NO LONGER REFLECT THE XENON LIGHT AND CAUSE THE OUTPUT FROM THE XENON ZKW HEADLIGHT ASSEMBLY TO BE FAINTER THAN ORIGINAL STATE. NUMEROUS INDIVIDUALS ON THE BMW CAR FORUMS HAVE EXPERIENCED SIMILAR PROBLEMS AND HAVE MADE NOTE THAT THIS IS THE CAUSE OF THEIR FAILURE. NOTE: SOME 2002-2005 330I SEDANS DID COME WITH AL/BOSCH BRAND HEADLIGHT ASSEMBLIES. *KB

CAR PULLS SEVERELY WHEN BRAKING AND MILDLY TO MODERATELY WHEN DRIVING. HAVE ASKED FOR ALIGNMENT AND HAD ALIGNMENT CHECKED SEVERAL TIMES BUT TOLD THAT CAR IS NOT OUT OF ALIGNMENT. *TR

CAR PULLS SEVERELY TO THE LEFT OR RIGHT WHEN BRAKES ARE APPLIED. I HAVE HAD THE CAR SERVICED AND ASKED FOR AN ALIGNMENT SEVERAL TIMES BECAUSE OF THIS ISSUE. I WAS TOLD THAT NO ALIGNMENT WAS NEEDED BUT NO EXPLANATION AS TO WHY THE CAR PULLED WAS GIVEN. *TR

I HAVE A 2005 330I BMW AND THE SEATBELT/AIRBAG SENSOR HAVE BEEN LIGHTING UP. I TOOK IT TO THE BMW DEALERSHIP AND THEY SAID THAT IT IS AN INTERNAL ERROR IN THE SEATBELT SENSOR OF THE PASSENGER SIDE. I UNDERSTAND THAT THIS IS A RECALL ISSUE AS STATED BY BMW AND I WOULD LIKE TO HAVE IT REPAIRED AS SOON AS POSSIBLE. THE MODEL PRODUCTION # IS KM42802.*TR

DT: THE CONTACT DROVE OVER A POTHOLE THAT WAS TWELVE INCHES IN DIAMETER, AND BOTH SIDE CURTAIN AIRBAGS ON THE DRIVER'S SIDE DEPLOYED. THE FRONT PASSENGER SIDE TIRE WENT FLAT AFTERWARDS. THE CONTACT FELT THAT THE AIR BAGS SHOULD NOT HAVE DEPLOYED. SHE WAS NOT CONCERNED ABOUT THE TIRE. SHE STATED THAT THE AIR BAGS CAUSED HER TO HAVE A HEADACHE AND RING IN EAR. IT WAS A LOANER VEHICLE. *AK

RE DEFECTIVE BRAKING/STEERING IN A 2005 BMW, REQUESTING A DEFECT INVESTIGATION. *BF THE CONSUMER STATED THE VEHICLE PULLED TO THE LEFT OR RIGHT UPON STOPPING. IN ONE CASE, THE VEHICLE PULLED SO SEVERELY THAT IT CAME TO A REST AT AN ANGLE ON THE ROAD. THE WHEEL COULD NOT BE STRAIGHTENED UNTIL THE BRAKE HAD BEEN RELEASED. *JB