2007 CHEVROLET AVEO Complaints

I BOUGHT MY AVEO NEW. AT ONLY 6,000 MILES THE MASTER CYLINDER FAILED AND 5,000 MILES LATER THE BRAKE BOOSTER FAILED AND I CRASHED--THE AIR BAGS DID NOT DEPLOY. GM WOULD FIXED THE BRAKE BOOSTER BUT NOT THE DAMAGE TO MY CAR! AT 13,000 MILES THE BRAKE DRUMS NEEDED TO BE RE-SURFACED, THE BRAKE ROTORS NEEDED TO BE CUT, AND I HAD TO GET NEW BRAKE PADS--AGAIN GM WOULD NOT FIX IT AND MADE ME PAY FOR IT. AT 16,000 MILES THE AIR BAG SENSOR FOR THE PASSENGER FAILED. AT 18,000 MILES THE GAS GAUGE FAILED AND THE SHIFTER GOT STUCK IN PARK, AND THE CRUISE CONTROL WOULD WORK ON AND OFF. AT 20,000 MILES THE ALL FOUR TIRES NEEDED TO BE REPLACED. AROUND THIS TIME, GAS MILEAGE DIPPED TO ABOUT 19-21MPG, BUT GM COULDN'T FIGURE OUT WHY. AT 30,000 MILES I HAD TO GET NEW ROTORS AND BRAKE PADS--AGAIN I HAD TO PAY FOR IT EVEN THOUGH THEY ARE WEARING OUT PREMATURELY. AT 35,000 MILES THE TRANSMISSION STARTED TO SHIFT HARD SO GM RECOMMENDED I CHANGE THE TRANSMISSION FLUID AT A COST $450 BECAUSE THE FLUID HAS A SPECIAL ADDITIVE THAT IS SHIPPED FROM KOREA! AT 44,000 MILES THE ENGINE DIED--MORE LIKE BLEW UP. GM SAID THAT IT IS MY FAULT FOR LETTING IT RUN TOO HOT, THOUGH I HAD NO WARNING FROM ANY GAUGES, LIGHTS, ECT... AGAIN I HAD TO FIX IT EVEN THOUGH I HAD THE 100,000 MILE WARRANTY. AT 48,000 MILES THE A/C NEEDED TO BE OVERHAULED--I HAD TO PAY FOR IT. AT 52,000 MILES I HIT A DEER AND AGAIN THE AIR BAGS DID NOT DEPLOY. THE INSURANCE COMPANY JUNKED IT. ABSOLUTELY WITHOUT A DOUBT IN MY MIND THE WORST CAR I HAVE EVER OWNED. GM SHOULD BE SUED FOR THIS CAR. THEY DO NOT HONOR THE WARRANTY AT ALL. THE SERVICE DEPARTMENTS TREATED ME WITH DISRESPECT. A COUPLE OF DEALERS REFUSED TO EVEN ACCEPT MY CAR FOR REPAIR. THE CAR IS VERY SCARY TO DRIVE AND NOT SAFE AT ALL. WITH ALL THE MONEY I SPENT FIXING THE CAR PLUS MY CAR PAYMENT EACH MONTH, I COULD HAVE EASILY PURCHASED A BMW INSTEAD. GM IS ABSOLUTELY THE WORST FOLKS TO DEAL WITH. NEVER AGAIN WILL I BUY OR SUPPORT ANYTHING FROM GM. *TR

BACK IN MAY OF 2008 I PICKED MY SON UP FROM SCHOOL, I SMELLED A SMELLED LIKE ANTIFREEZE. I STOPPED AT THE STORE BUT I DIDN'T THINK IT WAS MY CAR. ABOUT AN HOUR LATER, WHEN WE WENT TO CHURCH, I SMELLED THE SAME SMELL, BEING WE WERE THE ONLY CAR IN THE PARKING LOT, I KNEW THEN IT HAD TO BE MY CAR. WE PUT WATER IN IT AND WAITED UNTIL THE NEXT MORNING TO TAKE TO THE DEALERSHIP WE PURCHASED THE CAR FROM. THEY SAID IT APPEARED THAT I HAD HIT SOMETHING AND THE BOTTOM OF THE RADIATOR WAS DAMAGED HOWEVER I KEPT SAYING I DIDN'T HIT ANYTHING AND THEY TOLD ME TO TRY TO TURN IT IN TO MY INSURANCE AND SEE IT THEY WOULD COVER IT. ONE MAN EVEN WALKED ME TO THE CAR AND SAID IF I NEEDED HELP THAT "HELP ME OUT". THAT AFTERNOON I WAS ON THE PHONE WITH THE INSURANCE COMPANY TELLING THEM EXACTLY WHAT THE DEALERSHIP SAID THAT I HAD TO HAVE HIT SOMETHING BUT I DIDN'T REMEMBER HITTING ANYTHING WOULD THEY COVER IT. IN THE END THE INSURANCE COMPANY COVERED THE REPAIR OF THE RADIATOR PLUS 5 DAYS OF RENTAL CAR. WHEN WE WENT TO HAVE THE REPAIR DONE ON THE RADIATOR, WE ASKED FOR THE OLD RADIATOR BACK. MY HUSBAND TOOK IT BACK TO HIS SHOP AND DID A PRESSURE TEST ON IT. THE HOLE WAS ACTUALLY IN THE MIDDLE OF IT NOT IN THE BOTTOM AND YOU COULD SEE WHERE THE FAN SHROUD LINED UP WHERE THE RADIATOR MOUNTS TO IT AND IT HAD RUBBED A HOLE IN IT CAUSING THIS WHOLE PROBLEM. EVEN THOUGH THE INSURANCE COVERED THIS, I STILL THOUGHT RETRIBUTION NEEDED TO BE MADE BECAUSE PERHAPS THIS WAS A LEMON CAR OR EITHER A RECALL NEEDED TO BE DONE. THIS HAPPENED AT 23,000 MILES APPROXIMATELY. THEN THE FOLLOWING MONTH THE SAME FAN SHROUD RUBBED A HOLE IN THE AIR CONDITION LINE AND WE WERE WITHOUT AIR ABOUT 2,000 MILES LATER AND THE DEALERSHIP TOOK RESPONSIBILITY FOR THIS AND COVERED THIS UNDER THE WARRANTY. IT REALLY DIDN'T MAKE ANY SENSE. I HAVE CALLED GMAC AND THEY HAVE SAID THE DEALERSHIP ARE THEIR EYES AND EARS AND WE HAVE GIVEN THEM THE OLD RADIATOR BACK SO THEY COULD SEE WHAT WE SAW . *TR

OUR CHEVY AVEO ONCE AGAIN WAS BROKEN THREE TIMES IN ONE MONTH THE CLUTCH STUCK IN PARK MODE UNABLE TO GO INTO DRIVE MODE CHEVY AVEO WAS EARLIER WITH CLUTCH STUCK ON JUNE 15, 2008, JULY 15, 2008 AND JULY 21, 2008. CHEVY AVEO FAILED TO RESPOND TO RECALL THE CHEVY AVEO AS THIS IS A SERIOUS HAZARD TO MY FAMILY. COUPLE OF OBSERVATIONS: CHEVY AVEO HAD A FULL TANK WHEN IT WAS DELIVERED ON 7/21/2008 AT 14889 MILES. WHEN I PICKED UP THE CHEVY AVEO ON 7/23/08 IT SHOWED AN 1/8 FUEL WAS USED DURING THIS SERVICE SHOWING MILEAGE AT 14962. GAS BEING EXPENSIVE AT THIS TIME I WAS WONDERING WHETHER IT WAS TEST DRIVEN FOR 75 MILES? SECONDLY, TEAM CHEVROLET INVOICE STATES " CUSTOMER STATES THE KEY WOULD COME OUT OF THE IGNITION? I NEVER STATED THIS AT ANY TIME. THE PURPOSE WHY THE CHEVY AVEO WAS SENT BACK TO THE SERVICE CENTER WAS BECAUSE THE CLUTCH SHIFT WAS STUCK ONCE AGAIN IN PARKING MODE AND WOULD NOT MOVE BACK TO DRIVE MODE. THERE WAS NO PROBLEM WITH THE KEY AT ANY GIVEN TIME, IGNITION KEY HAD FREE MOVEMENT. THANKS FOR YOUR SERVICE. *TR UPDATED 07/24/08

THE ANTENNA MODULE HAS WENT OUT 2 TIMES. WHEN THIS HAPPENS YOU CANNOT PLAY THE RADIO DUE TO MAJOR STATIC WHEN YOU TURN ON THE REAR DEFROSTER. *TR

A PINHEAD SIZE CHIP ON THE PASSENGER SIDE WINDSHIELD BASE HAS CREATED A CRACK SPREADING ACROSS THE MIDDLE OF THE WINDSHIELD. I BELIEVE THIS IS A FLAW IN THE WINDSHIELD DESIGN, FACTORY INSTALLATION, AND/OR AERODYNAMIC DESIGN. MY WEB RESEARCH HAS SHOWN THAT OTHER CHEVROLET OWNERS HAVE HAD THIS PROBLEM WITH THE AVEO AND OTHER MODELS. THE DEALERSHIP DOES NOT ACCEPT ANY WARRANTY RESPONSIBILITY. *TR

BOTH HEADLIGHTS ON THE LOW BEAM SETTING FAILED TO WORK. HIGH BEAMS WORKED AS THEY SHOULD. FUSES, HEADLIGHT SWITCH, PARKING BRAKE SWITCH, AND RELAYS CHECKED OUT OK. THE ASSUMPTION IS THAT A VOLTAGE SPIKE BURNED OUT THE LOW SIDE OF THE BULBS AT THE SAME TIME WITHOUT BLOWING ANY FUSES. THIS WAS DISCOVERED DURING THE DAY RATHER THAN AT NIGHT. *TR

TL*THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING 50 MPH, THE VEHICLE BEGAN TO VEER OFF THE ROAD DUE TO ITS WEIGHT. THE FAILURE ALSO OCCURS WHILE THE VEHICLE IS AT A STOP AND ANOTHER VEHICLE PASSES. THE VEHICLE WAS NOT DIAGNOSED BY THE DEALER. THE CURRENT MILEAGE WAS 28,733 AND FAILURE MILEAGE WAS 24,000.

TL*THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE VEHICLE HAS BEEN FAILING EVER SINCE IT WAS PURCHASED. WHILE DRIVING BETWEEN 35-70 MPH, THE CONTACT SMELLS SOMETHING BURNING. THE CONTACT LEFT THE VEHICLE AT THE DEALER ON FOUR OCCASIONS FOR REPAIR, BUT NO WORK WAS EVER PERFORMED. THE ROAD CONDITIONS WERE DRY AND SUNNY AT THE TIME OF THE INCIDENT. OCCASIONALLY, WHILE DRIVING 40 MPH, THE VEHICLE WILL NOT SWITCH GEARS AND THE CRUISE CONTROL DOES NOT OPERATE PROPERLY. THE HEADLIGHTS TURN ON AND OFF WITHOUT THE VEHICLE TURNED ON. THE AUTOMATIC DOOR LOCKS NO LONGER WORK AND THE CONTACT HAS TO USE HER KEY TO ENTER THE VEHICLE. AFTER LOCKING THE DOORS, THEY SOMETIMES DO NOT OPEN FROM WITHIN THE PASSENGER COMPARTMENT. THE CONTACT CARRIES A HAMMER IN THE VEHICLE IN CASE SHE HAS TO BREAK THE WINDOWS TO ENTER THE VEHICLE. THE CURRENT MILEAGE WAS 5,080 AND FAILURE MILEAGE WAS 56. UPDATED 5/30/08 *CN THE AIR BAG LIGHT STAYED ON, THE TRUNK LID WOULD POP OPEN WHILE THE CONSUMER WAS DRIVING, THE DRIVER SIDE DOOR WOULD OPEN AS WELL, THE TRANSMISSION HAD A STRANGE ROARING SOUND AND IT WAS ALSO HARD TO UPSHIFT AND DOWNSHIFT, THE ODOMETER WOULD JUMP FORWARD ON ITS OWN WHEN IT WAS PARKED AND THEN RESTARTED, THE HORN WOULD BLOW ON ITS OWN WHEN NO ONE WAS IN THE VEHICLE. UPDATED 05/30/08

BEARING AND HUB ASSEMBLY HAD TO BE REPLACED ON LEFT SIDE AND ALSO THE ADJUSTER ASSEMBLY ON THE DRIVERS FRONT SEAT HAD TO BE REPLACED. *TR

SOMETIMES WHEN IT IS WINDY,OR WHEN A SEMI COMES FROM OPPOSITE DIRECTION, THE CAR WILL SORT OF JERK & GET A LOUD SQUEALING NOISE. HAVE TOLD THE DEALER WHERE WE GOT THE CAR TWICE NOW & THEY SAID IT IS JUST A NOISE FROM THE AERODYNAMICS . I HAVE ASKED ANOTHER PERSON IF THEY HAD THIS WITH THEIR AVEO & THEY SAID NO. THIS HAS HAPPENED A LOT FOR THE LAST SEVERAL MONTHS. THERE WERE TIMES IN BOTH 2007 & 2008. *TR