2024 CHEVROLET COLORADO Complaints

My dog and I were headed to Home Depot on [XXX] when without any warning there was a very loud boom. My first thought was that we had been shot at. Once I gathered myself I realized the sunnroof glass had exploded. I rarely open the sunroof but do on occasion have the shade open, luckily it wasn’t open or my dog and I would have been sprayed with the glass which could have caused serious eye injury and potentially a crash. I’ve had 2 Chevy dealers tell me that is not a warranty issue that it was likely caused by a rock being thrown up. I do not believe this was the case. The closest vehicle was some 500 feet in front of us. Because it was such a violent explosion I believe it was a pressure explosion. I am also very surprised that the glass is tempered and not laminated. I have insurance so I’m not concerned with getting it repaired. I just want you to know I think it a very serious issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2024 Chevrolet Colorado. The contact stated that while driving on several occasions at various speeds, and the brake pedal was depressed the pedal remained floored. The contact stated that the vehicle eventually slowed down on its own and came to a complete stop. The was towed to a dealer where it was diagnosed that the master cylinder needed to be replaced. The vehicle was repaired but the failure reoccurred a little over a month later. The vehicle was towed back to the same dealer where it was diagnosed that the battery was dead and the battery needed to be replaced. The vehicle was repaired but the failure reoccurred approximately 17 days later. The vehicle was taken to the same dealer where it was diagnosed that the drivers door wire harness needed to be replaced due to an electrical issue that killed the battery. The vehicle was repaired but the failure reoccurred approximately four months later. The vehicle was towed to the same dealer where the vehicle has yet to be diagnosed as of yet. The manufacturer notified of the failure. The failure mileage was approximately 8,400.

Check engine light came on and the dealership said it was because the coolant was low due to the radiator hose leaking. I was told by the actual mechanic that they’ve had to do a lot of radiator hoses and that it is a known defect with the Colorados and the traverses but that GM hasn’t done a recall on them yet. That is what brings me here. My truck is only 2 years old and this shouldn’t be happening right now. Thank you for taking the time to review this and I hope GM addresses the matter promptly.

The upper radiator hose on some huge percentage of these trucks fail (mine has failed at just over 35k miles). You can check the Colorado Chevy forum, youtube, etc., et al, and find plenty of instances where this has failed. As this is the cooling system, it can cause the engine to overheat and potentially ruin the engine. The flaw seems to be an engineering issue with the rubber seal they use (instead of a high quality o-ring) to seal the upper hose to the radiator. Additionally, since this can cause engine failure it should be addressed immediately. Instead, my local Chevy dealer, since its not a recall item, said they could schedule a time next week for me to LEAVE the truck and then they would get to it in 7-10 days. This is extremely unfair to the consumer who depends on these vehicles. This should absolutely be a recall item. You can find 1000's of examples online and if you can pull GM repair data, I'm sure you'll find 1000's more.

Truck has 36,669 miles check engine light came on and was idling loud, after being looked at my a Chevrolet dealership came back a faulty radiator hose, and coolant was leaking. Too new of truck for this kind of problem

The vehicle is registered to me; my mother was the driver at the time of the failure. At ~2,963 miles, the truck developed intermittent check engine and ABS warning lights. The dealer pulled DTC C058A (brake system control module) and P25A2. Per GM bulletin PIT6012A, the battery was replaced and a brake plunger motor sensor learn was performed. The same codes returned within weeks. The dealer then diagnosed internal failure of the brake master cylinder and reservoir, documented the vehicle as "unsafe to drive," and replaced both under warranty. The truck sat at the dealer over six weeks due to a nationwide parts backorder. Repairs were completed April 4, 2025. On May 2, 2025, at ~6,500 miles, the driver was traveling downhill on a city street in the rain at roughly 20 mph. The brake pedal suddenly became hard and resistant. Despite full-force pedal pressure, the vehicle could not be stopped. It entered an intersection, struck another vehicle, then struck a tree. Front and side airbags deployed; the vehicle was totaled. The driver sustained a concussion, broken finger, and severe back and knee injuries, was transported by ambulance, and required months of concussion treatment including vestibular therapy. The hard, resistant pedal is consistent with failure of the electronic brake boost assist (eBoost) system, leaving only unassisted hydraulic braking (roughly 4–5x normal pedal force). This matches other owner reports and the class action in Barron et al. v. GM LLC, which cites defective master cylinders with a missing internal cartridge seal on the same platform. The vehicle is no longer available for inspection. The driver was concussed with significant short-term memory loss at the scene; statements in the police report may not reflect the mechanical failure. Full police report available on request (exceeds 10 MB limit).

Coolant leaking from the upper radiator inlet hose connection. The Malfunction Indicator Lamp (MIL) illuminated in the Driver Information Center (DIC).

The backup camera view does not appear on my dash screen along with all other camera views. There were no warnings or indicators. It was working the last time the vehicle was driven and then failed on the next vehicle start up.

Check engine light with codes p0700 and p2796 has been happening for months with multiple failed repair attempts. Vehicle was returned to me by the dealer supposedly fixed. I drove it 15 minutes to the high school for an art fair my daughter was in. They (my family) rode with me home. Check engine light was on again. On the way home, the transmission was acting strange, not shifting properly. About half way home, it got stuck in a gear at 3500 or so rpms and would not shift. I tried the manual shifter, and it didn’t work. Stuck in gear. Concern was that we were approaching a hill when it did this, and I could not get the vehicle to shift to deliver the appropriate level of power I needed to ascend the hill. It thankfully did eventually shift, but it was scary for a few seconds, especially since I had my wife and all three of my kids in the vehicle. I dropped the vehicle off the next morning. It got stuck in gear at 3500 RPMS again on the way to the dealership. Two dealerships have made multiple failed attempts to fix the transmission issues. Several attempts to contact GM have gone without a response. No one in my family feels safe in the vehicle after what happened.

I have had my vehicle for less than 2 years and less than 25,000. I had it in for regular maintenance and was told I had no coolant. After a pressure test the dealership told me I had a large crack in the coolant line. It will 2 weeks to get the part and I can’t drive my truck. This needs to be made a recall and the part needs to be made available asap.This could of caused serious damage to my engine and could of cause me to have an accident.