2004 CHEVROLET EXPRESS 3500 Complaints

THE BRAKES ON MY 2004 CHEVY EXPRESS 3500 ACTIVATE WITHOUT WARNING, STOPPING THE VEHICLE IN TRAFFIC. A WARNING LIGHT INDICATED A FAILURE OF THE STABILITY CONTROL SYSTEM. FAULT CODE C0196 WAS RECORDED. MY DEALER REPLACED THE ELECTRONIC BRAKE CONTROL MODULE, BUT THE PROBLEM CONTINUES TO OCCUR. I WAS ALMOST REAR-ENDED WHEN THE VEHICLE STOPPED WITHOUT WARNING IN TRAFFIC. *TR

TL*THE CONTACT OWNS A 2004 CHEVROLET EXPRESS 3500. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE SUDDENLY LOST POWER STEERING AND BRAKING ABILITY. SHE LOST CONTROL OF THE VEHICLE. SHE SHIFTED INTO A LOWER GEAR AND WAS ABLE TO COMPLETELY STOP THE VEHICLE. THE CONTACT WAS ABLE TO TURN OFF AND RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO NUMEROUS DEALERS AND SHOPS, BUT THEY ALL CONFIRMED THAT THE HYDRO BOOST FAILED. THERE WAS A RECALL, IN WHICH THE VEHICLE WAS NOT INCLUDED. NO RECALL COULD BE FOUND FOR THE CHEVROLET EXPRESS 3500 ON THE NHTSA WEBSITE. THE CONTACT BELIEVED THAT IF THE FAILURE WAS COMMON, A RECALL SHOULD BE ISSUED. THE CURRENT AND FAILURE MILEAGES WERE 60,000.

2004 CHEVY EXPRESS WITH BROKEN STEERING IDLER. CONSUMER IS PLEASED BECAUSE THE DEALER FIXED THE PROBLEM. *KB **NAR**

FAULTY HINGE PINS ON SIDE DOORS OF 2004 CHEVY 3500 EXPRESS VAN CAUSE SEVERE BINDING OF HINGES. THIS COULD CAUSE EXIT DIFFICULTY FOR CHILD OR ELDERLY TRYING TO EXIT IN CASE OF ACCIDENT OR EMERGENCY. IT IS A PROBLEM WITH MULTIPLE YEARS AND PINS HAVE BEEN REDESIGNED. CHEVY WILL ONLY REPAIR AT CUSTOMERS EXPENSE. THIS IS NOT FROM DAMAGE OR NEGLECT. I HAVE TRIED TO LUBRICATE WITH NO SUCCESS. *JB

TL*THE CONTACT OWNS A 2004 CHEVROLET EXPRESS 3500. WHILE DRIVING 5-10 MPH, THE CONTACT HEARD A CLUNKING NOISE AND THE STEERING BECAME DIFFICULT. THE DEALER STATED THAT THE STEERING IDLER ARM WAS CRACKED. THE MANUFACTURER DENIED THE REPAIR AS PART OF RECALL NUMBER 07103 BECAUSE THE CRACK ON THE IDLER ARM WAS NOT LOCATED IN THE CORRECT SPOT. THE FAILURE MILEAGE WAS 39,000 AND CURRENT MILEAGE WAS 46,000. UPDATED 10/09/07. *JB

DT*: THE CONTACT STATED WHILE DRIVING ON THE HIGHWAY AT VARIOUS SPEEDS FOR AN EXTENDED PERIOD OF TIME WITH BRAKES DEPRESSED, THE STEERING WHEEL VIOLENTLY SHOOK. THE VEHICLE WAS INSPECTED BY A DEALER WHO TURNED THE BRAKE ROTORS. AFTERWARDS, THE PROBLEM PERSISTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO AS UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS CONTACTED.