2000 CHEVROLET EXPRESS Complaints

BRAKES KEEP WEARING OUT ON THIS VEHICLE. 4 BRAKE JOBS AND IT ONLY HAS 55,000 MILES AND WE BABY THIS VAN.*AK

VEHICLE IS RELEASED FROM THE FACTORY WITHOUT THE ABILITY TO HAVE A ROUTINE FRONT END ALIGNMENT PERFORMED. A PROCEDURE OF REMOVING "KNOCK-OUT TEMPLATES" MUST BE PERFORMED BEFORE AN ALIGNMENT CAN BE PERFORMED.*AK

TRANSMISSION STARTED TO SLIP WHEN CHANGING GEARS. THE TRANSMISSION ONLY HAD 39000 MILES ON IT. I TOOK THE VAN INTO TAYLOR CHEV. AND WAS TOLD THAT THEY NEEDED ME TO AUTHORIZE $1000 IN LABOR COSTS FOR DIAGNOSTICS. I CONTACTED GMC TO EXPLAIN THAT I FELT THAT THEY SHOULD PICKUP A ALL OR A PORTION OF THE COST. GMC TOLD ME THAT THEY DON'T SHOW ANY RECORDS THAT ROUTINE MAINTENANCE HAD BEEN PREFORMED BECAUSE IT WAS DONE BY AN OUTSIDE SOURCE AND "THAT DOESN'T COUNT". I PICKED UP MY VAN AND TOOK IT TO A TRANSMISSION SHOP WHERE I WAS INFORMED THAT THIS IS A COMMON PROBLEM WITH THE 4L60E TRANSMISSION. THE BEARING IS NOT HARDENED PROPERLY AND IS DESIGNED TO LAST FOR ABOUT 40000 MILES. THE TOTAL COST OUT OF MY POCKET FOR SHABBY WORKMANSHIP ON GMC'S PART WAS $1678.00, WHICH IS ABOUT $1500.00 LESS THAT THE DEALER TOLD ME IT WAS GOING TO COST. I WOULD LIKE TO SEE SOMETHING DONE ABOUT THIS.*AK

2000 CHEVROLET EXPRESS VAN, 1500, VA 4.3 LITER. CATALYTIC CONVERTER FAILS, DEALER SAYS THE INTERNALS COMPLETELY BREAK UP. HAVE HAD CATALYTIC CONVERTER REPLACED 3 TIMES AND THE ONE IN IT HAS FAILED ALSO. THE EXHAUST SYSTEM RATTLES WHEN CONVERTERS GO BAD. *JB

THE REAR BRACKETS ON THE DRIVER'S POWER SEAT ADJUSTER ASSEMBLY COMPLETELY BROKE. THE WHOLE SEAT NOW PIVOTS FORWARD ON THE FRONT BRACKETS. WE BROUGHT IT TO THE ATTENTION OF OUR LOCAL GM SERVICE CENTER AND WERE TOLD IT WOULD COST NEARLY $900 TO REPAIR. WE FEEL THIS IS A SAFETY ISSUE AND WOULD LIKE YOUR HELP IN IDENTIFYING THE HISTORY OF THIS TYPE OF FAILURE. WHAT STEPS SHOULD BE TAKEN WITH THE MANUFACTURER TO HAVE THEM REPAIR THIS AT THEIR EXPENSE?*AK

WHILE DRIVING , THE DRIVER AND PASSENGER SIDE SEAT SNAPPED OFF THE BASE, ON DIFFERENT OCCASIONS. *AK THE SEAT BELTS UNLATCHED BY THEMSELVES, THE REAR BENCH SEAT FAILED TO STAY TIGHT, THE SIDE DOORS WERE DIFFICULT TO OPEN AND THE OUTSIDE MIRRORS VIBRATED AND THE BRAKES WERE FAULTY *JB *NM

THE REAR PASSENGER SIDE TIRE TREAD SEPARATED. CONSUMER CHANGED THE TIRE, AND THE SPARE TIRE STARTED TO VIOLENTLY VIBRATE WHILE DRIVING. THE TIRE HAD A FOOTBALL SIZE BUBBLE IN IT. *AK THE CONSUMER STATED 4 OF THE ORIGINAL TIRES FAILED. *JB *NM

VEHICLE STALLS WHILE DRIVING AT SPEEDS 60 MPH OR MORE; RESTART AND STOPS AGAIN; THIS CAN HAPPEN AT ANY TIME. *LA

WHILE DRIVING FRONT BRAKES WOULD GET TOO HOT, CAUSING EXTENDED STOPPING DISTANCE. DEALER HAS BEEN NOTIFIED. *AK THE PASSENGER FRONT SIDE WHEEL SPEED SENSOR MELTED, THE ROTORS SHOWED MANY CRACKS IN THE SURFACE, AND THE CALIPER HAD BEEN REPLACED. THE FRONT WHEEL BEARINGS SHOWED SIGNS OF HEAT. THE CONSUMER REQUESTED TO BE INFORMED ABOUT THIS PROBLEM. *SCC *JB

2000 CHEVROLET EXPRESS VAN, PROBLEMS WITH INTERMITTENT DOWNSHIFTING FROM GEAR 4 TO GEAR 3 FOR NO APPARENT REASON. TRANSMISSION HAS BEEN SERVICED PROPERLY. NO ABUSE EVER AND MILEAGE TOO LOW FOR TRANSMISSION TROUBLES. 74000 MILES. *AK