2006 CHEVROLET COBALT Complaints

HAD TO CHANGE MY FUEL PUMP DUE TO A CRACK ON IT. MY KEY GETS STUCK IN THE IGNITION SWITCH IN ORDER TO TAKE IT OUT I HAVE TO PUSH A BUTTON UNDER THE STEERING WHEEL. I TO CHANGE MY STEERING SHAFT BECAUSE IT DOES A CLACKING NOISE.

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED WHILE THE VEHICLE WAS STATIONARY, HE STARTED TO SMELL A FUEL ODOR. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 94,000.

FUEL LINE LEAK BY LEFT REAR WHEEL WELL. HEAT SHIELD SEEMS TO CAPTURE MOISTURE AND HAS RUSTED LINE BY CLIP. RESULTS IN FUEL LEAK BY EXHAUST SYSTEM.

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT A SLOW SPEED IN A PARKING LOT, HE HEARD THE VEHICLE CHIME AS THE POWER STEERING WARNING MESSAGE APPEARED ON THE INSTRUMENT PANEL. THE CONTACT THEN STATED THAT THE POWER STEERING BECAME FIRM. THE CONTACT STATED THAT THE VEHICLE STALLED WITH THE ACCELERATOR PEDAL DEPRESSED. THE CONTACT RESTARTED THE VEHICLE AND THE CHECK ENGINE WARNING LIGHT APPEARED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THERE WERE SEVERAL RECALLS ON THE VEHICLE. A VIN SEARCH SHOWED NO OPEN RECALLS ON THE VEHICLE. THE CONTACT LINKED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 10V073000 (STEERING). NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.

WHILE DRIVING ON EXPRESSWAY, CAR WENT DEAD> HAD TO MAKE AN EMERGENCY STOP. POWER STEERING WENT OUT, BUT AFTER RESTARTING THE CAR IT WAS OK. IT KEEPS HAPPENING OFF AND ON- ON OCCASIONS. I KEPT SMELLING GAS, TOOK IT TO CAR REPAIR SHOP WAS TOLD I COULD NOT DRIVE THE VEHICLE, WAS TOLD THE GAS TANK HAD TO BE REPLACED OR WHATEVER THE PART INSIDE THE GAS TANK. NOTE: WHEN THE POWER STEERING PROBLEM ARRIVED I WAS LEAVING GOING TO WORK. I STARTED THE CAR BUT THE STEERING WAS HARD TO TURN SO I PULLED BACK INTO PARKING SPACE AND TURNED OFF THE ENGINE. I RESTARTED AFTER A FEW MINUTES-WAS ABLE TO STEER OK. UPON SMELLING GAS THIS WENT ON FOR SERVAL DAYS. I THOUGHT IT WAS FUMES FROM OTHER CARS. I WOULD SMELL GAS WHILE DRIVING IT. ONE DAY AS I PULLED UP TO WORK I GOT OUT OF THE CAR AND NOTICED SOMETHING WET NEXT TO MY FRONT TIRE. I COULD SMELL GAS FUMES. I TOOK IT TO REPAIR SHOP THE NEXT DAY. SHOP TOLD ME THE CAR COULD HAVE CAUGHT ON FIRE.

THE COMPANY WRAPPED A HEAT SHIELD FIBER AROUND A BARE METAL FUEL LINE CAUSING PREMATURE FAILURE OF THE LINE IN THAT SPECIFIC LOCATION DUE TO RUST FROM THE TRAPPED MOISTURE. THE FUEL LINE BURSTS CAUSING A STEADY FLOW OF GASOLINE TO POUR FROM BENEATH THE VEHICLE CAUSING AN EXTREMELY HAZARDOUS SITUATION. THE CAR CONTINUES TO FUNCTION, LEAVING A TRAIL OF GASOLINE EVERYWHERE YOU GO. THE HEAT WRAP DOES NOT APPEAR TO AFFECT THE BRAKE LINE DUE TO IT'S BLACK COATING. THE FUEL LINES SHOULD ALSO BE PROTECTED IN THIS AREA.

POWER STEERING WARNING CAME ON WHILE DRIVING ON THE HIGHWAY AN THE SPEEDOMETER STOP WORKING NOW THE CAR WON'T START I HAVE CHECKED FUSES AN RELAYS UNHOOKED BATTERY TO RESET COMPUTER NOTHING WORKS

VERY STRONG FUEL SMELL STARTED OCCURRING THAT WAS NOTICEABLE EVEN AFTER LONG PERIODS AFTER PARKING. UPON FURTHER INVESTIGATION A FUEL LEAK WAS DISCOVERED ON THE OUTLET OF THE FUEL PUMP WHICH IS INTEGRAL TO THE FUEL TANK. IT APPEARS THERE IS A CRACK OR SOME SORT OF DEFECT CAUSING THE EXTERIOR PIECE ON THAT FUEL PUMP TO FAIL. VEHICLE ONLY HAS 64,300 MILES ON IT.

MY VEHICLE, A 2006 CHEVY COBALT LT, LIKE MANY OTHER CHEVY COBALTS I'VE FOUND IN MY RESEARCH, HAS A FUEL LEAK IN THE REAR DRIVER SIDE. I HAVE NOT PINPOINTED THE EXACT LEAK LOCATION BUT I HAVE A PICTURE DISPLAYING THE FUEL LINE COVERED IN WHAT SEEMS LIKE AN ALUMINUM FOIL TO KEEP THE LINES FROM HEATING UP. CLEARLY THIS DOESN'T WORK. THIS IS A COMMON ISSUE AND I BELIEVE IT NEEDS TO BE ADDRESSED.

PLASTIC FUEL TANK CRACKED AND FUEL IS DRIPPING FROM VEHICLE IMPOSING A POTENTIAL FIRE AND HAZARD.