2016 CHEVROLET EQUINOX Complaints

Oil burns at an alarming rate, no low oil warning. Engine blew up & was rebuilt. A month after engine rebuild, vehicle started to throw the same codes that led to engine failure. I can't keep oil in my vehicle, it has stalled numerous times on busy highway & once at an intersection with my kids in the vehicle. O2 sensors keep frying, catalytic converters keep clogging. Faulty rear main seal valve. Oil is leaking into combustion chamber which has caused manifold issues, spark plugs keep frying. Engine constantly misfires. Frequent engine knocking. My vehicle also seems to have no low oil warning light either. I remember getting an oil change, roughly a month in a half later i checked it again and my dip stick was bone dry. Chevy is aware of defects, but they refuse to do anything for the thousands of customers who have complained about the same exact things I am. There are numerous lawsuits for this exact issue, unfortunately not in my state. The value of my vehicle has dropped substantially to the point I am now upside down with my loan. I've looked into trading it in and my highest offer was $1,500 because of the issues that have been reported. There are so many people dealing with this same exact problem and we are all being ignored. I can't even go trade my vehicle in for something that will actually run without me having to dump hundreds of dollars into it every few months. Not only that, but these defects are extremely dangerous! My vehicle completely shut off while i was driving roughly 60-65mph in crazy/speeding traffic in the middle of rush hour & I had my two little girls with me. When help finally arrived, it was discovered that yet again, there was no oil in my vehicle even though I added roughly 2.5 quarts within a month in a half of this incident occurring. My vehicle over heated... this is absolutely uncalled for and isnt something that happens because of owners negligence. Someone please help!!!

My equinox has only 70,000 miles and they found ground bearings in the transfer case and it cost me $2000 to fix they said this was an unusual repair to report it

The vehicle stopped middle of traffic, engine light came on. Took ti mechanic states need a new engine 100,000 2016. Diagnosed no oil, engine burning oil, it stutters.

The contact owns a 2016 Chevrolet Equinox. The contact stated that while her son was driving approximately 20 MPH, the vehicle stalled. The vehicle was later towed to the local dealer who diagnosed that the engine had failed due to extremely low engine oil. The contact was informed that the engine oil was four quarts low. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the regularly scheduled oil changes were always performed on the vehicle and that the engine had experienced excessive oil consumption. The manufacturer was notified of the failure. The approximate failure mileage was 94,000. The contact stated this could have been a VERY serious problem had the engine failed while her son was on the freeway traveling 70 MPH instead of only driving 20MPH. The contact had the engine rebuilt for over $8,000 and GM offered me a "Goodwill offering" of a little over $400, but contact declined the offer.

The contact owns a 2016 Chevrolet Equinox. The contact stated that while inspecting under the hood, it was discovered that oil had leaked into the engine compartment. The contact discovered that the vehicle had experienced excessive oil consumption and extra quarts of oil were required and added to the engine every two days. The vehicle was taken to the local dealer who replaced a faulty sensor, but the failure persisted. The manufacturer was also notified of the failure, but no assistance was offered. The failure mileage was 118,000.

Problem first appeared with the limp mode being initiated by the vehicles computer system. This occurred at 96,000 miles in July of 2021. After running numerous diagnostics with a OBD scanner, and removing VVT solenoids, came to the conclusion it was the problem. After replacing with new OEM Solenoids and restarting the computer from the battery. The problem seemed to be resolved. In March of 2021the vehicle started losing oil by the quart each week. January 2022 the computer link initiated the limp mode again at 100,000 miles. After trying to diagnose using OBD, the conclusion was not apparent. Followed up by taking the air box off and found oil in the vacuum line for the air box. Continue the investigation by removing the PCV valve and the VVT solenoids. Found large amounts of oil(more than Chevy engineers allowed). Then proceeded to reassemble and run compression tests. Found "blow by" to be so bad that the oil was blowing out of the valve cover and past the seal. Disassembled the intake manifold and found puddles of oil in the base of the intake manifold. The MAF system had large amounts of carbon build up. Cleaned intake components meticulously. Reassembled and problem went away only to reemerge with massive oil loss September of 2022. Took to the dealer and they kept vehicle an entire week to report they found no oil loss. We then decided to rebuild engine; seals, pistons, rings, bolts etc.. After removing engine (January 2023 113,000miles) completely and breaking it down to crankshaft, I came to the conclusion the Intake manifolds direct injection system has a major flaw (mainly due to a pinhole becoming clogged found in the middle of the intake valve system). Causing massive pressure issues that can lead to full engine failure. So much carbon build up on pistons with major ignition problems visible by piston damage. In February of 2024 (131,000miles). Problem has started to reoccur with much blow by continuing near valve seal. I have pics

The contact owns a 2016 Chevrolet Equinox. The contact stated while driving at an undisclosed speed at the drive-thru, the engine made a knocking sound. The vehicle then lost motive power and failed to restart. No warning light was illuminated. Additionally, after the vehicle had an oil change at the dealer, the engine started consuming an excessive amount of oil, causing frequent oil changes every 3,000 miles. The oil life monitor system displayed 60% of oil remaining; however, when the vehicle was taken to Walmart for an oil change, the contact was informed that there was no oil in the engine. The vehicle also jerked while driving. The vehicle was towed to an independent mechanic, who diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 103,000.

Due to an oil consumption issue the engine failed while there was still 1000+ miles before the next oil change was due. There was no warning light indication that the vehicle needed oil. Needed to replace the entire engine. After engine was replaced we were required to monitor the oil consumption consistently. The issue continued and oil had to be monitored and changed more often than manufacturer recommendations. The vehicle was brought to an independent service center who then performed the work to replace the engine. Before the vehicle was brought to an independent service center we went directly to the Chevy Dealer that we bought the vehicle from. They wanted nothing to do with it and did not even offer to inspect the vehicle.

While vehicle was in motion front wiper failed to operate while it was heavily raining. Resulting in have to pull to side of road and request a tow to a mechanics due to the dangerous hazard of no longer being able to see out of front windshield and possibly causing accidents and or fatalities. This problem was due to the Ball joint linkage system failing.

The contact owns a 2016 Chevrolet Equinox. The contact stated that while driving at various speeds, the vehicle stalled. Occasionally the vehicle would surge forward while stopped at a stop light. The vehicle was taken to the local service center who discovered that the engine oil was extremely low. Engine oil was added to the engine however, after retrieving the vehicle the contact discovered that engine oil had leaked from the engine. The vehicle was taken to the local dealer who diagnosed that the engine was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 50,000.