2025 CHEVROLET EQUINOX Complaints

Returning home on I-40 on Sunday, the engine just quit working. Fortunately it WAS Sunday and the traffic was light. Had there been more traffic, someone probably would have hit me from the rear. We managed to get it almost all of the way off the road before it stopped. According to the dealership that worked on it, it was the fuel supply service module, $46.09 part. The service technician said they had been having a lot of problems like this and knew what to do. All of the code were lost because to tow truck driving had to take the leads off of the battery. That was the only way he could get the car out of park in order to tow the vehicle.

The contact owns a 2025 Chevrolet Equinox. The contact stated that while stopped at a traffic sign, the accelerator pedal was depressed; however, the vehicle stalled. The contact stated that there was no warning light illuminated. The contact stated that the transmission automatically shifted to park(P). The vehicle was towed to a service station and the vehicle was refilled. The contact was able to start the vehicle, and the message "Auto Shut Down" was displayed and a 5-minute countdown was started, and the vehicle turned off. The contact was able to restart the vehicle and drove to the residence. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 13,000.

The contact owns a 2025 Chevrolet Equinox. The contact stated that the vehicle was experiencing rough idling and sputtering at start-up. The check engine warning light was illuminated. The vehicle was taken to Auto Zone, where it was diagnosed with rough idling and fuel injector failure. The dealer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 8,000.

on 10/9/2025 I pulled out of my driveway and less than 300 feet from my house I struck a deer. Weather was approx 50 degree and clear. There was no dew on my windows as I park my car in the garage. There was approximately $6200 worth of damage done to my vehicle and what concerned me the most was, the car never engaged the emergency stop. I mentioned this to the insurance company and they really had nothing to say. I have had bicyclists get too close to me on the road and my vehicle engaged the emergency stop. After repairs were done on the vehicle, they had a third party come in to do a calibration of all the sensors. He could not perform the calibration due to #PIT6274: Error Message Referring to Vision Camera system with DTC B1C48 - (Nov 4, 2024). I just dropped my vehicle off at the dealer and mentioned this to them and they are claiming there is nothing they can do about it. I started looking around online and have seen several other people complain about this and I knew it affected my Adaptive Cruise Control as I have gotten this error a couple times before and I just thought my window was dirty. What I did not know is this also affected my emergency stop as it does not tell me that in the warning. If this is a known issue, this is a serious safety concern and to have the dealer tell me there is nothing they can do is not acceptable. If the camera was functioning properly that morning, there is a good chance that I would not have gotten into an accident.

Visibility under certain conditions is very poor. Reflection on the windshield from the dash creates unsafe driving conditions. It is especially bad when driving into a dark area like a parking garage or car wash. Almost impossible to see other vehicles or people. Polarized, sunglasses, eliminates or reduces the reflection but they are not always within reach. This is not an isolated incident. It is a constant problem with the vehicle design.

My vehicle has been at the dealership for over a month for an issue with the HVAC system. The technician and GM engineering support believe the problem is related to a faulty acuator, which requires the entire dash to be removed for repair. (See pictures) This is extremely concerning for a new vehicle with very low mileage. An HVAC acuator failure in a brand new car should not occur, and the repair is invasive- involving disassembly of the major interior components. I am worried this will lead to creaks, rattles, or compromised fit and finish afterward, as well as potential damage to electronics, airbags, and trim panels. In addition, this problem appears to be widespread among other 2025 Equinox owners, based on multiple reports in owner forums describing identical HVAC noise or clicking problems linked to acuators. GM has not yet issued a recall or service bulletin addressing it. Given the scope of disassembly required and the frequency of similar reports, this should be reviewed as potential design or component defect affecting vehicle reliability and safety systems (defrosting performance and interior air management).

When using the factory-installed wireless charging pad, my phone becomes extremely hot within minutes of charging. The heat builds quickly, to the point that the phone must be removed immediately to prevent potential damages or safety risks. This has happened consistently, and I have not removed the phone case because I should not have to- the charging pad is designed and advertised to work safely under normal use conditions, which includes phones in standard protective cases. Regardless, the level of heat generated is excessive and concerning. This issue raises serious safety and design concerns, including the potential for battery damage, device malfunction, or even fire risk.

When there is dew, condensation, or rain on the windshield, the Front End Collision Warning system becomes inactive and displays the message: "Front End Collision System Inactive-Clean Windshield." This happens frequently, even with light moisture, and the warning system remains disabled until the windshield dries completely. Given that wet or low-visibility conditions are precisely when collision avoidance features are most critical, this failure creates a serious safety risk. I have verified that the windshield is clean and that three are no obstructions on the camera or sensors. Despite this, the system consistently deactivates whenever moisture is present. This issue appears to be a design or sensor calibration problem, not a maintenance issue.

When driving in sunny conditions, there is an intense glare reflecting from the interior trim- specifically the "chrome" trim on the middle console. The reflection is so bright that it becomes blinding at times, making it difficult to see the road clearly and creating a serious safety hazard. This issue occurs consistently whenever sunlight enters the cabin and reflects off the trim's surface. It is extremely distracting and has the potential to cause temporary vision impairment when driving.

On 10/26/25 at approximately 3:40pm while on a freeway (traveling approximately 65mph) with no traffic or cars in close proximity for the automatic brakes to be engaged, the 2025 ev equinox slammed its brakes on its own without driver braking. This caused whiplash to be experienced by two of the three passengers and it felt like we were rear ended but no cars were around. This is very dangerous. Had there been car behind me this would have caused serious accident.