2007 CHEVROLET CORVETTE Complaints

YELLOW CONNECTOR UNDER DRIVERS SEAT LOST CONTINUITY. AIRBAGS WERE DISABLED. *TR

2007 CHEVROLET CORVETTE BEGAN SMELLING OF FUEL UPON FILL-UP ON 8/15/2014. CHEVROLET DEALER IN CARY, NC CLAIMED TO HAVE DIAGNOSED THE ISSUE AND CHARGED FOR DIAGNOSTIC FEE, SAID END RESULT WAS FAULTY FUEL CAP SO IT WAS REPLACED. TOTAL FOR THIS WAS $42.08. UPON NEXT FILL-UP, THE SMELL PERSISTED WITHOUT ANY CHANGE FROM BEFORE DIAGNOSIS AT CHEVROLET DEALER. APPROXIMATELY 7 WEEKS LATER, FUEL SMELL HAD WORSENED SLIGHTLY AND ALSO THE ENGINE WAS MAKING A "CHATTERING" SOUND. SINCE CHEVROLET DEALER COULD NOT DETERMINE THE FUEL SMELL ISSUE CORRECTLY, I CHOSE A HIGHLY REPUTABLE INDEPENDENT SHOP AND THEY IMMEDIATELY FOUND THE PROBLEMS. THE "CHATTERING" SOUND WAS A FAULTY HARMONIC BALANCER, A KNOWN ISSUE WITH THE CHEVROLET CORVETTE ENGINES AND COST ~$1,100 TO REPAIR USING CHEVROLET PARTS. THE FUEL SMELL WAS DUE TO A CRACKED DRIVER SIDE FUEL TANK (CORVETTES USE TWO FUEL TANKS) WHICH WAS EASILY FOUND BY THIS INDEPENDENT SHOP ONCE THE CAR WAS LIFTED. THE FACTORY-INSTALLED DRIVER SIDE FUEL TANK HAD SHRUNK AND CRACKED, TRAPPING THE FUEL PUMP INSIDE, THUS FORCING THE TANK AND PUMP TO BE REPLACED, ALONG WITH ALL RELATED SEALS AND PARTS. TOTAL TO REPAIR THESE FUEL RELATED ISSUES WAS ~2,700, FOR A GRAND TOTAL OF $3,803.27. UPON PERFORMING FURTHER RESEARCH, MANY CORVETTE OWNERS HAVE HAD THE EXACT SAME PROBLEM--DRIVER SIDE FUEL TANK CRACKS OVER TIME AND EVERY ONLINE REFERENCE FOUND INDICATES THAT GM COVERS THE ISSUE. I CONTACTED CHEVROLET AND WAS TOLD THAT I ONLY HAD A 2-YEAR/24-MONTH WARRANTY ON THESE ISSUES. I FIND THAT TO BE RIDICULOUS, ESPECIALLY SINCE THE SAME ISSUE IS OCCURRING ON CARS OF THIS TYPE ACROSS THE COUNTRY. IT SEEMS AS IF CHEVROLET AND CHEVROLET DEALERS PICK AND CHOOSE WHO THEY COVER THESE ITEMS FOR, WHICH IS EVEN MORE RIDICULOUS BECAUSE I DON'T THINK IT SHOULD BE NECESSARY THAT I HAVE TO KEEP FIGHTING JUST TO BE TAKEN CARE OF THE WAY I SHOULD HAVE BEEN IN THE FIRST PLACE. *TR

WHEN I START THE CAR ON THE DASH A WARNING APPEARS "SERVICE ACTIVE HANDLING SYSTEM" I READ IN THE OWNERS BOOK I LOOSE HANDLING CONTROL AND OTHER PROBLEMS THE DEALER IS NO HELP? *TR

MY CAR IS SUBJECT TO A RECALL FOR THE LOW BEAM HEADLAMPS, AND CHEVY (THE MANUFACTURER) WILL NOT FIX IT. THE DEALER SAYS THEY CAN FIX IT BY REPLACING THE FUSE BOX, BUT CHEVY WILL NOT AUTHORIZE IT. I HAVE BEEN WITHOUT MY CAR FOR OVER A MONTH. THE DEALER GAVE ME LOANER CAR, AND I DO APPRECIATE THAT. HOWEVER, I WOULD LIKE TO GET MY CAR BACK. I AM GETTING ABSOLUTELY NOWHERE WITH CHEVY, THE MANUFACTURER. I HAVE NO COMPLAINTS WITH RESPECT TO THE DEALER. *TR

I HAVE A 2007 CORVETTE AND THE "SERVICE ACTIVE HANDLING SYSTEM" LIGHT COMES ON. I WENT TO THE CHEVROLET DEALER AND HE WAS OF LITTLE HELP. THE CURRENT INVESTIGATION NUMBER IS EA09-002. IS THERE NOW OR WILL THERE BE IN THE FUTURE A RECALL NOTICE ON THIS PROBLEM SINCE IT IS A COMMON PROBLEM AND EVEN A SERVICE BULLETIN ON THE MATTER. *TR

WHEN MAKING A SLOW LEFT TURN THE FRONT BRAKES ON THE CAR LOCKED UP. "SERVICE STABILITY SYSTEM" MESSAGE CAN ON. CAR WOULDN'T GO OVER 5-6 MPH UNTIL SYSTEM WAS TURNED OFF. *TR

MY LOW BEAM HEADLIGHTS (LEFT/RIGHT) HAVE INTERMITTENT OUTAGES AFTER THE CAR WARMS UP. THE LOW BEAMS FAIL WITHOUT WARNING LEAVING IT DIFFICULT TO SEE THE VEHICLE AND OPERATE THE VEHICLE DURING EVENING, DUSK AND NIGHT DRIVING. *TR

LOW BEAMS SUDDENLY GO OUT WHILE DRIVING AND WON'T COME BACK ON.ALL FUSES, RELAYS, AND SWITCHES HAVE BEEN TESTED AND FOUND TO BE GOOD. *TR

THE AIR BAG WARNING LIGHT COMES ON AND GOES OFF INTERMITTENTLY AS YOU DRIVE. SPEED REALLY HAS NO EFFECT ON WHEN. HAS COME ON/OFF AS LOW AS 20MPH OR AS HIGH AS 80MPH. *TR

FUEL GAUGE DOES NOT WORK. ORIGINAL PROBLEM WAS IN 2009 WHEN THE VEHICLE LOST POWER ON THE FREEWAY. FUEL GAUGE INDICATED FUEL IN THE TANK, BUT IT WAS EMPTY. HAD VEHICLE TOWED AND REFUELED. FROM THAT TIME TO THE PRESENT, FUEL GAUGE HAS NEVER BEEN ACCURATE. SINCE 2013, THE FUEL GAUGE NO LONGER WORKS AT ALL. *TR