2000 BMW 540I Complaints

TL*THE CONTACT OWNS A 2000 BMW 540I. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 1 MPH IN THE DRIVEWAY, THERE WAS A LOUD ROARING NOISE OUTSIDE OF THE VEHICLE. IMMEDIATELY, THE ENGINE WAS TURNED OFF. THE RADIATOR FAN BLADES DETACHED, DENTED THE HOOD, WHICH CAUSED THE PAINT TO PEEL AND THEN FELL TO THE GROUND.. THE FAILURE MILEAGE WAS 111,000. THE CONTACT WAS IN THE PROCESS OF TOWING THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS APPROXIMATELY 111,000.

ENGINE FIRE: ELECTRONIC THERMOSTAT WIRES OVERHEATED AND CAUSED WIRES AND ELECTRICAL CONNECTORS TO BURN. SMOKE ENTERED THE CABIN WHILE DRIVING AND VEHICLE PERFORMANCE HAS BEEN DEGRADED. *TR

TL*THE CONTACT OWNS A 2000 BMW 540I. WHEN THE BRAKES WERE DEPRESSED, THE TRACTION DID NOT HOLD OR CONTROL THE VEHICLE. THE INSTRUMENT PANEL GAUGE ALSO FAILED TO FUNCTION PROPERLY WHEN THE ABS FAILED. THE BMW MANUFACTURER WAS CALLED AND INFORMED THE CONTACT THAT HIS WARRANTY HAD EXPIRED AND HE WOULD BE RESPONSIBLE FOR THE REPAIR COST. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 91,000.

TL*THE CONTACT OWNS A 2000 BMW 540I. SHE STATED THAT THE BATTERY CONTINUED TO FAIL ON THE VEHICLE WHICH CAUSED SEVERAL UNDISCLOSED ELECTRICAL FAILURES. THE VEHICLE WAS TAKEN TO THE DEALER NINE TIMES TO CORRECT THE FAULTY BATTERY ISSUE, TO NO AVAIL. ON A SEPARATE OCCASION, WHILE THE VEHICLE WAS SITTING IDLE THE FRONTAL DRIVER'S AND PASSENGER'S SIDE AIR BAGS DEPLOYED WHICH CAUSED ALL OF THE WINDOWS TO SHATTER. NO ONE WAS IN THE VEHICLE AT THE TIME OF FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY REFUSED TO REPAIR THE VEHICLE SINCE THE BATTERY WAS PURCHASED FROM A THIRD PARTY. NO REPAIRS WERE MADE TO THE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE UNDER 36,206.

AFTER A COUPLE TIMES USING MY CUP HOLDERS IN MY 2000 BMW 540 I THEY BROKE. THEY ARE MADE OF CHEAP PLASTIC AND ARE VERY POORLY DESIGNED. I HAVE CHECKED OUT OTHER MODELS UP TO THE 2007 YEAR AND BMW HAS FAILED TO COME OUT WITH A QUALITY CUP HOLDER. EVEN A BETTER REPLACEMENT WOULD BE HELPFUL! IT NOW COSTS ME $150.00 JUST IN PARTS TO REPLACE THEM EACH TIME THEY BREAK. I CONSIDER MY CAR TO HAVE NO CUP HOLDERS AND WON'T ALLOW PEOPLE TO USE THEM BECAUSE THEY BREAK SO EASILY. THIS IS A "LUXURY CAR" WITH A CHEAP SHORT CUT IN THE OPTIONS DEPARTMENT. VERY DISSAPPOINTING. SHAME ON BMW! ACCORDING TO THE ORIGINAL OWNER THIS HAS HAPPENED NUMEROUS TIMES FROM DAY ONE OF BUYING THE CAR. I HADN'T EVEN DRIVEN THE CAR 20 MILES AND THE NEWLY REPLACED UNIT SNAPPED. GARBAGE! *TR

TL*THE CONTACT OWNS A 2000 BMW 540I. WHILE DRIVING LESS THAN 70 MPH, THE PASSENGER COMPARTMENT IN THE VEHICLE FILLED WITH SMOKE. THE CONTACT PULLED THE VEHICLE OVER AND CALLED THE POLICE AND FIRE DEPARTMENTS. IT WAS DETERMINED THAT THERE WAS AN ELECTRICAL PROBLEM. THE INSURANCE COMPANY REFUSED TO PAY FOR ANY DAMAGE BECAUSE THERE WERE NO FLAMES. AN ANALYSIS WAS PERFORMED BY BMW. THE CURRENT MILEAGE WAS 149,900. UPDATED 12/11/08. *LJ UPDATED 12/11/08

I HAVE A 2000 BMW 540I (E39). MY CAR WAS IN A PRISTINE CONDITION, AND ALL OF SUDDEN, THE "ENGINE FAILSAFE PROG" MESSAGE CAME UP, AND THE CAR SHUTDOWN. I TOOK IT TO A DEALERSHIP, AND I WAS TOLD THE THERMOSTAT WAS BURNED BADLY, CAUSING THE ENGINE WIRING HARNESS AND DME BURNED AS WELL. I BELIEVE THIS IS A BIG SAFETY CONCERN FOR THOSE THAT OWN THIS VEHICLE. I WAS QUOTED $3500 TO FIX THIS ISSUE, AND CURRENTLY IT'S BEING REPAIRED AT BMW SEATTLE. *TR

WHILE DRIVING IN MASSACHUSETTS ON 495N AT ABOUT 5:30PM I SMELLED SOMETHING BURNING. CHECKED MY GAUGES AND ALL SEEMED WELL, THOUGHT IT MAY BE A WOOD BURNING STOVE IN THE AREA I JUST KEPT DRIVING. I TURNED OFF RT495 AND ONTO RT 119. ABOUT A MILE DOWN RT119 I NOTICED A LOT OF SMOKE BUILDING UP INSIDE THE CAR, I THEN REALIZED MY CAR WAS ON FIRE AND BEFORE I CAN PULL OFF THE ROAD THE INSIDE OF THE CAR FILLED WITH SMOKE AND BURNED MY EYES AND I WAS CHOKING A LOT. I SLAMMED IT INTO PARK, SHUT THE KEY AND JUMPED OUT THE CAR. A CAR BEHIND ME PULLED OVER AND SAID HE WAS FOLLOWING ME AND SMELLED MY CAR BURNING AND TRIED TO SIGNAL ME. LITTLETON, MA FIRE AND POLICE ARRIVED SHORTLY AFTER. FIRE DEPARTMENT DISCONNECTED MY BATTERY IN THE TRUNK AND OPENED THE HOOD TO LOOK FOR FLAMES. NOT SEEING FLAMES THEY DID SEE HEAVY SMOKE AND SMELLED SOMETHING BURNING. SHORTLY AFTER THAT MY CAR WAS TAKEN AWAY ON A TOW TRUCK TO BMW IN NASHUA, NH. BMW DETERMINED THAT A FAULTY/FAILED ELECTRO MECHANICAL THERMOSTAT HAS CAUSED THE FIRE AND THE DAMAGE ESTIMATED SO FAR TO BE ABOUT $4,000.00 THEY TOLD ME THIS IS A PROBLEM SEEN BEFORE AND THEY HAD NO SUGGESTIONS AS TO WHY THIS HAPPENED BUT DID SAY IT COULD HAPPEN AGAIN! WHILE MY INSURANCE COMPANY (COMMERCE INSURANCE) REFUSES TO MAKE ANY PAYMENTS FOR DAMAGES, THEY CLAIM IT WAS CAUSED BY A FAULTY PART AND THAT BMW IS RESPONSIBLE. BMW TELLS ME THAT MY CAR IS OUT OF WARRANTY AND THIS PART IS JUST A FAILED PART. I THINK WE ARE DEALING WITH SOMETHING MORE SEVERE THAN A FAILED PART. IT'S JUST A GOOD THING I WAS ABLE TO GET OFF THE ROAD IN TIME BEFORE I WAS OVERCOME BY THE SMOKE AND TOXIC FUMES FROM BURNING WIRES IN THE CAR. REALIZING THIS CAN HAPPEN AGAIN, I DO NOT FEEL SAFE DRIVING THAT CAR ANOTHER DAY AND HAVE NOT DECIDED TO GET IT FIXED OR CRUSHED. *TR

I WAS MOVING MY CAR IN ORDER TO PARK IT SOMEWHERE ELSE. THE CAR STARTED THEN COMPLETE FAILURE. THE CAR CUT OFF, NO POWER BRAKES, NO POWER STEERING. I HAD TO PRESS THE BRAKES VERY HARD TO GET STOPPAGE. THE THERMOSTAT SHORTED OUT AND BURNED OUT THE MAIN COMPUTER. THE CAR WOULD NOT START. THE MAIN COMPUTER WAS REPLACED, THE WIRING HARNESS WAS BURNED OUT AND SEVERAL OTHER ELECTRONIC PARTS WERE REPLACED. THE ALUMINUM THERMOSTAT HOUSING WAS MELTED AND WAS REPLACED! TOTAL OF OVER $5,000 WAS REQUIRED TO FIX. IF A FUSE HAD BEEN THERE IT WOULD HAVE BEEN A COUPLE OF HUNDRED DOLLARS AND IF THIS HAD BEEN ON THE ROAD AS SPEED IT COULD HAVE BEEN EXTREMELY DANGEROUS. *TR

AFTER APPROXIMATELY 75,000 MILES ON MY BMW 540I, THE TRANSMISSION WILL NOT GO INTO REVERSE. THE DEALER SAYS IT HAS INTERNAL SLIPPAGE/DAMAGE AND WILL HAVE TO BE REPLACED WITH A REMANUFACUTED ONE. I FOUND OUT THAT THIS IS A COMMON PROBLEM WITH BMW - SEE HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/BMW_TRANS.HTML FOR TESTIMONY OF LOTS OF OTHER BMW OWNERS WHO LOST REVERSE. IT SURPRISES ME THAT BMW DOESN'T WARRANTY THEIR TRANSMISSIONS/DRIVETRAIN AS LONG AS THE "LOWER QUALITY" AMERICAN AND ASIAN VEHICLE MAKERS DO. BUT IF THE TRANNY ROUTINELY QUITS AROUND THE 60-80K MILE MARK, I GUESS IT'S A SMART BUSINESS DECISION FOR BMW! *TR