2002 CHEVROLET AVALANCHE 1500 Complaints

I LOST MY BRAKES TOTALLY NOT JUST HALF OF THEM PULLING A SMALL TRAILER WITH IRON GOING DOWN A LONG HILL IN MANKATO, MN. ON MADISON AVE. I REAR ENDED A PICK UP WHICH PULLED OVER AND I CONTINUED ROLLING DOWN THE HILL BUILDING SPEED SO I HAD TO DRIVE MY TRUCK INTO A WALL WITH MY DAUGHTER INSTEAD OF REACHING THE NEXT INTERSECTION. GM HAS NOW CHANGED THEIR BRAKE LINES IN TO STAINLESS STEAL SINCE 2003 BECAUSE THEY KNEW THEY HAD PROBLEMS WITH THEIR BRAKE LINES. MY BRAKE LINES ARE ON TOP OF FRAME RUNNING BACK TO THE REAR AXLE WITH THE GAS TANK BLOCKING MOST OF THE LINES. THERE IS ONLY 1.5 INCHES BETWEEN THE FRAME AND BODY. ALONG SIDE IS THE WIRING HARNESS GOING BACK TO THE REAR, NO ROOM TO INSPECT OR SEE YOUR BRAKE LINES. THIS COULD OF BEEN SO WORSE BECAUSE OF ALL THE TRAFFIC AND OUR LIVES. DO SOMETHING PLS... POLICE REPORT 18-25773 MANKATO POLICE DEPT. BEFORE SOMEONE GETS KILLED!

HEARD SNAP WHILE DRIVING HIT MEDIAN,AND TOTALED MY TRUCK.IT NEEDS TO BE NOTICED IF ANY BODY HASN'T BEEN KILLED YET

TURNING INTO MY DRIVEWAY, SLOWING DOWN, APPLYING BRAKES, THE PEDAL WENT TO THE FLOOR, NO RESISTANCE, PARK BRAKE DIDN'T ,HELP ALMOST HIT MY GARAGE, STEERED TOWARD GARDEN LANDSCAPE TIES, THAT STOPPED ME, LOOKED UNDER TRUCK, LARGE PUDDLE OF BRAKE FLUID DRIPPING , BOTH BRAKE LINES FROM THE MASTER CYLINDER TO THE ABS WERE RUSTED BADLY AND DRIPPING.

EXCESSIVE RUSTING OF THE FRAME, BRAKE LINES, TRANSMISSION LINES, AND FUEL LINES. THE BRAKE, TRANSMISSION AND FUEL LINES RUSTED COMPLETELY OUT AND REQUIRED A FULL REPLACEMENT. THE FRAME HAS EXTENSIVE RUST AND HAS DETERIORATED WELL BEYOND THE FRAME OF MY 2003 CAMARO Z28 WHICH IS 9 YEARS OLDER! THE TRUCK HAS LESS THAN 80K AND HAS BEEN WELL MAINTAINED, SO THERE IS NO EXPLANATION FOR THE AMOUNT AND LEVEL OF RUST, EXCEPT THAT THERE WERE INFERIOR METALS AND MANUFACTURING MATERIALS USED IN ITS CONSTRUCTION.

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 1500. WHILE DRIVING APPROXIMATELY 35 MPH AND ATTEMPTING TO MAKE A SUDDEN STOP, THE DRIVER FORCEFULLY DEPRESSED THE BRAKE PEDAL AND THE PEDAL EXTENDED TO THE FLOOR. AS A RESULT, THE BRAKING DISTANCE WAS EXTENDED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE FLUID WAS LEAKING DUE TO CORROSION IN MULTIPLE BRAKE LINES. THE VEHICLE WAS REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 134,258. *TT *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 1500. WHILE OPERATING THE VEHICLE, THE LOW BEAM HEADLIGHTS SUDDENLY SHUT OFF. WHEN THE CONTACT TAPPED THE FUSE BOX LOCATED UNDER THE HOOD, THE HEADLIGHTS TURNED BACK ON AND ILLUMINATED NORMALLY. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND LOCAL DEALER (BOB BROWN CHEVROLET IN ERVINGDALE, IA) WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 1500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE DECELERATED INDEPENDENTLY AND THE REDUCED ENGINE POWER, SERVICE ENGINE, AND TRACTION ASSIST INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO DON HEWLETT CHEVROLET BUICK (7601 N INTERSTATE HWY 35, GEORGETOWN, TX 78626) WHERE IT WAS DIAGNOSED THAT THE ACCELERATOR PEDAL FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO DON HEWLETT CHEVROLET WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC THROTTLE CONTROL MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SENSORS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED ONCE AGAIN. THE VEHICLE WAS TAKEN TO AUTONATION CHEVROLET LAUREL (500 WASHINGTON BLVD, LAUREL, MD 20707) WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REBUILT, THE TAC MODULE NEEDED TO BE REPLACED, AND THE INTAKE GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THEY COULD NOT ASSIST. THE CONTACT WAS TRANSFERRED TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 24,000.

THE BRAKE LINE BROKE DUE TO RUST AND AS I HAVE SEEN THIS IS A ON GOING THING. GM SAYS IT IS NOT A SAFETY ISSUE BUT IT VERY MUCH IS AS WHEN THE LINE BRAKES YOU LOSE PADDLE AND AT HIGH SPEED THIS COULD KILL PEOPLE. THE FACT THAT THEY DO NOT SEE THIS AS A SAFETY ISSUE TELLS ME A LOT ABOUT GM AND HOW THEY DON'T CARE ABOUT THE PEOPLE THAT BUY FROM THEM. MY TRUCK WAS ON THE BOAT LAUNCH WHEN THE BRAKE FAILED I'M LUCKY I DID NOT LOSE MY TRUCK AND BOAT. THIS NEEDS TO BE FIXED AT NO COST

ABS PUMP OR SPEED SENSOR ARE DAMAGED AND NOT WORKING ON THIS TRUCK. WHEN MY VEHICLE WAS TURNED OFF THE ABS PUMP KEPT RUNNING CAUSING ME TO PULL THE FUSE FOR THE ABS. CHEVROLET IS AWARE OF THIS PROBLEM AS I HAVE BEEN CALLING THEM TRYING TO HAVE THEM INCLUDE MY TRUCK IN THE ABS/SPEED SENSOR RECALL WHICH IS ON OTHER TRUCKS LIKE MINE. CHEVROLET CONTINUES ONLY TO RECALL THESE TRUCKS WHICH WERE MANUFACTURED IN THE "SALT STATES" ONLY. AS STATED ON: HTTP://WWW.CHEVROLETPROBLEMS.COM/RECALLS/AVALANCHE/2002/ SERVICE BRAKES, HYDRAULIC:ANTILOCK RECALL FOR 2002 CHEVROLET AVALANCHE RECALL ANNOUNCED AUGUST 29 2005 NHTSA REFERENCE #05V379000 NUMBER AFFECTED 1,353,718 SUMMARY: CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY. CONSEQUENCE: THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH. FIX: DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. FOR DETAILED INFORMATION & SUPPORTING DOCUMENTS, SEE THE OFFICIAL NHTSA PAGE CONCERNING RECALL #05V379000

CABLES THAT HOLD ON THE TAILGATE HAVE BROKEN ON ONE SIDE. CHEVROLET CLAIMS NO RECALL FOR THIS VIN NUMBER VEHICLE. YET ONLINE IT SAYS 2002 AVALANCHE HAS RECALL FOR CABLES.