1999 BMW Z3 Complaints

TL* THE CONTACT OWNS A 1999 BMW Z3. THE CONTACT STATED THAT THE VEHICLE WAS INCREASINGLY HARD TO CONTROL AND THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY FOR AN ALIGNMENT. THE MECHANIC ADVISED THE CONTACT THAT THE REAR DIFFERENTIAL HAD FAILED AND WAS CAUSING THE WHEELS TO FRACTURE FROM THE SUB FRAME. THE MECHANIC ALSO ADVISED THE CONTACT OF THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 99V272000 (POWER TRAIN: DRIVELINE: DIFFERENTIAL UNIT). THE MANUFACTURER WAS CONTACTED AND THE CONTACT WAS ADVISED TO HAVE THE VEHICLE TOWED TO THE DEALER. THE VEHICLE WAS TOWED AND THE CONTACT WAS AWAITING DIAGNOSIS AND REPAIRS. THE FAILURE AND CURRENT MILEAGE WAS 105,000.

MY 1999 BMW Z3 ROADSTER BEGAN DRIVING FUNNY AND MAKING SQUEAKING NOISES, IN THE REAR. THEN I NOTICED THE BACK TIRES, WERE STARTING TO KICK OUT AND LOOK STRANGE. THEN MY CAR BEGAN MAKING A BAD VIBRATING SOUND, COMING FROM THE BACK TIRES, WHEN I WAS IN FIRST GEAR. I TOOK IT TO SHOP. THEY JACKED IT UP, AND FOUND, THAT THE DIFFERENTIAL UNIT, HAS SEPARATED FROM THE SUB-FRAME. *TR

1999 BMW Z M ROADSTER REAR GEARBOX(DIFF) TEARING FROM CAR. ALL WELDS ARE BROKEN AND SUPPORT IS TORN IN HALF IN PLACES AND CRACKED. *TR

AIR BAG LIGHT ON. SHOP MECHANIC STATED "RETRIEVED DTC CODE FOR DRIVERS SEAT BELT SWITCH OPEN OR SHORT CIRCUIT. CLEANED CONNECTORS, CLEARED DTC INFO OPERATIONAL CHECK OK. IF FAULT RECURS, RECOMMEND REPLACEMENT OF DRIVERS SEAT BELT LATCH ASSEMBLY." PROBLEM FIXED JUNE 18, 2008. NOW PROBLEM WITH AIR BAG LIGHT ON IS BACK. THERE SEEM TO BE A LOT OF PROBLEMS WITH AIR BAG SENSORS AND SEAT BELT LATCHES ON VARIOUS BSM VEHICLES ACCORDING TO INTERNET SEARCHES. *TR

I NOTICED A SQUEAKING NOISE COMING FROM THE BACK OF MY 1999 BMW Z3 COUPE. WHEN I HAD IT CHECKED I FOUND IT WAS A SMALL CRACK WHERE THE SUBFRAME HAD BEEN FACTORY REINFORCED. THE REINFORCEMENTS WERE FAILING IN THE BACK OF THE CAR NEAR THE TRUNK FLOORING AND THE SWAYBAR. THE MECHANIC STATED IT WOULD COST $6500 TO REPLACE THE CRACKING FRAME, OR I COULD GO TO ANOTHER SHOP AND HAVE IT SPOT WELDED TO REINFORCE AND STOP THE CRACK FROM GETTING LARGER. *TR

1999 Z3 M COUPE DIFFERENTIAL MOUNT TRUNK FLOOR SUPPORT FAILURE. I TOOK IN MY CAR FOR MY 90 THOUSAND MILE SERVICE AND WAS INFORMED BY THE SHOP (WWW.THEMSHOP.COM) LOCATED IN GLENDALE, CA. THAT MY SUBFLOOR WAS CRACKED AND UNLESS I FIXED IT MY CAR WOULD BE USELESS, AND NOT DRIVABLE. I HAD TO SPEND OVER $2,800 TO FIX MY CAR WHICH IS VERY DISAPPOINTING ESPECIALLY SINCE THIS IS A WEEKEND CAR NOW AND WHEN YOU PAY $46,000 FOR A BMW YOU DO NOT EXPECT THE FRAME TO FAIL.... *TR

DT*: THE CONTACT STATED WHILE DRIVING 70 MPH DURING CLEAR CONDITIONS, THE FRONT DRIVER SIDE AIR BAG DEPLOYED WITHOUT WARNING OR IMPACT TO THE VEHICLE. THERE WAS NO DEBRIS OR POTHOLES PRESENT. THE CONTACT SUFFERED CUTS, BRUISING AND SCARING TO THE LEFT ARM. THE CONTACT DROVE TO THE HOSPITAL. THE SERVICE DEALER AND MANUFACTURER WERE NOTIFIED AND PHOTOS WERE TAKEN OF THE VEHICLE AND INJURIES. UPDATED 11/16/2006 -THE GAS GAUGE AND ODOMETER WERE INOPERATIVE. THE DEALER REPLACED THE INSTRUMENT CLUSTER. THE DRIVER'S DOOR GRAB HANDLE WAS REPLACED. THE REAR SHOCKS AND MOUNTS WERE REPLACED. THERE WAS A POWER STEERING LEAK. THE DEALER REPLACED THE POWER STEERING HOSE RES TO PUMP. THE DEALER REPLACED THE FLEX COUPLER ON THE DRIVE SHAFT. *NM

I PURCHASED MY CAR FROM ROSE IMPORTS IN VALLEJO, CA. ON 08-22-2006. APPROXIMATELY 1 MONTH LATER, I STARTED TO HEAR A NOISE FROM THE REAR. I WOULD HEAR IT OCCASIONALLY. ON 10-10-2006, I WAS DRIVING HOME ON I-80 AND AS I WAS DRIVING, SUDDENLY I HEAR A LOUD "POP". I PULL OVER AND DID A VISUAL CHECK BUT FOUND NOTHING I COULD SEE SO I CONTINUED TO DRIVE HOME AND HEARD METAL SOUNDS COMING FROM THE BACK. THE NEXT DAY WHILE DRIVING TO WORK, I CONTINUED TO HEAR THE SOUND AND WHEN I RETURNED HOME, ME AND A FRIEND LIFTED THE CAR AND THAT'S WHEN I DISCOVERED THE SNAP OR BREAK IN THE DIFFERENTIAL SUPPORT BRACKET. IT HAS COMPLETELY SEPARATED FROM THE DIFFERENTIAL. THE DEALER WHERE I PURCHASED THE CAR TOLD ME GOOD LUCK. THEY'RE NOT GOING TO DO ANYTHING SINCE IT PASSED THEIR SAFETY INSPECTION. I CALLED MY LOCAL BMW DEALER AND SPOKE TO THE SERVICE DEPT. AND THEY TOLD ME IT WAS NOTHING THEY CAN OR WILL DO BECAUSE IT'S 86K MILES AND OUT OF WARRANTY. NOW I'M STUCK WITH A CAR I JUST PURCHASED AND HAVE A MAJOR BILL 2 MONTHS LATER. *NM

I AM THE THIRD OWNER OF THIS CAR, IT WAS ALWAYS GARAGED AND USED AS A WEEKEND PLEASURE VEHICLE. CLEAN CARFAX, NEVER RACED, WHAT I THOUGHT WAS A GOOD PURCHASE. TWO SPOT WELDS IN THE TRUNK WERE NOT ACTUALLY HOLDING ANYTHING TOGETHER (ROBOT ERROR) AND THERE WAS A SMALL CRACK ON MY DIFFERENTIAL MOUNT. I PURCHASED A REINFORCEMENT KIT AND INSTALL FROM SPORTS CAR LLC, WHICH INCLUDES A NEW MOUNT (DUAL EAR FROM AN E36 M3) AND SEVERAL REINFORCING BRACKETS BEING WELDED INTO THE TRUNK AREA. THIS COST ME SEVERAL THOUSAND DOLLARS JUST TO ENSURE MY PERSONAL SAFETY AND KEEP MY CAR AT THE SAME TIME. *NM

THE WELDS CONNECTING THE SUBFRAME TO THE FLOOR ON THE UNDERSIDE OF THE REAR OF THE CAR HAVE BEGUN TO FAIL. THIS WAS FOUND AFTER THE AREA BEGAN TO MAKE NOISES WHEN SHIFTING THE CAR OR GOING OVER BUMPS.