2004 CHEVROLET AVEO Complaints

IN MID-FEBRUARY AFTER ONE OF OUR MANY BLIZZARDS, MY WIFE WAS DRIVING HER SEDAN HOME. THERE WAS A PILE OF SNOW ON OUR STREET THAT HAD HARDENED OVER. I GUESS SHE MISCALCULATED ITS HEIGHT (AND HARDNESS) AND WHEN SHE WENT OVER IT, THE CAR LURCHED UP AND SHE HEARD A LOUD GRINDING SOUND AGAINST THE UNDERCARRIAGE. THE ENGINE STARTED SHAKING IMMEDIATELY AND WITHIN SECONDS DIED. SHE CALLED ME OUT AND I TOOK A LOOK AT THE CAR. IT WAS DEAD. I WALKED OVER TO THE ICE AND IT WAS ROCK HARD, SO I TRIED TO TAKE A SHOVEL TO IT AND IMMEDIATELY EMAILED MY NEIGHBORS TO BE CAREFUL OF IT. I AM NOT MECHANICALLY-INCLINED, SO WHEN I GOOGLED WHAT MIGHT'VE HAPPENED, I SAW SEVERAL COMMENTS THAT IT COULD BE AS MINOR AS A DAMAGED OIL PAN THAT CAUSES THE ENGINE TO SHUT DOWN. FIGURING IT MIGHT BE SOMETHING MINOR, I CALLED AAA (HAD TO WAIT A FEW DAYS SINCE THEIR LINES WERE DOWN) AND HAD THE CAR TOWED DOWN THE STREET TO A SERVICE STATION. I WAS NOT EXPECTING THE ASSESSMENT FROM THE MECHANIC: APPARENTLY DURING THE COLLISION, THE TIMING BELT SLIPPED AND CAUSED THE PISTONS TO BEND. THIS WOULD COST SEVERAL THOUSAND TO FIX. UNFORTUNATELY, THIS CAR HAS AN "INTERFERENCE" DESIGN WHICH IS PRONE TO EXTENSIVE DAMAGE WHEN THIS HAPPENS. MANY AVEO OWNERS HAVE COMPLAINED ABOUT THIS ONLINE. THE WORST PART ABOUT ALL OF THIS IS THAT EVEN THOUGH IT HAPPENED DURING A COLLISION, OUR INSURANCE CHALKED THIS UP TO "WEAR AND TEAR" AND WE WERE FORCED TO JUNK THE CAR. OUR CAR HAD LESS THAN 60K MILES ON IT AND WE KEPT IT IN GOOD CONDITION. THIS SHOULD NOT HAVE HAPPENED. THIS SHOULD HAVE EITHER BEEN HANDLED THROUGH A MANUFACTURER RECALL OR MY INSURANCE SHOULD HAVE TREATED IT AS THE COLLISION IT WAS AND COVERED IT.

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE CONTACT CALLED THE AUTHORIZED DEALER SEVERAL TIMES FOR MONTHS AND THEY INDICATED THAT THE PART WAS NOT AVAILABLE AND THAT THE REPAIR WAS NOT URGENT. UPON STARTING THE VEHICLE, GRAY SMOKE STARTED TO EMIT FROM UNDER THE HOOD INTO THE INTERIOR OF THE VEHICLE. THE CONTACT RELEASED THE HOOD LATCH QUICKLY AND HAD A PASSENGER DISCONNECT THE BATTERY. HOWEVER, A FIRE ERUPTED NEAR THE FRONT OF THE VEHICLE AS SMOKE FILLED THE VEHICLE CAUSING POOR VISIBILITY THAT IMPACTED THE CONTACT'S BREATHING. THE CONTACT AND THE DRIVER WERE ABLE TO QUICKLY EXIT THE VEHICLE. THE CONTACT WAS ABLE TO EXTINGUISH THE FLAMES WITH A FIRE EXTINGUISHER. A POLICE REPORT WAS NOT FILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND WAS PARKED AT THE CONTACT'S RESIDENCE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT EXPERIENCED AN INTERMITTENT FAILURE WITH THE EXTERIOR LIGHTING. THE FAILURE MILEAGE WAS UNKNOWN.

RECEIVED A RECALL NOTICE FOR DRL FIRE HAZARD. CALLED 3 DEALERSHIPS IN THE DALLAS AREA TO HAVE THE MOSFET REPAIRED. ALL 3 DEALERSHIP DENY ANY KNOWLEDGE OF THE RECALL AND DO NOT HAVE THE PARTS IN STOCK EVEN IF I DID BRING THE RECALL NOTICE IN. CHEVY HAS SENT 2 E-MAILS BUT THEY ARE THE DO NOT REPLY. I HAVE ATTEMPTED NUMEROUS TIMES TO CONTACT CHEVY CUSTOMER SERVICE AND CANT GET ANYONE TO RESPOND. THIS IS A FIRE HAZARD, PLEASE HELP ME TO GET THIS FIXED. *TR

TL* THE CONTACT OWNED A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V2610000 (EXTERIOR LIGHTING). WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT'S VEHICLE TAPPED ANOTHER VEHICLE. THE CONTACT NOTICED FLAMES UNDER THE HOOD OF THE VEHICLE. THE VEHICLE BECAME ENGULFED IN FLAMES AND WAS DESTROYED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD AN ABNORMAL NOISE AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TIMING BELT FRACTURED AND THE ENGINE WAS RUINED. THE VEHICLE WAS UNABLE TO BE REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000. UPDATED 5/4/15*CN UPDATED 05/12/15*JB

TL*THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LAMP ILLUMINATED SEVERAL TIMES AND THEN TURNED OFF. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH, THE VEHICLE WAS SHAKING VIOLENTLY AND STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND UPON PULLING OVER, THE CONTACT NOTICED FLAMES AND SMOKE WAS EMITTING FROM UNDER THE HOOD NEAR THE FRONT PASSENGER SIDE. THE DRIVER AND THE FRONT PASSENGER EXIT THE VEHICLE. THE FIRE WAS ABLE TO BE EXTINGUISHED BY THE FIRE DEPARTMENT. A POLICE REPORT WAS FILED. THE DRIVER AND FRONT PASSENGER DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 14V261000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT INSPECTED OR DIAGNOSED. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. WHILE STARTING THE VEHICLE, SMOKE EMITTED FROM THE VENTS AND CD PLAYER WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 88,000. UPDATED 5/5/15*CN UPDATED 10/23/2015 *JS

I WAS DRIVING AND THE CAR JUST STOPPED .. IF I WAS DRIVING ANY FASTER OR IF THERE WAS A CAR BEHIND ME I WOULD HAVE BEEN KILLED!!!!RESULT WAS THE TIMING BELT. THE CAR ONLY HAD 52000 MILES. I CONTACTED CHEVY AND ALL THEY COULD OFFER ME WAS A LOYALTY DISCOUNT ON A NEW CAR... WHICH I PROBABLY WOULD BE ENTITLED TO ANYWAY .. I JUST FOUND A LETTER FROM GM INDICATED THAT THE REQUIRED REPLACEMENT OF THE TIMING BELT WAS AT 60K MILES... WELL MY CAR DIDN'T MAKE IT TO 60K .....SO THEY KNOW THAT THERE IS A PROBLEM AND CONTINUE TO DENY IT!! *JS