2019 CHEVROLET CORVETTE Complaints

OEM wheels fail. Thousands of online reports of 2015-2019 Corvette C7 Grand Sport and Z06 models wheels cracking without incident. My wheel is available for inspection. Safety was risked by having a wheel crack, loose air pressure and fail under normal operating load, potentially causing a crash. This issue has been reported to GM, has countless incidents also reported and can be easily confirmed at any dealer. My vehicle is currently at the dealer and has been inspected by their professionals. No symptoms prior to failure. No other damage has been noted or reported by the dealership to this wheel or tire.

Vehicle has 6900 miles on it, started to vibrate badly while driving on highway. Car has not been in any accidents and carefully driven. Dealer says the two rear wheels are bent.This could lead to cracking of wheels and/or loss of control of the vehicle. Vehicle is still under 36 month/36,000 mile bumper to bumper warranty. GM will not cover cost to replace and assumes no responsibility.

Bad smell of gas while parked in garage. Looked underneath and was leaking fuel. Looked online early c7 corvette 15-18 has a special recall for the fuel receiver and tank because it was leaking. Gm actually extended one of the warranties because of it. Brought my car to the dealer and said it's not covered under the extended warranty that gm gave. I was 18 days out of my bumper to bumper 3yr 36k miles and gm agreed to pay 90% and me 10%.

The rim cracked from the outside edge and progressed until air begin to leak. The dealer will not replace the rim unless you bought a tire and rim policy. But the manufacture of the tire does warrantee the tire and the dealer knows that to be the case. So the dealer knows the rims are the problem. I have researched and many others have the very same problem with their Corvette rims cracking until air is lost. These rims are definitely improperly designed and they should be recalled.

In February 2021, my Chevy dealer service department found that both of my rear wheels were bent and had to be repaired. My Corvette had 13,319 miles on it and I had never run off road or hit a major pot hole to cause this level of damage. The service technician said that this was 'common' on 2017 to 2019 Corvette Grand Sport and Z06 OEM wheels. Additionally, the wheels would probably 'crack' in the future and need to be replaced. I find this totally unacceptable that GM (Chevy) would design and manufacture defective wheels on a sports car, or any of their vehicles.

Upon tire change, 3 cracks noted in right passenger wheel. Problem diagnosed at Discount Tire (1475 Austin Hwy, San Antonio, TX 78209) on 6/5/2021. No known obvious road hazards or incidents that could have explained wheel fractures. Due to severity of wheel cracks, it was not even safe to drive home from Discount Tire (per the technicians there). There was concern for eminent wheel failure that would risk loss of control of car and injury to self/others. Car was left there until new wheel can be ordered and shipped. Upon review of internet, this is a recurring problem owners of this model of Corvette have been reporting. There is concern for design issues, wheel selection, and tire selection leading to repeated wheel failures. More wheel failures are expected in the future raising concerns for potential safety risks.

I PURCHASED NEW TIRES FOR MY 2019 CORVETTE GRAND SPORT AND WHEN THE TIRE SHOP REMOVED MY OLD TIRES I WAS INFORMED THAT (3) OF THE WHEELS WERE CRACKED AND (1) REAR WHEEL WAS CRACKED IN TWO PLACES. I HAD NO CHOICE BUT TO PURCHASE A SET OF (4) NEW WHEELS WITH ONLY 32,430 MILES ON THE CAR.

CAR WAS TAKEN TO A LOCAL DEALER TO HAVE 4 NEW TIRES INSTALLED. UPON INSTALLATION THE DEALER DISCOVERED BOTH REAR RIMS WERE CRACKED (1 COULD NOT HOLD AIR) AND ONE FRONT RIM WAS BENT. THE DEALER WILL NOT COVER THE WHEELS AND MY WHEEL INSURANCE WILL NOT COVER ANYTHING BUT OEM PARTS. I SECURED FORGED WHEELS AS I AM CONCERNED ABOUT MY SAFETY BY REPLACING THE SAME RIMS THAT CAME WITH THE CAR. THE CAR WAS STATIONARY WHEN THE PROBLEM WAS DISCOVERED. I AM AFRAID TO DRIVE THE CAR WITH THE OEM WHEELS. GM IS CLAIMING DRIVING BEHAVIOR AND/OR POTHOLES. I HAVE BEEN DRIVING CORVETTES ON AND OFF SINCE 1986 AND NEVER HAD ANY CRACKED RIMS. IN ALL THAT TIME MY DRIVING HABITS HAVE NOT SUDDENLY CHANGED. SECONDLY, IT IS HIGHLY UNLIKELY THAT I WOULD HAVE THREE DEFECTIVE RIMS ALL AT THE SAME TIME SIMPLY DUE TO POT HOLES. AFTER CONDUCTING RESEARCH MY STRONGEST BELIEF IS THAT SINCE THE RIM IS CAST AND NOT FORGED IT LACKS THE STRENGTH NEED FOR A PERFORMANCE VEHICLE AND THAT THE CRACKS ARE FATIGUE CRACKS WHICH OCCUR OVER TIME. FURTHER, THERE IS NO SENSOR OR WARNING SYSTEM TO LET YOU KNOW THE CRACKS ARE PRESENT. IN ADDITION, THE PROBLEM IS MAGNIFIED IN THAT THE CRACKS ARE ON THE INSIDE OF THE RIM AND NOT VISIBLE WHEN LOOKING AT THE WHEEL. IT IS MY BELIEF THAT THERE WILL BE FATALITIES ATTRIBUTABLE TO THIS DEFECT. I AM UPLOADING EVERYTHING I SENT TO MY INSURER WHO INFORMED ME THAT THEY CANNOT COVER AFTER MARKET WHEELS, EVEN THOUGH THEY WERE LESS EXPENSIVE. PS: I CANNOT TELL FROM YOUR FILE UPLOAD IF BOTH FILES WERE LOADED.

TL* THE CONTACT OWNS A 2019 CHEVROLET CORVETTE. THE CONTACT STATED WHILE DRIVING 45 MPH, THERE WAS AN INTENSE VIBRATION THROUGHOUT THE VEHICLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER COASTAL CHEVROLET CADILLAC NISSAN (8519 OCEAN HWY SUITE 1, PAWLEYS ISLAND, SC 29585, (843) 894-008) WHERE IT WAS DIAGNOSED WITH NEEDING THE FOUR WHEELS NEEDING TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE FAILURE MILEAGE WAS APPROXIMATELY 2,200.*DT*JB

WHEN TAKING THE CAR OUT FOR A TEST RIDE I NOTICED THE TIRE PRESSURE LIGHT WAS ON. DEALER SAID IT WAS BECAUSE OF THE WEATHER. I PURCHASED THE CAR AND A FEW DAYS HAD PASSED AND THE LIGHT WAS STILL ACTIVE. I TOOK IT BACK TO THE DEALER NUMEROUS TIMES TO RECTIFY THE SITUATION. AFTER NUMEROUS ATTEMPTS THE SERVICE DEPARTMENT INSPECTED FURTHER AND REALIZED MY WHEEL WAS BENT AND CRACKED. AFTER SOME RESEARCH I HAD FOUND NUMEROUS COMPLAINTS ABOUT THE C-7 CORVETTES, SPECIFICALLY THE GRAND SPORT AND Z06 MODELS WHERE THIS HAPPENS ALL THE TIME DUE TO THE WHEELS NOT BEING FORGED.