2007 CHEVROLET CORVETTE Complaints

AIR BAG DISENGAGED LIGHT ON DASH COMES ON WHEN HITTING A BUMP. NOT SURE WHETHER AIRBAGS ARE REALLY NOT WORKING OR NOT. CODE SHOWS SEAT BELT TENSION AT FAULT.

2007 CORVETTE Z06 WITH LS7 ENGINE E. VALVE TRAIN BEGAN MAKING USUAL NOISES. FACTORY VALVE GUIDES FOUND TO BE OUT OF SPECIFICATIONS. HEADS REMOVED AND FACTORY VALVE GUIDES AND EXHAUST VALVES REMOVED AND REPLACED.

TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT APPLIED THE CLUTCH TO SHIFT FROM SECOND TO THIRD GEAR. WHEN THE CLUTCH WAS RELEASED, THE VEHICLE JERKED AS IF THE BRAKES WERE APPLIED AND THE ENGINE STALLED. THE CONTACT ENGAGED THE CLUTCH AND MANEUVERED TO THE EMERGENCY LANE. THE CONTACT WAS UNABLE TO RESTART THE ENGINE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DISCOVERED THAT A VALVE HAD FALLEN INTO CYLINDER ONE. AS A RESULT, THE PISTON AND CYLINDER WALL WERE FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 32,500.

WHILE DRIVING THE CORVETTE, THE ENGINE SHUT DOWN WITH NO NOTICE. THE DASH INDICATED THE VEHICLE HAD ENTERED ACCESSORY MODE. POWER STEERING, POWER BRAKES AND ENGINE POWER WERE COMPLETELY GONE. WITHIN A FEW SECONDS, THE DIC WENT FROM 'ACCESSORY MODE' TO 'SHIFT INTO PARK'. IN ORDER TO DO SO, I HAD TO COAST TO A SAFE PLACE. ONCE I GOT TO A SPOT WHERE I COULD MOVE OFF THE ROAD, I SHIFTED TO PARK AND RESTARTED THE CAR. IT THEN DROVE ON AS USUAL, BUT THERE WAS NO CHECK ENGINE LIGHT OR OTHER INDICATOR. THIS HAPPENED ONLY ONCE THIS DAY, HOWEVER OCCURRED THREE ADDITIONAL TIMES WITHIN 10 MILES ON THE 23RD OF JULY. I CONTACTED A GM SERVICE TECHNICIAN WHO WORKS AT A CHEVROLET DEALERSHIP AND HE CHECKED FOR ANY SERVICE BULLETINS OR RECALLS. THERE WERE NONE FOR THE CORVETTE. I SEARCHED THE INTERNET, AND CORVETTE FORUM (I AM A 10 YEAR FORUM MEMBER). I FOUND NUMEROUS INSTANCES OF THE IGNITION SWITCH IN 2005-2007 CORVETTES FAILING IN THIS MANNER. I LOCATED AN IGNITION SWITCH AND REPLACED IT. THIS FIXED THE PROBLEM IN 15 MINUTES AND FOR LESS THAN $50 AT DEALER RETAIL. I KNOW FROM OTHER NHSTC RECALLS ON VEHICLES THAT IGNITION SWITCH FAILURES ARE CONSIDERED A CRITICAL AND DANGEROUS FAILURE. THE FAILURES IN THE CORVETTES SHOULD BE INCLUDED IN THESE RECALLS. IF SUCH A FAILURE OCCURRED DURING CROSSING TRAFFIC OR WHILE DRIVING IN CLOSE PROXIMITY INTERSTATE TRAFFIC, THE RESULTS COULD EASILY BE (AND MAY ALREADY HAVE BEEN) DEADLY. PLEASE CONSIDER INITIATING A RECALL, OR INCLUDING THE AFFECTED YEARS OF CORVETTE IN AN EXISTING RECALL. MY CAR IS NOW FIXED DUE TO MY ABILITY TO SEARCH FORUMS AND OTHER WEB BASED INFORMATION, HOWEVER MOST CORVETTE OWNERS ARE NOT AS INVOLVED OR AS WEB SAVVY AND COULD BE INVOLVED IN A LONG DRAWN OUT PROBLEM/DIAGNOSIS PROCESS WHICH WOULD PUT THEIR LIVES AT RISK. THANK YOU.

GAS FUMES CONSTANTLY COMING OUT FROM AROUND THE CAR MOSTLY FROM THE DRIVERS SIDE REAR.....ENTERING INSIDE OF CAR

THE SHIFT INTERLOCK FAILS HAS FAIL 3 TIMES SINCE I OWNED THE CAR. THE SELONOIDE THAT TELLS THE SHIFTER THAT THE BRAKE IS PRESSED LOCKS UP. (CANT SHIFT OUT OF PARK) THE DRIVER CANT PUT THE CAR IN ANY GEAR. GM FIXED IT BY REPLACING THE WHOLE SHIFTER AND NOT UPGRADING THE FAILED PART. THEY JUST PUT ANOTHER BAD SHIFTER IN ITS PLACE. I HAD ONE TIME WHERE I COULD NOT PUT THE CAR IN PARK, THIS THE ENGINE WOULD NOT SHUT OFF. I HAD TO FORCE THE SHIFTER FORWARD ALMOST TO BREAKING POINT TO SHUT THE ENGINE.

TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. WHILE DRIVING AT 45 MPH, THE VEHICLE BEGAN TO MAKE AN ABNORMAL SNAPPING SOUND AND A WIND NOISE. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 23,888.

TRANSMISSION WILL NOT SHIFT OUT OF PARK. DEALER REPLACED BRAKE SWITCH. STILL HAVE SAME ISSUE.

WHILE DRIVING ON THE ROAD AT APROX. 45MPH, MY CAR EXHAUST VALVE DROPPED IN THE MOTOR CAUSING IMMEDIATE ENGINE FAILURE ALSO CREATING POWER STEERING AND POWER BRAKES TO STOP WORKING IMMEDIATELY. THIS SAME EXHAUST VALVE ISSUES OCCURRED WITH MANY OTHER GM CORVETTES WITH THE 7.0LITER Z06 MOTOR.

THE SHIFT BUTTON WILL NOT DEPRESS AND WILL NOT SHIFT OUT OF PARK. INTERMITTEN ISSUE. IT CAN TAKE UPTO 50 ATTEMPTS BEFORE IT WILL WORK. DEALER CLAIMS IT ISNT AND ISSUE IF THEY CANNOT REPEAT THE PROBLEM.