2004 CHEVROLET AVEO Complaints

2004 CHEVY AVEO THERMOSTAT HOUSING - CRACKED AND OVERHEATED. TONS OF REFERENCES ON INTERNET ON THIS SAME PROBLEM. *TR

I WAS DRIVING HOME ON THE HIGHWAY IN MY 2004 CHEVY AVEO. SUDDENLY I NOTICED THAT I WAS UNABLE TO ACCELERATE AND THAT I HAD LOST PRESSURE IN MY BRAKES. I HAD TO PULL OVER TO THE SIDE OF THE ROAD AND PUT ON MY HAZARD LIGHTS. IT WAS VERY BUSY TRAFFIC AND I NARROWLY AVOIDED AN ACCIDENT. MY ENGINE WOULD NO LONGER START. AFTER HAVING MY CAR TOWED TO MY MECHANIC I DISCOVERED MY TIMING BELT/CHAIN HAD BROKEN AND DAMAGED MY ENGINE AND THAT IT WILL HAVE TO BE REPLACED. CAR ONLY HAS 55,000 MILES. *TR

I PURCHASED THIS USED 2004 CHEVY AVEO FROM TONY HONDA END OF JULY 2010. IT RAN GOOD UP UNTIL 10/12/10 WHEN ALL OF A SUDDEN THE HOLD BUTTON LIGHT FLASHED ALONG WITH THE CHECK ENGINE LIGHT...THE CAR LITERALLY DROPPED TO LIKE 5 MILES AN HOUR AND SPUTTERED ALL THE WAY LIKE IT WAS DYING....THANK GOD THAT FOR SOME REASON, I DECIDED TO TAKE MY GRANDSON TO SCHOOL SO I WAS IN THE SCHOOL ZONE AND NOT ON THE FREEWAY WHICH I NORMALLY WOULD HAVE BEEN. I SWEAR, I WOULD HAVE BEEN DEAD HAD THAT HAPPENED AT 60 MILES AN HOUR. I HAVE CALLED CHEVY AND THEY DO NOT HAVE A RECALL. *TR

TL*THE CONTACT OWNS A 2004 CHEVROLET AVEO. WHILE THE CONTACT WAS DRIVING 55 MPH IN RAINY WEATHER CONDITIONS, THE VEHICLE BEGAN TO JERK AND THE ENGINE STALLED WITHOUT WARNING. THE ENGINE WOULD NOT RESTART. THE VEHICLE COASTED TO THE SIDE OF THE ROAD AND THEN TOWED TO A NEARBY INDEPENDENT MECHANIC. THE FAILURE WAS ATTRIBUTED TO THE TIMING BELT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 59,000. UPDATED 01/24/11 *BF THE CONSUMER WAS QUOTED A PRICE OF $2500, BUT INFORMED IT MAY BREAK AGAIN. UPDATED 03/22/11

2004 CHEVROLET AVEO. CONSUMER STATES THE VEHICLE STOPPED IN THE MIDDLE OF TRAFFIC ON THE HIGHWAY *TGW THE CONSUMER STATED THE TIMING BELT FAILED. *JB

THERMOSTAT HOUSING BUSTED ON THE MIDDLE OF HIGHWAY CAUSING CAR TO IMMEDIATELY RUN HOT. *TR

MY 2004 CHEVROLET AVEO'S THERMOSTAT HOUSING BUSTED TODAY AT 67,000 MILES. THIS RESULTED IN OVER HEATING THE MOTOR AND DUMPING ABOUT ONE GALLON OF ANTI-FREEZE ON THE ROADWAY. IT TURNS OUTS THIS PART WAS MADE OUT OF PLASTIC. A REPLACEMENT ALUMINUM VERSION IS NOW AVAILABLE BY THE DEALER FOR $95. *TR

2004 CHEVY AVEO WITH 41,000 MILES. TIMING BELT BROKE, BENDING ALL OF THE VALVES IN THE ENGINE. NO PRIOR PROBLEMS WITH THIS CAR. REPLACED THE TIMING BELT, WILL NOW HAVE TO REPLACE THE HEAD ON THE ENGINE. *TR

I HAVE A 2004 CHEVY AVEO THAT WAS PURCHASED BRAND NEW. SINCE IT WAS FIRST PURCHASED THE CLOCK HAS CHANGED TIME BY ITSELF AND THE GEAR SHIFT GETS STUCK IN PARK. *TR

I WAS DRIVING AT 65 MPH AND THE CAR STALLED AND HAD TO CROSS TWO LANES OF TRAFFIC TO GET TO THE SIDE OF THE ROAD. THE TIMING BELT HAS BEEN THE SOURCE OF MY PROBLEM, IT STRIPPED OUT THE TEETH ON THE BELT. WHY WOULD CHEVY USE A TIMING BELT WHEN ALL OF ITS OTHER CARS USE CHAINS, WHY NOT MODIFY THE ENGINE THEY BOUGHT FROM DAEWOO AND PUT A CHAIN ON IT. *TR