2013 CAN-AM SPYDER ST Complaints

AFTER RIDING VEHICLE & PARKING IT , I COULD SMELL STRONG FUEL FUMES FROM VEHICLE. I ALSO NOTICED THAT THE BODY PANELS BECOMES VERY HOT . I ALSO NOTICED THAT THE FUEL IN THE TANK HAS BUBBLES / BOILING .I BROUGHT THE VEHICLE AT MY LOCAL DEALERSHIP ( JACKSONVILLE, POWERSPORT) TO HAVE THEM CHECK MY CONCERN . THE SERVICE MANAGER CONTACTED BRP , A CASE WAS ASSIGNED ( #[XXX]) .BRP RECOMMEND TO INSTALL 2014 BODY PANELS FOR MY PROBLEM WHICH I WILL HAVE TO PAY . THESE ARE THE PART # FOR ROADSTER AIR SCOOP RETROFIT KITS LH KIT 219 800 341 , RH KIT 219 800 342 (PURE MAGNESIUM (METALLIC) B-349) .THERE ARE SOME REPORTS OF VEHICLES OF THE SAME YEAR & MODEL THAT HAVE CAUGHT ON FIRE & I DON'T WANT THIS TO HAPPEN W/ MY VEHICLE . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

FUEL IN TANK BOILS AFTER RIDING. FUEL VAPORS ESCAPE FROM THE CHARCOAL CANISTER. SOMETIMES THERE IS SO MUCH FUEL VAPOR THAT IT CONDENSES AND FORMS A PUDDLE. I HAVE CONTACTED BRP ABOUT THE ISSUE BUT HAVE NOT HEARD BACK. *TR

REPEATED PROBLEMS WITH ODOR OF FUEL AND INTERMITTENT STALLING. EVAP CANISTER WAS REPLACED TWICE (FUEL IN CANISTER) AND PURGE VALVE ONCE. APPEARS TO AFFECT RUNNING AS IT MISSES AND SURGES AT A CONSTANT SPEED (VERY SUBTLE). SINCE I PARK THIS IN MY ATTACHED GARAGE IT IS A CONCERN. VEHICLE HAS BEEN IN SHOP 5 TIMES FOR A TOTAL OF 2 1/2 MONTHS DURING MY 6 MONTHS OF OWNERSHIP. BRP HAS NOW TOLD ME THAT THEY WILL NO LONGER REPAIR THIS VEHICLE WHICH NOW HAS ONLY 2600 MILES. *JS

DURING ENGINE OPERATION; THE VEHICLE SENDS EXTREMELY HOT AIR OUT OF THE SPACE BETWEEN THE FORWARD EDGES OF THE SEAT AND UPPER AND SIDE BODY PANELS, THE UPPER SIDE PANELS ARE VERY HOT TO TOUCH, AND THE UNDERSEAT AREA ACCUMULATES AN EXCESSIVE AMOUNT OF HOT AIR ALLOWING THE FUEL CAP FOUND UNDER THE SEAT TO BECOME HOT TO THE TOUCH. THE SEAT HEAT PROBLEMS MAKE RIDING AND CONTROLLING THE VEHICLE DIFFICULT BECAUSE OF THE DISCOMFORT FELT BY THE DRIVER AND PASSENGER. IF THE DRIVER IS NOT WEARING THICK, PROTECTIVE GARMENTS COVERING THEIR LEGS THERE IS A POSSIBILITY OF BURNS ABOUT THE UPPER LEGS OR LOWER TORSO. THIS ISSUE IS ESPECIALLY EVIDENT WHEN THE OAT IS ABOVE 80 DEG FARENHEIT. *TT

WHEN STOPPING AT STOP SIGNS, TRAFFIC LIGHTS OR JUST STOPPING TO PARK THERE IS AN EXCESSIVE GAS SMELL COMING FROM THE VEHICLES EVAP CANISTER. THIS ALL STARTED WHEN THE OUTSIDE TEMPERATURES EXCEEDED 70 DEGREES. THIS SMELL OCCURS IF THE FUEL TANK IS FULL, HALF FULL OR NEARLY EMPTY. ON SUNDAY 4/13/14 WHEN COMING HOME FROM A LONG RIDE I DECIDED TO CHECK OVER SOME THINGS AND DISCOVERED THE GASOLINE IN THE FUEL TANK WAS BOILING! THE EXAUST PIPE ON THIS MACHINE RUNS VERY CLOSE TO THE FUEL TANK. *TT

THE SPYDER ST HAS STARTED IDLING ROUGH....RPM'S WILL RACE BETWEEN 1000 AND 2000 IN A NANO SECOND THE BIKE WILL SURGE FORWARD....STARTED HAPPENING AFTER ABOUT 200 HUNDRED ARE SO MILES....NOW IT HAS A ROUGH IDLE ALL THE TIME.....BECOMING A SAFETY HAZARD WHILE AT STOP LIGHTS AND IN TRAFFIC ....WHEN RPM'S REACH 1000 OR BELOW A BEEPING SOUND AS IF BIKE IS GOING TO SHUT OFF....THEN SURGES TO 1800-2000 AND BIKE WILL LURCH FORWARD...BIKE ALSO CLATTERS AND SHAKES AT COLD TAKE-OFF AND REVERSE. *TR

2013 CAN AM SPYDER ST-S. EXTREME HOT TEMPERATURES ON BODY PANELS CAUSING GREAT DISCOMFORT TO DRIVER. WHEN STOPPED TO FUEL RIGHT FINGER TIPS BURNED WHEN OPENING GAS CAP. HAD TO USE T- SHIRT I WAS WEARING TO OPEN GAS CAP. SEAT AREA EXTREMELY HOT AS IT APPEARS EXHAUST IS ROUTED UNDER SEAT. INFORMED DEALER OF INCIDENT AND WAS TOLD NOT TO BE CONCERNED AS THEY ALL RUN HOT "JUST RIDE IT. IT WILL BE FINE". HAD PUFF OF WHITE SMOKE COME FROM VEHICLE NOT SURE IF IT WAS EXHAUST OR VAPOR FROM UNDER BODY PANELS. CONCERNED ABOUT EXTREME HEAT FROM VEHICLE CAUSING PERSONAL INJURY OR PROPERTY DAMAGE. *JB

WHEN STOPPED TO GET FUEL. THE GAS CAP IS ALMOST TOO HOT TO TOUCH. TAKE CAP OFF AND GAS SPEWS OUT AT YOU. SO I STARTED RELEASING CAP SLIGHTLY AND THEN TAKE CAP OFF. GAS WOULD SPIT BACK AT YOU AS YOU WERE TRYING TO FILL TANK. HAPPENS FREQUENTLY. *JB

WHEN BRAKES WERE APPLIED WHITE SMOKE WOULD COME OUT OF THE VENTS AND THERE WAS AN ODOR. THE NEXT DAY WHEN THE SPYDER WAS STARTED WITH THE BRAKE APPLIED MORE SMOKE STARTED POURING OUT AND THE "BRAKE FAILURE" LIGHT CAME ON THE LCD PANEL. THE VEHICLE WAS TRAILERED TO THE DEALERSHIP AND WHEN IT WAS UNLOADED FROM THE TRAILER THE BRAKE FLUID STARTED POURING OUT. THE DEALERSHIP SAID THAT THE MASTER BRAKE CYLINDER HAD MELTED. *TR

THE HEAT BUILD UP UNDER THE BODY COVERINGS HAS MELTED THE TOP COVER OF THE BRAKE MASTER CYLINDER. THE MASTER CYLINDER IS LOCATED INCHES FROM THE EXHAUST PIPE FROM THE REAR CYLINDER. CONTINUED DEGRADATION OF THE PLASTIC COVER WOULD LEAK BRAKE FLUID DIRECTLY ONTO THE EXHAUST, AND COULD LEAD TO A FIRE HAZARD, AS THE BRAKE FLUID WOULD LEAK ONTO THE EXHAUST PIPE JUST BEFORE THE CATALYTIC CONVERTER. *TR