2019 CHEVROLET BOLT EV Complaints

Part of the charging element - the metal clip- locks up and will not allow the car to be plugged in to charge. According to Chevrolet dealer this is a known issue but customers have not been notified by GM. They do not have a fix other than taking the car to the dealer and doing a factory reset. This is dangerous for people who may not discover the problem until their car is too low on miles/charge and may not be able to get it reset. It is happening multiple times, even after dealer reset.

The steering started clunking when turning. You could hear a noise and feel a jerk when turning. The dealer said the steering gear had failed.

On 4/13/2022, my wife was driving her 2019 Chevy Bolt EV when a dash light came on. When she told me about the light, I checked GM's mobile app and the Diagnostic Information stated, "Immediate Attention, Lithium-Ion Battery: Issue found with On-Board Charging System. Please schedule a service appointment." This was odd since I knew that the vehicle had a full battery replacement due to the safety recalls for this particular vehicle. The replacement occurred at Reeder Chevrolet in Knoxville, TN in November of 2021. I also noticed a considerable range drop while driving the vehicle prior to this warning. I notified Reeder Chevrolet and they were unable to service the vehicle in a timely manner so I reached out to Beaty Chevrolet in Knoxville, TN. The next day we decided to drop off the vehicle, knowing it could take a while. As we were heading to the dealership, my wife stated she nearly wrecked her car because the steering became very difficult to turn, and could not turn in traffic properly. She said she had to force the steering wheel with all her strength just to get it to turn. When we got to the dealership, I reported the incident to them and they said they would look into it. I got a callback today, 4/15/2022, that the battery is fine and that Reeder Chevrolet did not perform the battery replacement correctly. They did not perform the proper vacuum replacement of the coolant and the computer sent a code. They stated they performed the proper coolant fix and that my range should go back to normal. As for the steering, the steering has been confirmed by their technicians at Beaty Chevrolet that there is in fact a major problem with the steering assembly. A new replacement is needed and should take 12 hours to complete with the cost of $2100.00. I believe this is not the only incident due to other Bolt owners stating they have the same issues (chevybolt.org). This needs to be recalled for the safety of the driver and others.

The contact owns a 2019 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V560000 (Electrical System) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2019 Chevrolet Bolt EV. The contact received a notification for NHTSA Campaign Number: 21V560000 (Electrical System) however, the part to do the recall repair was unavailable. The dealer had been notified about the recall and confirmed that parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

Last week, we had our 2019 Bolt serviced at a dealership - they had "replaced drive motor battery high voltage manual disconnect" and did some sort of check on the "high voltage battery." We had also showed them a message we got from On Star that an "issue had been detected with the electric drive unit" and get it serviced within seven days. We bought the Bolt in the Fall of 2019 and it has less than 5,000 miles on it. We are on the waitlist for the LIB recall. 6 days after getting the car back from service, my wife was driving the car when suddenly the car went completely dead. Fortunately, she was not on the highway where she could have been killed, but on a quiet suburban street. I came over to assist and we arranged to have it towed to the Chevy dealership. After the Bolt stopped running, my wife again received the message saying "issue had been detected with the electric drive unit." They are now working on the Bolt. They are telling us that the problems are (1) the 12 volt battery has low state charge power and needed to be replaced and (2) there is a "faulty accessory power module" which they have ordered a part for. They do not think it is LIB related. They are not sure what "electric drive unit" means and will need to check with Chevrolet.

The car's AC, which cools the battery stopped working. The vehicle says to be serviced immidiately but Chevrolet has not found a local dealer or mechanic in Puerto Rico (where my car is currently situated) that can service it. I am afraid the car will light on fire because the car already has a battery recall, which they have yet to resolve as well.

Chevrolet has yet not made the replacement battery available for my 2019 Bolt. I received a letter in mid November saying my car was on the "priority list". I attempted to make an appointment around Thanksgiving of 2021 and now, 8 weeks later, they say the replacement battery is still not available and the dealer has no idea when they'll get it. The Chevy "concierge" has not been helpful at all. They don't know either when a battery will be available and send me to talk to the the dealer. The dealer says that Chevy has not given them any estimate about when the battery will be available. For obvious reasons, I feel the car is unsafe.

Solenoid on charge receptacle that asserts locking latch gets stuck in extended state leaving the car in a bricked state - out of charge and unable to insert a charger. This occurred after receiving the new battery packs covered by recall and the dealer did the associated firmware upgrade after the battery recall fix. Also - when observing the Bolt forums the "stuck latch preventing charging" is occurring on quite a number of other Bolts - FW bug??

The contact owns a 2019 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V560000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and informed the contact that he was on a waiting list. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.