2008 CAN-AM SPYDER Complaints

I HAD RIDDEN THE CAN AM SPYDER ROADSTER FOR APPROXIMATELY 30 MINUTES BEFORE STOPPING AT COSTCO AND FILLING IT UP. NO OVERFILL OR GAS SPILLED. I ROAD APPROX. 2 MILES HOME, PARKED, AND WENT INTO THE HOUSE FOR APPROX. 3 OR 4 MINUTES. I RETURNED TO SPYDER STARTED IT & BACKED UP APPROX. 10 FEET, PULLED FORWARD, BACKED UP AGAIN, STARTED FORWARD OUT OF MY DRIVEWAY. WHEN I TURNED & STARTED FORWARD THERE WAS A SMELL ELECTRICAL WIRE BURNING. I SAW SMOKE COMING FROM THE FRONT OF MY SEAT & CENTRAL PLASTIC PANEL. BEFORE I COULD REACT TO THAT I HAD MOVED FORWARD MAYBE 10 OR 15 FEET. THERE WAS A WHOOSHING SOUND & A LARGE AMOUNT OF SMOKE FROM THE SAME AREA. IT SCARED ME ENOUGH THAT I PANICKED & TRIED STEPPING OFF THE SPYDER AS IT WAS MOVING. I TRIPPED AND STRUCK THE DRIVEWAY ON MY LEFT ARM, SHOULDER AND HEAD. I ROLLED OVER & LOOKED TO SEE WHAT HAPPENED. THE SPYDER HAD CONTINUED FORWARD INTO THE FENCE & TREE AT THE SIDE OF MY DRIVEWAY. THERE WAS A LOT OF SMOKE AND A SMALL FLAME APPROX. A FOOT HIGH AT THE FRONT OF THE SEAT & CENTER PANEL. WHEN THE SPYDER HIT THE TREE THE FLAME JUMPED TO AROUND 3 TO 4 FEET. THE SPYDER HAD RUN OVER MY GARDEN HOSE AND HIT THE WATER LINE SO THAT I COULD NOT GET TO A HOSE OR TURN THE WATER ON. I WAS AFRAID THE GAS TANK WOULD EXPLODE ANY WAY SO I CALLED 911. BY THE TIME THE FIRE DEPARTMENT ARRIVED THE SPYDER WAS APPROXIMATELY 75 % BURNT. THE FIREMAN IN CHARGED STATED HE FELT THE FIRE STARTED ON THE RIGHT SIDE. MY CAN AM SPYDER IS THE 8TH ONE TO BURN UP THIS WAY. ON 09/28/2010 ANOTHER 2008 CAN AM SPYDER SELF-IGNITED WHILE THE RIDE WAS MOVING. HE REPORTED THAT HIS MACHINE WAS ALSO A TOTAL LOSS. FIRE DEPARTMENT STATION #21 INCIDENT #10-0107129 UPDATED IVOQ 10/26/10*JB *TR

TL*THE CONTACT OWNS A 2008 CAN-AM SPYDER RS MOTORCYCLE. THERE WERE NUMEROUS DEFECTS AND FAILURES ON HIS MOTORCYCLE. THE POWER STEERING PULLED TO THE RIGHT AND THE DEALER REPLACED THE GPS UNIT UNDER THE WARRANTY. THE FUEL GAUGE WAS NOT READING AS IF THERE WAS A FULL TANK OR IF IT WAS EMPTY. THE DEALER REPLACED THE SENDING UNIT WITHIN THE TANK AND THE INSTRUMENTATION PANEL UNDER WARRANTY. THE MANUFACTURER WAS CALLED IN REGARDS TO ALL OF THE PROBLEMS THE MOTORCYCLE HAD AND WAS TOLD THAT THEY WOULD CONTACT HIM. THEY HAD NOT CONTACTED HIM WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 1,781.

I RIDE A CAN AM SPYDER WHICH IS A 3 WHEELED MOTORCYCLE AND ON 8-8-10 IT SPONTANEOUSLY CAUGHT ON FIRE, THANK GOODNESS SOMEONE WAS ABLE TO GET A FIRE EX. AND PUT OUT THE FIRE BUT NONE THE LESS IT MELTED A LOT OF PARTS. IT IS NOW AT A DEALER WAITING FOR PARTS TO COME IN THE BE REPLACED. I HAVE READ ON SEVERAL WEB SITES THAT THIS HAS HAPPENED BEFORE, MAYBE A RECALL IS IN ORDER. NO ONE WAS HURT. *TR

TL*THE CONTACT OWNS A 2008 CAM AM SPIDER. WHILE DRIVING 45 MPH THE CONTACT NOTICED THAT THE HANDLE BARS HAD BEGAN TO LOCK WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT A PART ON THE POWER STEERING SYSTEM NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 500 AND THE CURRENT MILEAGE WAS 600.

THREE WHEELED CYCLE STEERING LOCKED/BINDED AT ABOUT 45 MPH. OPERATOR LOST CONTROL AND RAN OFF THE ROAD CAUSING PROPERTY DAMAGE. THIS WAS THE FOURTH TIME THE STEERING "BINDED" WHILE TRAVELING STRAIGHT AT FREEWAY SPEEDS. *TR

VEHICLE - 2008 BRP CAN AM SPYDER. WHILE RIDING AT APPROXIMATELY 60 MPH ON A 2 LANE HIGHWAY IN THE RAIN AFTER DARK THE DYNAMIC POWER STEERING (DPS) SEIZED UP AND I WAS UNABLE TO STEER THE UNIT WITH THE NORMAL AMOUNT OF PRESSURE ON THE HANDGRIPS. WHEN ENOUGH PRESSURE WAS APPLIED TO THE HANDLE BAR TO OVERCOME THE RESISTANCE EXCESSIVE OVER STEERING RESULTED. THE OVER STEERING CAUSED ME TO DRIVE INTO THE OPPOSING LANE AND ALTERNATELY ON TO THE SHOULDER. THE ONLY WAY I WAS ABLE TO PREVENT THE STEERING FROM LOCKING UP IN ANY ONE POSITION WAS TO CONTINUOUSLY MOVE THE HANDLEBAR FROM LEFT TO RIGHT ' RIGHT TO LEFT. I WAS LUCKY NOT TO HAVE HAD AN ACCIDENT. I KNOW THAT BRP IS AWARE OF THIS PROBLEM BUT HAS NOT PROVIDED ANY REMEDY THAT PROTECTS THE OWNERS FROM SERIOUS ACCIDENTS. BRP'S APPROACH IS TO PROVIDE SOFTWARE UPDATES TO THE DPS UNITS WHICH MY SPYDER HAD INSTALLED SEPT. 2009. ACCORDING TO A NUMBER OF FORUMS; MANY SPYDER OWNERS HAVE HAD DPS FAILURES. PLEASE LOOK INTO THIS SITUATION BEFORE SOMEONE GETS KILLED. *TR

CAN AM SPYDER EVERY NOW AND THEN WHILE GOING AROUND A SHARP CURVE THE POWER STEERING WILL TURN OFF AND COME BACK ON CAUSING AN OVER CORRECTION AND POSSIBLE UNINTENDED LANE CHANGE. *TR

WHILE RIDING ALONG ON A LONG SWEEPING LEFT TURN THE STEERING LOCKED AND I NEEDED TO PHYSICALLY FORCE IT TO UNLOCK. I SINCE RETURNED IT TO THE DEALER AND I'M AWAITING FOR A STEERING PART NEEDED FOR REPAIR.

2008 CAN-AM SPYDER DISPLAYED DPS AND VSS ERRORS. RESET ERROR BY TURNING OFF AND LETTING SET FOR A FEW MINUTES. THEN DROVE FOR 40 MILES ON HIGHWAY. UPON EXITING THE HIGHWAY AT ABOUT 40 MPH THE BIKE'S STEERING STOPPED WORKING. THE VEHICLE WANTED TO DRIFT TO THE RIGHT ONLY. IT COULD NOT BE STEERED EVEN WITH GREAT FORCE APPLIED TO THE HANDLE BAR. AFTER ABOUT 10-15 SECONDS THE ABILITY TO STEER KICKED BACK IN. THE SAME SYMPTOMS OCCURRED AGAIN 6-7 TIMES IN THE NEXT 1.5 MILES. BIKE WAS LATER TOWED TO THE CAN-AM DEALER IT WAS PURCHASED FROM. THEY REPLACED THE DPS MODULE WHICH AFTER ONLY 60 MILES IS STILL WORKING FINE.

DYNAMIC POWER STEERING (DPS) UNIT FAILURE ON MY 2008 CAN AM SPYDER. DID NOT APPEAR UNTIL THE SOFTWARE UPDATE WAS INSTALLED AS PART OF THE MANUFACTURER'S RECALL WHEN I TOOK IT IN FOR THE 12000 MILE SERVICE JUST BEFORE THE 2 YEAR WARRANTY EXPIRED. UP UNTIL THEN I HAD NO SYMPTOMS. THE DEALER HAS ORDERED A REPLACEMENT DPS UNIT FROM BRP. *TR