2019 CHEVROLET EQUINOX Complaints

I was stopped at a traffic light and the car just froze. All the dash lights started flashing, the brakes would not work. The car started moving slowly backing up traffic behind me. I barely made it to a parking lot off the road.

Vehicle experienced derating. Check engine light on. Called mobile repair service. 20 year mechanic. Replaced Pedal Sensor. Fail. Second visit replaced Throttle Body. Fail. He advised better to take it to a reputable shop. Did. Shop worked on it for 2 months and ended up replacing ECM. I finally had the unit towed to an Electrical Specialist in Longmont Colorado. They replaced Wiring loom between pedal sensor and car worked again. Drove car to Kansas and after about 300 miles, loud boom and messages on display. ECM engaged electric emergency brake hard at 79 MPH. WAS on cruise. At 20 mph car stopped messaging, and resumed normal operation. Pulled over, checked car. 50 miles from nearest city. cautiously drove about 20mph, then 30, then more until up to speed limit again. Worked fine 140 miles (needed a population center to get car fixed)) and it happened again. Limped car a few miles to repair in Salina, Kansas. ECM erased all miles, messages, etc. They could find nothing. my research showed the 2025 Equinox EV recall (We had replaced ECM and reprogrammed). I went to get car and risked driving, but without cruise. Warnings would come up, but car ran. No more emergency stops, but plenty of warnings. $3K in repairs and still problem. I believe current problem is electrical that Equinox is known for. The ECM/Reprogramming problem that activated the Brake is the issue here and previously reported by many. Extremely dangerous! Car has 50K miles. Was flawless driver until now. Note: Unit was Rebuilt Salvage. I bought at 1460 miles. Hit right rear, Replaced right rear sheet metal, Rear driveline on right side (Genuine GM parts), Replaced Hatch door. Inspected by state of Michigan. Reputable Rebuilder. Zero bad reviews. Hundreds of excellent reviews. P.S. Cannot take to Chevrolet - they universally refuse to work on car - not to even change oil.

The contact owns a 2019 Chevrolet Equinox. The contact stated that on several occasions while driving at various speeds, the brake pedal was depressed; however, the engine revved continuously as if the vehicle was going to drive forward. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

Vehicle Information: 2019 Chevrolet Equinox VIN: [XXX] Mileage: [Insert your current mileage] Engine: 1.5L Turbo ? Complaint Summary: Sudden and complete loss of brake assist while driving. Brake pedal became extremely hard to press, making it difficult to stop the vehicle safely. A warning message appeared on the dashboard stating “Brake Assist”. This happened without warning and made braking unpredictable and dangerous. If I had been driving downhill or in the mountains, I could have easily lost control or crashed. I was lucky to be on a relatively flat road when it happened. I inspected the vacuum hose and brake fluid level — both were normal. After researching, I discovered this is a known issue in 2019 Equinox models with the 1.5L turbo engine, related to vacuum pump failure or loss of vacuum supply to the brake booster. There are service bulletins and limited coverage programs (N192268490 and N182202780), but my VIN does not show an open recall. I believe this is a serious safety defect that could affect many vehicles not yet covered by the recall or service campaigns. GM needs to expand the recall and properly warn drivers before someone gets killed. Please investigate this problem and hold GM accountable for fixing this safety-critical issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Chevrolet Equinox. The contact stated while driving approximately 20-30 MPH, the vehicle jerked and stalled, and the vehicle was nearly rear-ended. There was no warning light illuminated. The contact immediately made a turn into the nearby independent mechanic shop parking lot. The contact stated that the vehicle was able to restart; however, the failure recurred while the vehicle was being test-driven by the independent mechanic. The mechanic diagnosed the vehicle and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

On July 1, 2025 I was involved in an accident and none of my airbags deployed. Car was inspected by police, insurance company and General Motors who haven’t sent me the report yet. No warnings or symptoms appeared.

My vacuum pump failed on this vehicle. Causing my brakes to lock and a crash to almost happen

I was following my usual routine with my young child. I unlocked the vehicle, secured him in his car seat, then placed my bag (containing the key fob) inside the vehicle. I then closed the door and walked to the driver’s side to enter the car—as I do daily. However, when I reached for the door, every door was locked—including the trunk—and the vehicle would not respond to any button pressing, handle pulling, or proximity unlocking. My child was locked inside the car on a 92-degree day with no way for me to gain access. I immediately called emergency services. Both police and fire arrived quickly, but due to the design of the locking system and the placement of the lock buttons, they were unable to use their unlocking tools. Ultimately, they had no choice but to shatter a window to rescue my child, who had been trapped for 25 minutes in extreme heat. This malfunction could have led to serious injury or worse. I’m extremely shaken and concerned that this happened at all—especially considering I had the key fob in the vehicle and never manually locked the doors.

My car had been sitting for a week as we were off on vacation and when I came back the car would not start. Oil had been changed 1 week before that by Miller and Son. After towing it to Miller and Son Chevrolet (724-378-0542)we were told it was a timing chain issue and once they opened things up I was told the engine is ruined. The car only had 71,000 miles on it(I purchased it last year) We spoke to multiple mechanics who stated this was a common problem for this car and if the engine had failed while driving it could have caused a fire/accident. I have a [XXX] son and he very much could have been trapped in the car. If this is happening frequently as the mechanics have told me why has this not been recalled. I religiously had my oil changed as required. I tried calling GM (case #[XXX]) without much success. The dealer wants $9000 to put in a new engine which I need to get a loan to do but also my fear is will this happen again. I would appreciate you looking into this issue. Thank You. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On Sunday, [XXX] (a very hot day in Michigan. My vehicle registered 100 degrees) I was driving on [XXX] about 70-73 mph when I got an alert that said (to the best of my recollection) TOO HOT - IDLE IMMEDIATELY! and there was a continuous high pitch beeping which I only heard after turning off the radio. I continued at highway speed for a good 2-3 miles to the next exit afraid at any minute my car would start smoking. I exited and had to stop at a red light before turning left into a Kroger plaza with a fuel station. When the light turned green I accelerated and a grinding sound came from my car. I pulled into the plaza and turned the car off but had to turn it back on in about a minute as it was too hot to sit in car without air conditioning. It started and idled just fine. I googled roadside service and got a nice fellow (on a SUNDAY!) and he arrived in about 40 minutes. He towed me 40 miles away to a recommended auto shop that on Monday told me it was my transmission cooler that was defective and that I needed a transmission shop for a new transmission. It was then towed another 20 minutes away where it stayed for 9 days. Cost: $6564.48 plus $150 for paying with a credit card so totaled $6714.48. My drive train warranty was only good to 60,000 miles/5 years and I have 76,000 miles on my car at the time. Was told the transmission cooler was defective so I asked to have the cooler part and I have it in my garage. I spent over $1000 at the dealership in the months of Feb/March/April 2025 as my car hit the 70,000 mile mark so I had them do all work required by the car manual. The transmission cooler is apparently not a part they check. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)