2012 BMW X5 Complaints

Passenger interior Door handle assembly caught on fire and melted the rubber grommet. BMW said it was the comfort sensor fuse should have blown but did not. I saw blue smoke while driving from the passenger door mirror blowing out of the door handle like a volcano for 2 ft sideways. The rubber grommet holding the door handle melting completely down the outside door exterior. BMW fixed the sensor but my entire electrical system has been a disaster since. the passenger seat air bag warning, the parking brake, sensors working intermittent in the vehicle. There is a problem there should be a recall on the entire electrical system.

Ever since the rain starter my aux water pump don't work and brake light too. And it seems like something has been draining my battery because battery discharge comes up. And I think the idle idle pulley issue affects almost most of that year bmw X5 because my serpentine belt only installed 10,000 miles ago and already see threads being worn out. Unless that's how long they last. I had to bring the car back in multiple times to get it adjusted because kept making squealing noise. They blamed it on water pump and didn't change the thermostat. Water even leak into front passenger side where all the fuses were. When I connected the battery charger I could hear the pump all of sudden working and the radiator tank sputter water out. I don't want to bring it to dealership and get charged for things that they should fix with charging me but they tell me it's some other issue and have me pay for it. The way they act are worse than gangsters because if you get it fix elsewhere they say it's not covered by them them. And the driveshaft issue, even alot of the cars not in recall are affected and how are they to assume which car need replacing and which dont? I think the v8 engine is just too much power for the other parts to handle and they don't want to admit it. Because how many bmw X5 owners complain about these issue ??

Egr cooler broken and leaking exhaust gas to cabin making all passengers drousy, a/c vents pulls outside air. Making it a lot worse egr will be replaced and save for warranty inspection etc.. My safety was affected sue to carbon monoxide emissions, others were affected due to the drowsiness effects of the exhaust making the drive drousy at the wheel . No reproductions know. Inspection by owner No inspection yet due to the need of vehicle had to replace asap to keep using part saved for inspection. Engine light due to glow plugs, non related to egr cooler, and brakes lights due to sensor not replace yet.

My car is giving engine overheat warning when I am driving . I understand that this issue is with cooling system . Presently there is a open recall for this issue for the 2012 bmw x5. NHTSA Campaign Number: 18V248000 . But my car is not covered under this recall.

After accelerating normally on the highway the vehicle shut off completely, without warning, and put itself into neutral in the middle of a busy freeway. (No warning lights, no smoke or smell of any kind). The Car would not start despite multiple attempts using a jump start from the tow company. I could have been hit by another vehicle while stopped. The car was then towed to a BMW dealership where they determined an engine replacement was probably necessary because it appeared seized. (they could not turn the engine using a breaker bar with the belt off. ) No further investigation was done. The car was running: - castrol 5w-30, -regular oil & filter changes every 5,000 miles -was never modified -all the fuel injectors changed by the dealership under a recall 1 year before the vehicle died

Front passenger door would not unlock or open from inside or outside. Per dealer and report this appears to be failure of the passenger door actuator/solenoid. Door panel will require removal to confirm. There was no immediate safety issue, however with 3 small children, there is a reluctance to drive this car with the potential for doors locking and no way to extricate them should the problem occur on all doors. My understanding is there is no mechanical release associated with these doors. In addition, if an elderly/handicapped person had been in the front passenger seat during this occurrence, there could have been serious issues with extrication. I have been an engineer for 30 years and liken this problem to the old refrigerator doors latches trapping children inside and similarly, rear trunk latches with no interior releases. I have notified the manufacturer and reported this issue.

The DPF exhaust emissions system failed. BMW dealership refused to replace only replaced a holding tank. That code was not shown. The x5 left shop with a engine light and emissions failure. Independent shop scanned car explained diesel dpf system has failed and is under warranty.. dealership refused to fix. Car runs sluggish, engine warning keeps coming on and take to service. ... The egr cooler failed. The independent shop confirmed codes. Exhaust smell in cabin, reduced power, sluggish, and car goes into LIMP mode while I was driving on the freeway. The shut down of power caused me to almost crash into on coming lane of vehicles at highway speed. Engine light on and warning of engine failure and car stuck in limp mode . System says to take to dealer. . Please help as the dealer will not warranty or recall repair, even though I am under 100,000 miles and there are multiple recall and manufacturer extension warranty for these specific repairs. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

ENGINE FAILED BECAUSE CUSTOMER CARE PACKAGE WAS NEVER DONE ON VEHICLE TO SAVE ENGINE FROM KILLING ITSELF. THESE ENGINES IN THESE CAR ARE PROBLEMATIC DUE TO DESIGN OF ENGINE THEY EAT OIL AND VALVE STEMS DRYS OUT AND STARTS TO SMOKE

RIGHT INNER BRAKE LIGHT ASSEMBLY ON HATCHBACK IS PRONE TO WATER DAMAGE WHICH RESULTED IN CORROSION OF LED CONTACTS RESULTING IN FAILURE OF THE ASSEMBLY. LOSS OF FUNCTION WAS EVIDENT AS THIS TAILLIGHT WENT ENTIRELY DARK AND REQUIRED REPLACEMENT

AS I WAS DRIVING THE VEHICLE SHUT OFF WHILE VEHICLE COMING AT A 40 MPH TO 50 MPH SPEED LIMIT.LOCAL POLICE HAD TO PUT OUT CONES TO MAKE SURE MY VEHICLE WASN'T GOING TO CAUSE AN ACCIDENT BECAUSE MY BATTERY WAS DRAINED FAST MYBE DUE TO THE PROBLEM