2004 BMW 5 SERIES Complaints

I OWNED A 2004 BMW 525I E60 HAD "ACTIVE STEERING FAULT CAME ON AT ALL TIME .THE DEALER WANTS 4000USD TO FIX THE PROBLEM BUT THE STEERING CONTROL IS FINE . I BELIEVE THIS ISSUE HAD RELATED TO STEERING ANGLE SENSOR DEFECTIVE FROM BMW FACTORY AND DEALERS IN US DID NOT WANT TO FIX THIS MANUFACTURING DEFECTS. THIS PROBLEMS HAD HAPPENED TO ALL BMW'S . ALL OVER THE BLOGS .CUSTOMERS HAD FILED A COMPLAINT ABOUT THIS ISSUE. PLEASE LOOKING INTO THIS PROBLEM(S). *TR

VEHICLE LUNGES FORWARD AT LOW SPEEDS SUCH AS PARKING; 4 TIMES IN THE LAST MONTH, WHEN I AM PULLING OUT OF A PARKING SPACE, THE VEHICLE HAS LUNGED FORWARD. 2 OF THOSE 4 TIMES, I ALMOST HIT THE VEHICLE IN FRONT OF ME. I HAD SHIFTED FROM REVERSE, TO DRIVE, AND JUST TAKEN MY FOOT OFF OF THE BRAKE, AND THE VEHICLE JUMPED FORWARD. THE DEALER HAS CONTINUED TO SAY THAT THINGS ARE OK AND NORMAL. THEY ARE NOT NORMAL. ADDITIONALLY, I HAVE OTHER SHIFTING ISSUES BELOW: --35MPH (5TH TO 6TH HESITATION) 5-6 HARD SHIFT (SPORT MODE GOING 45-55 MPH) SLOW TO ENGAGE REVERSE -- GEAR SHIFTING IN GENERAL IS JUST SLOPPY (THE LOANER THAT THE DEALER PROVIDED, SHIFTED GREAT). *TR

TL* THE CONTACT OWNS A 2004 BMW 545I. THE CONTACT STATED THAT HE NOTICED THAT THERE WERE VARIOUS WARNING LIGHTS THAT ILLUMINATED ON THE INSTRUMENTAL PANEL. HE STATED THAT THE VEHICLES I-DRIVE WOULD MALFUNCTION CAUSING THE RADIO TO FAIL, GPS, AND HE WAS UNABLE TO MAKE PHONE CALLS FROM THE VEHICLE. THE SPEEDOMETER ALSO DISPLAYED 0 INSTEAD OF THE ACTUAL MPH THAT WAS BEING DRIVEN. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 88,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A BMW 2004 545. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 10V446000 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM) YET THE VACUUM PUMP WAS STILL LEAKING. THE DEALER ADVISED THAT THE ENTIRE VACUUM PUMP WOULD NEED REPLACING. THE CONTACT CALLED THE MANUFACTURER REGARDING THE RECALL REPAIR AND THEY ADVISED THAT THEY WERE UNABLE TO ASSIST. THE CONTACT WAS NOT SATISFIED WITH THE RECALL REMEDY AND STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 93,570.

IT WAS A RECALL FOR BRAKE FLUID PUMP CHECK VALVE OIL LEAK, AND THEY REPLACED VACUUM HOSE, DID NOT FIXED FLUID LEAK . FLUID IS STILL LEAKING A SMALL AMOUNT.

TL* THE CONTACT OWNS A 2004 BMW 545. THE CONTACT STATED THAT THE AIR BAG AND PASSENGER RESTRAINT LIGHTS WERE ILLUMINATING ON THE DASH BOARD. THE CONTACT TOOK THE VEHICLE TO A DEALER AND WAS TOLD THAT THE PASSENGER SEAT OCCUPANT DETECTION MAT FAILED. THE DEALER STATED THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 08V384000 (AIR BAGS: FRONTAL), BUT THE VEHICLE WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 78,000 AND THE CURRENT MILEAGE WAS 80,200.

WITHIN THE PAST 6 MONTHS OF DRIVING, MY AIRBAG FOR THE PASSENGER SIDE HAD TRIPPED THREE TIMES. THE THIRD TIME I BROUGHT IT IN, I RESEARCHED ON A RECALL FOR THE PASSENGER SENSOR. I PRINTED OUT THE PAGE FROM SAFERCAR.GOV, AND THEY TOLD ME THAT MY VIN# DOES NOT FALL UNDER THE CATEGORY. THE RECALL SPECIFICALLY STATED FOR MY BMW 545I 2004. I AM NOT HAPPY DUE TO THE FACT THAT YOU BUY A CAR AND FOR SOMETHING THAT CANNOT WEAR OUT BRAKES... *TR

FIRE: TL* THE CONTACT OWNS A 2004 BMW 545I. WHILE DRIVING APPROXIMATELY 40 MPH WITH THE DRIVER SIDE SEAT HEATER ENGAGED, THE CONTACT BEGAN TO SMELL AN ABNORMAL BURNING ODOR AND THE SEAT BEGAN SMOKING. THE CONTACT SHUT OFF THE HEATER AND NOTICED A BURNED HOLE IN THE SEAT. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS ADVISED OF NHTSA CAMPAIGN ID NUMBER: 04V575000 (SEATS: FRONT ASSEMBLY: SEAT HEATER/COOLER) HE THEN CONTACTED THE MANUFACTURER AND WAS ADVISED THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 66,000 AND THE CURRENT MILEAGE WAS 66,600.

TL* THE CONTACT WOULD LIKE TO USE HIS SUBMITTED EMAIL AS THE ACTUAL COMPLAINT. OUR 2004 BMW 530I HAD THE DRIVER'S HEATED SEAT CATCH FIRE. I AM NOT GETTING MUCH HELP FROM BMW ON THIS MATTER. TO ME, THIS IS ONE HELLUVA OF AN EASY WAY TO CAUSE A MAJOR ACCIDENT. ONLY BECAUSE OF MY PARTNER'S QUICK THINKING AND TURNING OFF THE HEATER WAS SHE ABLE TO STOP THE FIRE. IT WAS HOT ENOUGH THAT IT MELTED THE FOAM (TOXIC I AM SURE) IN THE SEAT. SOMETHING LIKE THIS HAPPENING WHILE YOU ARE GOING DOWN THE ROAD IS RIGHT UP THERE WITH TOYOTA AND THEIR ACCELERATION PROBLEMS. EITHER WAY A MAJOR ACCIDENT CAN HAPPEN. NOT TO MENTION THAT A PERSON COULD BE SEVERELY BURNED. WHILE THE CAR IS OUT OF WARRANTY THIS SEAT HAS NEVER BEEN ABUSED. THE DRIVER OF THE CAR WEIGHS IN AT ABOUT 120 POUNDS. FROM CHECKING THE INTERNET THERE SEEMS TO BE A QUITE A NUMBER OF SUCH INSTANCES. THANK YOU SCOTT THE FAILURE MILEAGE WAS 60,000.

TL*THE CONTACT OWNS A 2004 BMW 545I (NA). THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH, THE FRONT PASSENGER SIDE AIR BAG WARNING LIGHT ILLUMINATED. THE MALFUNCTION CONTINUED UNTIL THE ENGINE WAS SHUT OFF. THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY INFORMED THAT THE AIR BAG SENOR WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 91,000.