2006 BMW 5 SERIES Complaints

TL* THE CONTACT OWNS A 2006 BMW 5 SERIES 530XI. THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK, THE VEHICLE WOULD NOT SHIFT INTO PARK. ONCE THE CONTACT WAS ABLE TO SHIFT INTO PARK, THE MESSAGE DISPLAY INFORMED HER THAT THE ENGINE WOULD NOT SHUT OFF BECAUSE THE VEHICLE WAS NOT LOCKED INTO PARK. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS AWAITING INSPECTION OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V504000 (POWER TRAIN:AUTOMATIC TRANSMISSION). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 123,000.

THE FRONT SUSPENSION MAKES LOUD NOISES WHEN THE CAR GOES OVER BUMPS. I ALSO FIND THAT I HAVE TO PERFORM WHEEL BALANCING EVERY 2-3 MONTHS, WHICH IS A LOT MORE THAN OTHER VEHICLES I HAVE OWNED. I HAVE TAKEN THE CAR IN TO THE DEALER, WHO STATED THAT THERE IS NOTHING WRONG WITH THE SUSPENSION, EXCEPT FOR DIRTY BUSHINGS. I FIND THIS HARD TO BELIEVE. *TR

I'VE HAD PROBLEMS WITH THE AUTOMATIC TRANSMISSION SINCE PURCHASING IN DEC 2008. THE VEHICLE JERKS VIOLENTLY AS IT SHIFTS AFTER STOPS. A FEW MONTHS AGO, THE TRANSMISSION WOULDN'T SHIFT UP UNTIL I PUT IT IN NEUTRAL AND SHIFTING IT BACK TO D. CURRENTLY, IT JERKS DURING UP SHIFTS THRU ALL GEARS, MOST OF THE TIME. I HAVE BROUGHT IT IN TO THE DEALER MULTIPLE TIMES OVER THE YEARS. THEY CLAIM THAT THEY COULDN'T FIND ANYTHING WRONG. I AM VERY WORRIED OF THE TRANSMISSION FAILING SUDDENTLY AND CAUSING A CRASH. *TR

I HAD A RECENT PROBLEM WITH OUR 525I. I WAS DRIVING IT AND IT LOST POWER/DIED. WHEN THE VEHICLE DIED, I LOST POWER STEERING AND POWER BRAKES. THE CAR WOULD NOT RESTART AND NO ERROR LIGHTS OR MESSAGES WERE DISPLAYED ON THE IDRIVE. I HAD THE CAR TOWED HOME. AFTER THE INITIAL CHECK OF THE VEHICLE, IT SHOWED THE CRANK SENSOR FAULT. I NOTICED A BUNCH OF METAL THROW OFF IN THE OIL FILTER AND THE VEHICLE DID NOT HAVE COMPRESSION IN CYLINDER 2 AND 6. I WAS THINKING CATASTROPHIC ENGINE FAILURE. SINCE I AM VERY FAMILIAR WITH AMERICAN/JAPANESE VEHICLES, I DECIDED TO LOOK INTO THE PROBLEM MYSELF AFTER GETTING NO RESPONSE FROM BMWNA. THE CAR IS OUT OF WARRANTY WITH 85K MILES. THE METAL THROW OFF WAS DUE TO THE TIMING CHAIN JUMPING OFF OF THE EXHAUST CAM GEAR AND GRINDING AGAINST THE BACK OF IT. THE CAUSE OF THE PROBLEM WAS THE TWO ALUMINUM SCREWS UNDER THE CAM SHAFT GEARS. BOTH HEADS WERE BROKEN OFF AND ONE MADE ITS WAY UP THE CHAIN GETTING CAUGHT IN THE CHAIN AND GEAR. THESE SCREWS ARE ALUMINUM. I DON'T KNOW IF THIS IS A COMMON PROBLEM BUT FOR THE BOLTS TO BREAK IT WOULD BE DUE OVER TORQUED/TIGHTEN BOLTS OR EXTREME PRESSURE FROM EXPANDING/CONTRACTING OF THE MAGNESIUM VS ALUMINUM. THE OTHER BROKEN BOLT HEAD IS STILL SOME WHERE IN THE BOTTOM OF THE OIL PAN. THE EXHAUST CAM GEAR WAS CHEWED UP, BUT STILL SERVICEABLE. I RE-TIMED THE CAR AND CHECKED THE COMPRESSION. I GOT LUCKY AND COMPRESSION IS GOOD SO NO BENT VALVES. I DISASSEMBLE EVERYTHING AND NOW I PATIENTLY WAITING FOR SEVERAL PARTS. HOWEVER, I'M STILL DEALING WITH THE BROKEN HEAD THAT IS SOME WHERE IN THE OIL PAN. THIS IS A SERIOUS MANUFACTURES DEFECT AND I HAVE RETAINED ALL OF THE PARTS AND INCLUDING THE OIL. *TR

TL* THE CONTACT OWNS A 2006 BMW 525I. THE CONTACT STATED WHILE DRIVING THE PASSENGER FRONT AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS CONTACTED BUT WOULD NOT ASSIST WITH THE REPAIR BECAUSE THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 08V384000, AIR BAGS FRONTAL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILES WERE 157,000.

PASSENGER RESTRAINT SYSTEM FAULT LIGHT HAS STARTED SHOWING ON MY BMW, THERE HAS BEEN A RECALL REPORTED ON THE SAME COMPONENT "STATEMENT ON VOLUNTARY RECALL INVOLVING FRONT PASSENGER SEAT SENSOR MAT ON U.S.A. MODEL BMWS - AUGUST 13, 2008". I HAVE THE SAME PROBLEM BUT MY VIN IS NOT SHOWING UP IN THE RECALL. I TOOK THE CAR TO DEALER AND DEALER SAYS ITS EXACTLY THE SAME PART BUT I AM NOT COVERED UNDER RECALL WARRANTY.

TL* THE CONTACT OWNS A 2006 BMW 525I. THE CONTACT STATED THE PASSENGER SEAT MAT THAT CONTROLS THE AIR BAGS EXPERIENCED AN ELECTRICAL FAILURE. THE FAILURE CAUSED THE AIR BAG LIGHT TO CONSTANTLY ILLUMINATE. THE PROBLEM OCCURRED PREVIOUSLY AND THE DEALER REPLACED THE FRONT PASSENGER SEAT SENSOR MAT UNDER THE MANUFACTURERS WARRANTY. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED HIS VIN WAS NOT INCLUDED IN THE RECALL; THEREFORE, HE HAD TO PAY $1,800 FOR THE REPAIRS REGARDING NHTSA RECALL CAMPAIGN ID NUMBER: 08V384000; AIR BAGS: FRONTAL. THE MANUFACTURER ADVISED THE CONTACT TO CALL THE NHTSA HOTLINE AND OFFERED NO OTHER ASSISTANCE. THE FAILURE MILEAGE WAS 130,000.

TL*THE CONTACT OWNS A 2006 BMW 5-SERIES. THE CONTACT STATED THAT THE AIR BAG LIGHT WOULD ILLUMINATE INTERMITTENTLY. THE DEALERS DIAGNOSIS INDICATED THAT THE MAT SENSOR WAS DEFECTIVE AND EXPLAINED THAT A RECALL RELATED TO THE FAILURE WAS NOT RELATED TO CAMPAIGN# 08V384000 (AIR BAGS:FRONTAL); BUT THE CONTACTS VIN WAS NOT A PART OF THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 57,000 AND THE CURRENT MILEAGE WAS 60,000.

TL*THE CONTACT OWNS A 2006 BMW 530I. THE CONTACT STATED THAT THE WINDSHIELD WIPER MOTOR FAILED ON DIFFERENT OCCASIONS WHILE DRIVING IN INCLEMENT WEATHER. THE VEHICLE WAS INSPECTED BY A DEALER WHO ADVISED HIM THAT THEY WOULD RESET THE COMPUTER. AFTER HAVING THE COMPUTER RESET THE FAILURE OCCURRED APPROXIMATELY ONE WEEK LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THEY ADVISED HIM THEY NEEDED TO REPLACE THE ENTIRE WINDSHIELD ASSEMBLY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 49,500.

MY 2006 BMW 525I INDICATES A PASSIVE RESTRAINT SYSTEM FAULT. THE DEALER REPORTS THE DIAGNOSIS CODE AS OC3 MAT FAULTED. THE ESTIMATE FOR REPAIR IS $1,095.15. I DECLINED THE REPAIR. WHEN I ASKED FOR A WRITTEN ESTIMATE THEY ALSO SENT ME AN ESTIMATE FOR ANOTHER CUSTOMER'S 2005 BMW 525I/530 THAT HAD THE SAME FAULT, SO I THOUGHT IT WAS WORTH REPORTING TO SEE IF IT IS A WIDESPREAD ISSUE WITH THE PASSIVE RESTRAINT SYSTEM FAULTS. *TR