2003 CHEVROLET ASTRO Complaints

THROTTLE CABLE STICKING DUE TO OUTER LAYER OF BRAIDED CABLE BEING FRAYED. ROUTING OF CABLE CAUSED A KINK IN THE OUTER JACKET THAT FRAYED THE OUTER LAYER OF A BRAIDED CABLE FROM THE GAS PEDDLE TO THE THROTTLE BODY. THIS CAUSED THE THROTTLE TO OPEN AND REMAIN AT WHAT EVER POINT IT WAS BY THE PUSHING THE ACCELERATOR PEDAL CAUSING UNCONTROLLABLE ACCELERATION. THE CABLE WAS ROUTED BELOW A HOSE AT THE FIREWALL PUSHING THE OUTER JACKET DOWNWARD AND WAS THAT WAY FROM THE FACTORY AS FAR AS I AM AWARE. NO HOSES HAVE BEEN CHANGED. REPLACED THE THROTTLE CABLE AND ROUTED IT ABOVE THE HOSE AT THE FIREWALL TO ELIMINATE THE DOWNWARD PRESSURE ON THE OUTER JACKET AND ALL IS OPERATING PROPERLY. DEALER HAD NO INTEREST IN FIXING OR INVESTIGATING THE PROBLEM WITHOUT COST BEING INCURRED BY ME. MADE THE REPAIR MYSELF WITH A NEW THROTTLE CABLE OBTAINED THROUGH A DEALER PARTS DEPARTMENT. *TR

2003 CHEVROLET ASTRO VAN. DROVE VEHICLE WITHOUT INCIDENT ON AUGUST 1, 2010. MONDAY MORNING AUGUST, 2, 2010 BATTERY WAS DEAD (PURCHASED NEW FEBRUARY 2010). REPLACED WITH NEW BATTERY ON AUGUST 2, 2010. FIRST CONNECTED THE POSITIVE CABLE. ATTEMPTED TO CONNECT NEGATIVE CABLE. NEGATIVE POST TERMINAL SPARKED AND BATTERY CABLE GOT VERY HOT. DISCONNECTED BATTERY CABLE. INSPECTED FUSES. ALL GOOD. TRACE VISIBLE PORTIONS OF POSITIVE CABLE TO FUSE BOX, ALTERNATOR, AND STARTER. NO INDICATION OF GROUNDING. CONTACTED MECHANIC WHO ON AUGUST 14, 2010 PERFORMED TEST ON FUSE BOX, ALTERNATOR, AND STARTER. ALL GOOD. MECHANIC THOROUGHLY TRACED POSITIVE CABLE. DISCOVERED SHORT LOCATED AT THE PASSENGER SIDE OF THE ENGINE BEHIND THE STEERING LINKAGE. STATED THAT CABLE SHEATH HAD BEEN WORN AWAY BY THE RUBBING OF THE TIE ROD AND WAS GROUNDING OUT ON THE BODY AND THAT IT WAS EXTREMELY FORTUNATE THAT THE VEHICLE HAD NOT CAUGHT ON FIRE. I HAD TO HAVE THE VEHICLE TOWED TO CHEVROLET DEALERSHIP AND HAD CABLE REPLACED. *TR

I WAS DRIVING APPROXIMATELY 30 MILES PER HOUR ALONG SLIGHTLY SNOW-COVERED ROAD TOWARDS STOPPED TRAFFIC AT RED LIGHT ON A SLIGHT DOWNGRADE. I STEPPED ON THE BRAKES GENTLE, AS REQUIRED BY THE CONDITIONS, BUT THE ABS SYSTEM STARTED TO SHUDDER AND THE VEHICLE DID NOT BRAKE AT ALL. I HIT A STOPPED VEHICLE AT THE INTERSECTION AND EVEN WITH A RELATIVELY SLOW SPEED IMPACT, OUR VEHICLE WAS WRITTEN OFF AND THE OTHER WAS TOWED AWAY BECAUSE IT COULD NOT BE DRIVEN. OUR VAN WAS DRIVABLE, BUT JUST BARELY, AND WAS SUBSEQUENTLY WRITTEN OFF BY THE INSURANCE COMPANY. I WAS CHARGED WITH CARELESS DRIVING WHICH WAS ABSOLUTELY NOT THE CASE. WE HAVE ANOTHER VEHICLE OF THE SAME YEAR AND SIMILAR MODEL AND IT DOES THE SAME THING OCCASIONALLY BUT SO FAR THIS HAS NOT RESULTED IN ANY FURTHER COLLISIONS. WE HAVE OWNED ASTRO VANS SINCE THEY WERE FIRST MARKETED IN 1985 AND THIS IS THE FIRST ONE TO ACT LIKE THIS. WE PURCHASED 1985, 1992, 1998, AND 2003 MODELS (2). I AM ASKING MY WIFE, ROSE, WHO IS ALSO THE REGISTERED OWNER OF THE VEHICLE TO SUBMIT THIS REPORT ON MY BEHALF. PLEASE RESPOND TO HER WITH ANY RESOLUTIONS. WE PURCHASED THE SALVAGE FROM THE INSURANCE COMPANY SO IT IS STILL IN OUR POSSESSION ALTHOUGH NOT ON THE ROAD. *TR

I OWN A 2003, CHEVROLET ASTRO. ON SUNDAY, JUNE, 28, 2009, I WAS DRIVING ON I-94, BETWEEN ALEXANDRIA, MN AND FERGUS FALLS, MN. I HAD MY CRUISE CONTROL SET AT 70 MPH, THE POSTED SPEED LIMIT, WHEN I APPROACHED A VEHICLE THAT WAS TRAVELING AT A SLOWER SPEED. I PULLED OVER TO THE LEFT LANE AND PROCEEDED TO PASS. AS I WAS PASSING, I LOOKED IN MY REAR VIEW MIRROR AND NOTICED A VEHICLE WAS COMING UP TO ME AT A FAST PACE, SO I STEPPED ON THE ACCELERATOR, TO GET BY THE VEHICLE, THAT I WAS PASSING, A LITTLE QUICKER. WHEN I PASSED THE VEHICLE, I LET UP ON THE ACCELERATOR, TO GET BACK TO THE SPEED I WAS PREVIOUSLY TRAVELING. INSTEAD OF MY VEHICLE SLOWING BACK DOWN, IT CONTINUED TO GO FASTER, I TOUCHED MY BRAKE PEDAL, TO RELEASE THE CRUISE CONTROL, BUT MY VEHICLE CONTINUED TO PICK UP SPEED, 80MPH AND CLIMBING. I THEN STEPPED ON MY BRAKE, ON AND OFF, TO GET BACK TO ABOUT 60MPH, MOVED MY SWITCH,FOR THE CRUISE CONTROL, TO THE OFF POSITION. I CONTINUED TO PICK UP SPEED. THERE JUST HAPPENED TO BE AN EXIT, TO A TOWN, SO I WENT UP THE EXIT, STEPPING ON AND OFF THE BRAKE PEDAL TO SLOW DOWN. WHEN I GOT TO THE TOP OF THE EXIT, I TURNED OFF THE IGNITION AND WITH THE HELP OF BRAKING, I COASTED TO A STOP. AT THIS POINT, BOTH MY WIFE AND I WERE VERY SCARED. I THOUGHT MY CRUISE CONTROL HAD STUCK, SO I TURNED ON THE IGNITION AND THE ENGINE ROARED, SO I SHUT IT OFF. I TRIED IT ONCE MORE AND THE SAME THING HAPPENED. THEN I KNEW IT WAS MORE THAN THE CRUISE CONTROL, SO I CALLED MY ROADSIDE SERVICE. AFTER ABOUT A TWO HOUR WAIT,THEY BROUGHT MY VAN TO A CHEVROLET DEALER IN ALEXANDRIA, MN. IT WA DETERMINED, BY A MECHANIC, THE NEXT DAY, THAT MY ACCELERATOR CABLE WAS FRAYED AND THAT CAUSED IT TO STICK. THE ACCELERATOR CABLE WAS REPLACED. I HAVE THE FRAYED CABLE. *TR

VEHICLE: 2003 CHEVY ASTRO VAN DEFECT SUMMARY: FACTORY DESIGN DIRECTS LEAKED BATTERY ACID TO DRIP DOWN ON A STEEL BRAKE LINE. DETAILS: THE (+) BATTERY TERMINAL SPONTANEOUSLY BROKE OFF THIS VEHICLE'S OEM DELCO BATTERY. THE BREAKAGE WAS DUE TO EITHER: 1) CABLE CONNECTOR BEING OVER-TORQUED AT THE GM FACTORY, OR 2) AN INTEGRAL FAULT WITHIN THE BATTERY. THE DESIGN OF THIS YEAR-MODEL OF ASTRO IS SUCH THAT THE NATURAL PATH FOR ACID DRIP-PAGE IS ON TO A STEEL BRAKE LINE LOCATED BELOW, AND IN FRONT, OF THE BATTERY. I AM GOING TO HAVE THE BRAKE LINE REPLACED BY A LOCAL CERTIFIED MECHANIC BECAUSE THE LINE IS SEVERELY CORRODED DUE TO THE ACID EXPOSURE. BECAUSE OF THE INACCESSIBILITY OF THE BRAKE LINE AND ITS CONNECTIONS, THE REPAIR COST WILL NOT BE CHEAP. PLEASE NOTE THAT THE BATTERY AND CABLE HAVE NOT BEEN EXPOSED TO ANY POST-MANUFACTURE MISUSE OR DISTURBANCE. THE PROBLEM IS SOLELY DUE TO POOR PLACEMENT OF THE HYDRAULIC LINE, COUPLED WITH THE FACTORY INDUCED BATTERY BREAKAGE. I HAVE DIGITAL PHOTOGRAPHS FOR YOUR INSPECTION OF THE BROKEN BATTERY TERMINAL, THE GEOMETRY OF THE BATTERY COMPARTMENT, THE (BRAKE) HYDRAULIC LINE, AND THE RESULTING CORROSION. *TR

THE BRAKE LINE RUBBED UP AGAINST THE POWER STEERING PUMP, EVENTUALLY RUBBING THROUGH. I LOST BRAKING POWER AND NEARLY CAUSED AN ACCIDENT. WITHIN MINUTES, I WENT FROM HAVING BRAKES TO HAVING TO PUSH THE BRAKE PEDDLE TO THE FLOOR TO STOP. I HAD A LOCAL MECHANIC FIX THE PROBLEM AT A SUBSTANTIAL COST. *TR

2003 CHEVROLET ASTRO WITH BRAKE PROBLEMS. CONSUMER STATES THAT GM WILL NOT REIMBURSE HER FOR THE REPAIRS MADE ON HER VEHICLE. *KB THE CONSUMER STATED WHILE BRAKING AT LOW SPEEDS, THE VEHICLE LUNGED FORWARD. ALSO, THE ABS LIGHT ILLUMINATED. THE CONSUMER HAD TO PAY TO HAVE THE SENSORS REPLACED. *JB

THURSDAY SEPTEMBER 20, 2007 4:30 P.M. . TRANSMISSION FAILURE, 200 MILES FROM HOME IN CALIFORNIA. DRIVING ON HIGHWAY, HEARD ROARING SOUND FROM ENGINE, WOULD NOT ACCELERATE SPEED DROPPED. EXITED FREEWAY LOOKING FOR MECHANICAL HELP, NONE AVAILABLE. OVERNIGHT IN CAMPGROUND. NEXT DAY TO LOCAL REPAIR SHOP FOR DIAGNOSIS OF TRANSMISSION FAILURE. VAN HAD TO BE TOWED TO SANTA BARBARA, CALIFORNIA. TRANSMISSION REPLACED, SEPT. 21, '07. *TR

ON SEVERAL OCCASIONS OVER THE PAST FEW MONTHS, THE ABS LIGHT ON MY VAN HAS BEEN COMING ON AND WHEN I APPLY THE BRAKES, THE VAN JERKS AROUND ON THE ROAD AND PULLS TO THE LEFT. I HAVE ALMOST HIT OTHER CARS ON MANY OF THESE OCCASIONS. I HAD MY MECHANIC LOOK AT IT RECENTLY AND HE SAID HE CHECKED OUT THE BRAKING SYSTEM AND CAN SEE NO VISIBLE REASON FOR THIS HAPPENING. *TR

SUMMARY: ON 2003 CHEVY MINIVAN, THE MULTIFUNCTION SWITCH HS DEVELOPED AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE. CONSEQUENCE: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COFAILED TO WARN THE FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD HAVE LEAD TO A VEHICLE CRASH. REMEDY: DEALERS ARE REPLACING 2002 CHEVY ASTRO HAZARD WARNING FLASHER SWITCH FREE OF CHARGE, BUT NOT 2003 ASTROS THAT HAVE THE SAME MANUFACTURER DEFECT. THE RECALL BEGAN ON APRIL 13, 2005 FOR OWNERS OF 2002 CHEVY ASTROS. GM RECALL NO. 05013. *TR