2004 CHEVROLET CAVALIER Complaints

WHILE DRIVING AT 55 MPH CONSUMER FOUND IT HARD TO STEER THE VEHICLE. CONSUMER SLOWLY DROVE THE VEHICLE HOME CHECKED UNDER THE HOOD, AND FOUND THAT STEERING FLUID WAS COVERING THE ENGINE COMPARTMENT. ALSO, THE HOSE CONNECTING THE STEERING FLUID PUMP WAS NOT CONNECTED PROPERLY. THE CLAMP WAS ON THE HOSE, BUT NOT CLAMPED ONTO THE CONNECTOR. *AK DEALER REPLACED POWER STEERING PUMP. *LA

DRIVERS SEAT BELT MORE THAN TWELVE INCHES SHORTER THAN PASSENGERS SEAT BELT. *AK

UPON DELIVERY OF NEW 2004 CHEVROLET CAVALIER, IT WAS DISCOVERED THAT TWO OF THE FOUR BOLTS THAT HOLD THE TRUNK LID TO THE VEHICLE WERE BROKEN COMPLETELY OFF. ALSO, THE REAR WINDOW HAD TO BE REMOVED AND NEW WEATHER STRIPPING HAD TO BE APPLIED BY THE DEALER BODY SHOP. THE WEATHER STRIPPING THAT WAS APPLIED AT THE FACTORY IN LORDSTOWN WAS NOT INSTALLED PROPERLY. THE TRUNK AND REAR SEAT WAS SOAKED WITH RAIN WATER THE DAY AFTER DELIVERY TO ME. THE BRAND NEW VEHICLE WAS IN THE BODY SHOP FOR A TOTAL OF 6 DAYS. CHEVROLET WAS NOTIFIED IMMEDIATELY OF THESE PROBLEMS BY ME. *JB

I DISCOVERED AT 1500 MILES MY 2004 CAVALIER LS HAD A LEAK APPARENT IN THE ROOF LINER. TOOK IT TO THE DEALER AND TURNS OUT THE REAR BACK WINDOW SEAL WAS NOT PROPERLY INSTALLED AND WAS CRIMPED UPON INSTALLATION AT THE FACTORY. THE PROBLEM WAS REPAIRED UNDER WARRANTY BY GM AND WAS FIXED TO MY SATISFACTION. *AK

I PURCHASED MY 2004 CAVALIER LS WITH ONLY 4 MILES ON THE OD. I NOTICED THE VERY SAME DAY ON THE WAY HOME THAT THE STEERING WHEEL WAS VIBRATING AT SPEEDS BETWEEN 65 & 75, AND DIDDNT TAKE IT IN RIGHT AWAY CAUSE I JUST THOUGHT THIS WAS NORMAL AND THERE COULDNT POSSIBLY BE ANYTHING WRONG CAUSE THE CAR WAS BRAND NEW. WELL THIS CONTINUED AND GOT WORSE, SO AT 6,000 MILES WHEN IT WAS TIME FOR A ROTATION I HAD THEM CHECK IT AND THEY SAID THE WHEELS WERE OUT OF BALANCE. I DROVE IT AWAY BUT STILL HAD THE SAME PROBLEM. I FINNALY TOOK IT BACK A MONTH LATER AND TOLD THE DEALER THIS WAS NOT NORMAL, SO THEY DID A FORSE VARATION BALENCE WHICH CORRECTED THE PROBLEM. I JUST THINK GM NEEDS A BETTER INSPECTION PROCESS, CAUSE THE TIRES WERE NOT CORRECTLY BALENCED FROM THE FACTORY.*AK

CONSUMER STARTED VEHICLE TO WARM IT UP AND WENT BACK INTO THE OFFICE. VEHICLE WAS IN FLAMES WITHIN 10 MINUTES. THE FLAMES WERE UNDER THE HOOD. *AK

ON INTERMITTENT SETTING, WINDSHIELD WIPERS ONLY MOVE ACROSS WINDSHIELD IN SPURTS, STOPING EVERY SECOND. WORKS NORMALLY ON HIGH SETTINGS. ON PREVIOUS REPAIR, WIPER LINKAGES FAILED RESULTING IN ONE WIPER REMAINING PARKED AT ALL TIMES. *AK