CAN-AM Complaints

DYNAMIC POWER STEERING (DPS) UNIT FAILURE ON MY 2008 CAN AM SPYDER. DID NOT APPEAR UNTIL THE SOFTWARE UPDATE WAS INSTALLED AS PART OF THE MANUFACTURER'S RECALL WHEN I TOOK IT IN FOR THE 12000 MILE SERVICE JUST BEFORE THE 2 YEAR WARRANTY EXPIRED. UP UNTIL THEN I HAD NO SYMPTOMS. THE DEALER HAS ORDERED A REPLACEMENT DPS UNIT FROM BRP. *TR

FOLLOWING RECALL SERVICE WORK RELATING TO THE DYNAMIC POWER STEERING I IMMEDIATELY NOTICED SMOOTHER POWER STEERING ACCOMPANIED BY A SMALL "BUMP" OR "HICCUP" WHEN STEERING WHICH APPEARS TO BE A PRELUDE TO POWER STEERING FAILURE. FOLLOWING AN 18 MILE TRIP AFTER THE RECALL WAS DONE THE UNIT BEGAN TO DISPLAY CODES INDICATING PROBLEMS WITH THE VEHICLE STABILITY SYSTEM AND THE DYNAMIC POWER STEERING (DPS) INCLUDING "VSS FAULT", "CHECK ENGINE", AND "DPS FAULT". I WAS FORCED TO "LIMP" MY UNIT BACK TO THE DEALER FOR FURTHER TESTING AND REPAIR. PRIOR TO THE RECALL I HAD NO CODES OR ENGINE ISSUES. THE UNIT HAS APPROXIMATELY 22,700 MILES. *TR

I WAS DRIVING DOWN THE ROAD AND WENT TO ADJUST MY POSITION WITHIN MY LANE BUT THE HANDLEBARS HAD TO BE FORCED TO THE LEFT (STEERING SEEMS TO BE LOCKING UP). THIS OCCURS CONSTANTLY AND REQUIRES ABNORMAL FORCE TO CORRECT OR HAVING TO BRAKE TO A STOP SO AS NOT TO VEER INTO ONCOMING TRAFFIC. I TOOK THE VEHICLE IN TO A CAN-AM DEALERSHIP FOR A POWER STEERING RECALL ALONG WITH AN ECM UPDATE RECALL AND A DPS UPDATE PER MANUFACTURER. THE RECALLS AND UPDATES WERE DONE BUT THE PROBLEM STILL EXISTS. *TR

STEERING LOCKS UP WHILE DRIVING. OVERCOMING THIS LOCKED UP CONDITION REQUIRES ABOVE NORMAL FORCE. WHEN THE APPLIED FORCE OVERCOMES THE LOCKED UP STEERING THE MOTORBIKE THEN VEERS IN AN UNCONTROLLED MANNER. *TR

WHEN TRAVELING ON HIGHWAY, SPYDER DRIFTED TOWARD TO THE RIGHT. TRIED TO CORRECT DRIFT, BUT STEERING WAS LOCKED. HAD TO APPLY EXCESSIVE FORCE TO CORRECT DRIFT, THEN STEERING BROKE LOOSE AND SHARPLY JERKED TO THE LEFT. NO ON-COMING TRAFFIC BUT IT WAS ENOUGH TO ENTER THE ONCOMING LANE. THIS CONTINUED TO OCCUR AND SCHEDULED A STEERING UPDATE WITH DEALER. AFTER THE DEALER INSTALLED THE UPDATE, ON THE WAY HOME (APPROX. 50 MILE TRIP) THE SAME THING BEGAN TO OCCUR, ONLY WORST. BY THE TIME I GOT HOME, IT WAS BEGINNING TO BE SO SEVERE THAT IT WAS DIFFICULT TO JUST STAY IN MY LANE OF TRAFFIC. CALLED THE DEALER WHEN I GOT HOME AND WAS INFORMED TO JUST BRING IT BACK AGAIN. THIS STEERING ISSUE IS BEGINNING TO BE A SEVERE SAFETY HAZARD AND SOMEONE WILL EVENTUALLY BE SERIOUSLY INJURED OR CAUSE A FATALITY. *TR

WHILE OPERATING MY 2009 CAN AM SPYDER, THE POWER STEERING UNIT LOCKED UP CAUSING ME TO VEER ACROSS 2 LANES OF TRAFFIC. THIS HAPPENED 6 TIMES IN A 1 HOUR PERIOD AND THEN 2 TIMES WHILE RIDING BACK HOME. THIS ISSUE HAPPENED ONCE BEFORE ON AUGUST 10TH BUT THE EFFECTS WERE NOT AS STRONG AND I ATTRIBUTED THIS TO THE ROAD CONDITIONS. *TR

'08 CAN AM SPYDER. WHEN RIDING IN HIGH CROSSWINDS, STEERING WOULD INTERMITTENTLY "STICK" WHEN CORRECTING BACK INTO CROSSWIND. HAD BRP'S 2ND SOFTWARE UPDATE DONE AND NOW STEERING "STICKS" ALL THE TIME JUST OFF CENTER TO THE LEFT. THE STEERING DOES NOT COMPLETELY SEIZE, BUT DEFINITELY TAKES EXTRA EFFORT TO TURN. HAVE ALMOST GONE INTO THE DITCH A FEW TIMES AS IT CAUGHT ME UNAWARES. NO PARTS REMOVED AND REPLACED AT THIS TIME. *TR

RIDING MY 2008 CAN-AM SE5 SPYDER I WAS TRAVELING NORTH ON I95 AT 75MPH ATTEMPTING TO PASS A SEMI WHEN THE SPYDER STARTS TO BUCK, & LOSE POWER AND THE DASH LIGHTS UP. ENGINE LIGHT, VSS LIGHT AND DPS PROBLEM SCROLLING. TERRIFYING TO ALL OF A SUDDEN HAVE NO POWER WHILE ALL AROUND U ARE DOING 70 AND YOUR 3 LANES AWAY FROM A TURN OFF W/ LITTLE POWER AND ERRATIC STEERING.. I GOT OFF TO THE SIDE AND TURNED EVERYTHING OFF AND BACK ON & FAULT WAS STILL THERE. DID IT AGAIN & IT WAS GONE, SO I CAUTIOUSLY GOT BACK ON THE FREEWAY, ONLY TO HAVE IT HAPPEN AGAIN 20 MILES LATER. AGAIN SURROUNDED BY SEMIS. PULLED OVER. TURNED IT OFF & BACK ON. EVERYTHING OK. THIS TIME IT DIDN'T HAPPEN AGAIN, BUT JUST IN CASE I STAYED IN THE RIGHT LANE SO I COULD GET OFF IN A HURRY IF I HAD TO. *TR

2008 CAN-AN SPYDER MODEL SE5 POWER STEERING PROBLEMS :POWER STEERING LOCKS UP OR CATCHES AND EXTRA EFFORT IS REQUIRED TO TURN THE HANDLE BARS. WHEN THE BARS DO RELEASE THE EXTRA EFFORT CAUSES VEHICLE TO SWERVE MAKING OF A VERY DANGEROUS CONDITION. ALSO MOTOR SURGES WHEN SHIFTING, BACK FIRES WHEN SLOWING AND QUITS AT RED LIGHTS ....EVEN THOUGH THE INCIDENT DATE IS STATED AS 10-17 THIS HAS BEEN AN ONGOING PROBLEM FROM DATE OF PURCHASE,AND THERE HAVE BEEN 2 UPDATES DONE BY CAN-AM BUT THE PROBLEMS REMAIN. *TR

WHILE DRIVING MY CAN AM SPYDER SM5 ON THE FREEWAY ON 11/7/O9 IT PULL TO THE RIGHT INTO THE OTHER LANE IT FELT LIKE IT LOCK UP AND VERY HARD TO STRAIGHTENED WHEELS, IT HAPPEN ABOUT SIX TIMES IN FIVE MILE RADIUS. *TR