1994 CHEVROLET CAVALIER Complaints

DRIVER SIDE SEATBELT RETRACTOR GETS STUCK INSIDE AND MAL FUNCTIONS, AND WILL NOT COME OUT. THE DEALERSHIP IS AWARE OF IT. *AK

HEAD GASKET LEAKS COOLANT AT THE EXHAUST MANIFOLD SIDE, THE GASKET HAS BEEN REPLACED 3 TIMES, GASKET IS LEAKING AGAIN. CJ

ENGINE PISTONS WERE 2K UNDERSIZED, CAUSING ENGINE TO KNOCK. DEALER HAS REPLACED PISTONS.*AK

ENGINE HEAD GASKETS HAVE BLOWN TWICE. CHEVROLET HAS EXTENDED WARRANTY ON 1995-1998 CAVALIERS AND 1994 IN CANDA ONLY. *AK THE CONSUMER HAD REQUESTED THE MANUFACTURER TO REIMBURSE HIM FOR THE COST OF REPAIR. *YH

3 TEETH OF FLYWHEEL BROKE OFF, CAUSING DAMAGE TO HOUSING OF STARTER.PLEASE PROVIDE FURTHER INFORMATION. *AK

DRIVER SEAT BELT IS NOT ROLLING BACK AND THEREFORE IT GET STOCK IN THE DOOR AND TEARS UP. *AK

WILL CONTACT DEALER SERVICE AND MANUFACTURER FOR ASSISTANCE. NO SAFETY DEFECT LISTED FOR ABOVE VEHICLE. *AK

WHILE CHANGING THE OIL I NOTICED A RUST LINE DOWN THE ENGINE BLOCK WHERE THE TRANSMISSION HOUSING AND ENGINE BLOCK MEET. THERE IS A DISTINCT LEAK AT THAT SECTION OF THE HEAD/BLOCK WHERE THEY MEET. *AK

FUEL GAUGE DOES NOT WORK PROPERLY. NEEDLE WOULD GO ALL THE WAY PAST FULL WHEN IT'S FILLED. BUT WHEN DRIVING, CANNOT TELL IF TANK IS BEING EMPTY DUE TO NEEDLE NOT MOVING DOWNWARD. WAS NO INDICATION OF WHETHER FUEL WAS IN TANK OR NOT. TOOK TO DEALERSHIP & WAS INFORMED BY MECHANIC THAT A NEW PART, FUEL SENDER MODULE, WAS NEEDED & WOULD REPLACE IT WHEN IT CAME IN.*AK

DUE TO T DEFECTIVE ABS SYSTEM WHEELS TO LOCKED UP, ANDVEHICLE SKID, WHICH MAY HAVE CAUSED A CRASH. DEALER COULD NOT DETERMINE CAUSE. COMMON PROBLEM. PLEASE PROVIDE FURTHER INFORMATION.*AK