2004 CHEVROLET CAVALIER Complaints

SPEEDOMETER IS UNRELIABLE. SOMETIMES IT SHOWS FASTER, SOMETIMES IT SHOWS SLOWER. STICKS IN PLACE AT TIMES. NEXT, THE TEMP GAUGE MADE ME THINK MY CAR WAS RUNNING VERY HOT AND I BOUGHT A $25 TEMPERATURE SENSOR FIRST, THAT DIDN'T HELP, SO I WAS GOING TO REPLACE THERMOSTAT. THEN I LEARNED ABOUT THIS BEING A PROBLEM WITH THOUSANDS OF THESE CARS, SO I AM NOT DOING ANYTHING TO IT UNTIL THERE IS A RECALL. I'LL USE A GPS TO TELL MY SPEED. I HAVE HAD TWO SPEEDING TICKETS OVER THIS BECAUSE I HAD NO IDEA THE THING WAS NOT WORKING RIGHT UNTIL IT GOT REALLY BAD AND STARTED STICKING IN ONE PLACE FOR DAYS. EACH TICKET WILL GIVE ME TWO POINTS ON MY LICENSE BECAUSE OF THIS. MY INSURANCE WILL GO UP. ALSO, I DON'T GET PAID FOR THE TIME I TAKE OFF TO GO TO TRAFFIC COURT OVER THESE TICKETS. I AM 65 YEARS OLD AND NEVER HAD A TICKET UNTIL THESE TWO. THANKS, CHEVY. *TR

MY 2004 CHEVY CAVALIER SPEEDOMETER QUIT WORKING. THIS SEEMS TO BE A COMMON PROBLEM WITH THIS VEHICLE. A RECALL IS IN ORDER! *TR

INSTRUMENT CLUSTER FAILS TO WORK PROPERLY ON THIS MODEL ALTHOUGH I HAVE TAKEN IT TO THE DEALERSHIP 3 TIMES BEFORE THE WARRANTY RAN OUT. HAS NEVER BEEN REPAIRED ALTHOUGH THEY CLAIM THEY FIXED IT. THE FUEL GAUGE, SPEEDOMETER, TACHOMETER, AND TEMPERATURE GAUGE ARE ALL AFFECTED BY THIS MALFUNCTION. WHEN I AM DRIVING DOWN THE ROAD, IT IS VERY COMMON FOR IT TO READ THAT I'M GOING 30 MILES FASTER THAN I REALLY AM AND THE EXTREME OPPOSITE ALSO HAPPENS WHERE I AM SITTING AT A RED LIGHT BUT GOING 70 MPH. I HAVE RESEARCHED ONLINE AND HAVEN'T SEEN A RECALL BUT I REALLY FEEL THAT ONE IS NECESSARY IN THIS CASE. IT IS UNSAFE TO NEVER KNOW HOW MUCH GAS IS IN THE VEHICLE, THE SPEED IN WHICH YOU ARE TRAVELLING, OR ANY OF THE OTHER ESSENTIAL THINGS THAT SHOULD BE KNOWN WHILE YOU ARE OPERATING A CAR.

THE SPEEDOMETER STICKS AND DOES NOT REPORT ACCURATE VEHICLE SPEED. ABOVE A CERTAIN SPEED THE GAUGE WILL FREEZE AND BE UNUSABLE. THIS HAPPENED WITHOUT WARNING WHILE I WAS DRIVING ON THE HIGHWAY AND COULD EASILY HAVE CAUSED AN ACCIDENT. THIS IS A KNOWN SAFETY ISSUE ON OTHER GMC CARS FROM THE SAME TIME PERIOD (MINE IS A 2004). IN ADDITION TO THE SPEEDOMETER, THE TACHOMETER AND THE FUEL GAUGE ARE ALSO COMPLETELY INOPERABLE. THE WHOLE INSTRUMENT CLUSTER IS DEFECTIVE. IT IS INCREDIBLY DANGEROUS AND EXPENSIVE TO REPAIR, AND SHOULD BE COVERED UNDER THE SAME RECALL AS THE OTHER CHEVROLET PRODUCTS. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET CAVALIER. WHILE EXAMINING THE VEHICLE THE CONTACT NOTICED THAT THE INSTRUMENT PANEL GAUGES WERE NOT FUNCTIONING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE INSTRUMENT PANEL WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 61,000 AND THE FAILURE MILEAGE WAS 60,650. UPDATED03/15/12 *BF THE CONSUMER STATED THE PROBLEM STARTED WITH THE GAS GAUGE. WHICH STARTED OFF AS AN INTERMITTENT PROBLEM AND BECAME WORSE. THE GAS GAUGE NEEDLE THEN STARTED BLOCKING THE TEMPERATURE GAUGE, WHICH CAUSED THAT NEEDLE NOT TO WORK PROPERLY. THE GAS GAUGE AND TEMPERATURE NEEDLE WERE FACING THE STEERING WHEEL. THE CONSUMER WAS INFORMED THE ENTIRE INSTRUMENT CLUSTER WOULD HAVE TO BE REPLACED AT A COST OF $650 PLUS LABOR. UPDATED 05/30/12

IT WAS SOMETIME IN NOV. 2011 WHEN THE SPEEDOMETER STOPPED WORKING FOR NO REASON. EVERY ONCE IN A WHILE IT WILL REGISTER THE SPEED BUT IT IS NOT CORRECT. I HAVE SEEN A LOT OF COMPLAINTS ABOUT THIS SAME PROBLEM WITH THE SAME CAR MODEL. AND FROM WHAT I HAVE LEARNED ONLINE THIS CAN BE A VERY EXPENSIVE REPAIR. THERE REALLY SHOULD BE A RECALL ON THIS PART. ALL DRIVERS NEED TO KNOW WHAT THEIR SPEED IS IN ORDER TO BE SAFE AND RESPONSIBLE DRIVER. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET CAVALIER. WHILE PARKED THE CONTACT NOTICED THE FUEL GAUGE DISPLAYED THE INCORRECT READING. THE READING WOULD FLUCTUATE FROM EMPTY AND FULL. IN ADDITION, THE CONTACT NOTICED THE SPEEDOMETER DID NOT READ THE ACCURATE SPEED WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC. THE MECHANIC STATED THE INSTRUMENT CLUSTER WOULD HAVE TO BE REPLACED BUT THE PART WAS NOT AVAILABLE FOR REPAIR. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

AFTER CONSULTING LICENSED MECHANICS, AND ONE SUCH NATIONALLY CERTIFIED AIRPLANE-ENGINE TECH-MECHANIC, BEING RANKED IN THE TOP THREE (3) OF THE NATION'S AVIATION MECHANICS INDUSTRY FROM 1981-1983 PERIOD (AND STILL HAS QUALIFICATIONS AUTHORITY), [AND BEFORE MAKING A FOOL OF MYSELF], THE CONSENSUS/VERDICT [BY THESE PROFESSIONALS] WAS AGREED THAT IT BORDERS ON CRIMINALITY (AND I QUOTE), THAT AUTOMAKERS ARE USING PLASTIC COVERINGS AND SEALS, AS THE ENGINE'S OIL FILTER HOUSING CAPS. KNOWN (INDUSTRY-WIDE) TO EXERT PRESSURES IN 'POUNDS PER-SQUARE-INCH' ( LBS/PSI) AND EXTREME TEMPERATURES THAT THESE PLASTIC MATERIALS--SUCH AS THE OIL FILTER-HOUSING CAPS, CANNOT WITHSTAND. THEY ALSO STRIP. IT WAS EXPLAINED TO ME BY THE CERTIFIED AIRPLANE MECHANIC THAT, TO UNDERSTAND THE EFFECTS OF PRESSURIZATION THEORY BEHIND THAT TECHNOLOGY, AND THE KNOWLEDGE THAT FIFTY-50 TO SIXTY-60 POUNDS (LBS/PSI) OF PRESSURE PER-SQUARE-INCH IS BEING GIVEN TO THE PLASTIC CAPS FROM THE ENGINE'S INTERNAL COMBUSTION WILL CAUSE ANY PLASTIC CAP, HOUSED UNDER SUCH PRESSURES TO FAIL. HE SAID HE WAS SURPRISED IT DID NOT CAUSE ENGINE FAILURE TWO(2) YEARS AFTER BEING NEWLY PURCHASED. HE SAID THE SCIENCE THAT INDUSTRY INSIDERS DO NOT WANT US TO KNOW IS THAT THE PROPER SEMI-PRECIOUS METALS, AS ALUMINUM, COPPER AND THE LIKE ARE PERFECT CONDUCTORS OF ELECTRICITY AND HEAT, ALLOWING THE METAL TO EXPAND/CONTRACT ACCORDING TO TEMPERATURES AND/OR TORQUE PRESSURIZATION OF THE 50-60 LBS/PSI BEING RELEASE TO HOUSING. EVEN TAMPERED STEEL WOULD WORK AS IT WOULD CONFORM. BUT PLASTIC ONCE OVERHEATED WILL REMAIN IN WARPED STATE CAUSING OIL LEAKAGE IN THAT AREA. THIS DEPRESSURIZATION OF ENGINE PHYSICS AND CHEMISTRY, A COUPLE-TO-FEW YEARS LATER RESULTS IN ENGINE'S CRANK CASE HOUSING DEPRESSURIZING TO THE POINT OF CRACKING AFTER PISTONS THEMSELVES GIVEWAY RENDERING ENGINE BEING IRREPARABLE. MY CAR SHOULD HAVE FLIPPED @ 70MPH. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE WINDOWS COULD ONLY BE CLOSED PARTIALLY. THE REAR DRIVER AND PASSENGER WINDOWS COULD NOT BE OPENED OR CLOSED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO LOCATED THE FAILURE AT THE DOOR MOTOR AND REGULATOR. THE MOTORS AND THE REGULATORS WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 83,000 AND THE CURRENT MILEAGE WAS 90,000.

MY SPEEDOMETER STOPPED WORKING. APPARENTLY I'M NOT THE ONLY ONE THIS HAS HAPPENED TO. I'VE BEEN READING A FORUM ON HTTP://WWW.CARCOMPLAINTS.COM/CHEVROLET/CAVALIER/2004/ACCESSORIES-INTERIOR/SPEEDOMETER_STOPPED_WORKING.SHTML AND BETWEEN THE MILEAGE RANGE OF 30,000 AND 50,000 THIS HAS HAPPENED TO SIGNIFIGANT AMOUNT OF PEOPLE BY NO FAULT OF THEIR OWN. THIS IS EXTREMELY DANGEROUS FOR PEOPLE WHO HAVE NO WAY TO AFFORD GETTING IT FIXED AND CHEVROLET SHOULD BE LIABLE TO FIX THIS ISSUE. THEY CANNOT EXPECT TO CHARGE UPWARDS OF $500.00 TO REPAIR SOMETHING THAT WAS POORLY MANUFACTURED. *KB