2007 CHEVROLET HHR Complaints

Body clips holding fuel line causing rusting at these points. Leaking fuel from body clip in front of driver’s side rear tire. Based on caked on debris (mud like consistency), it has been happening for a while but wasn’t leaking to driveway due to disuse of the vehicle. This has commonly happened on 2008-2010 HHRs and Cobalts too.

The contact owns a 2007 Chevrolet HHR. The contact stated while her aunt was driving at an undisclosed speed, there was an abnormal gasoline odor inside the vehicle. After a visual inspection, it was discovered that there was fuel leaking from the rear of the vehicle. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to a past NHTSA investigation but was unable to provide specific information. The manufacturer was notified of the failure, and a case was filed. The failure mileage was unknown.

I HAVE A FUEL LINE LEAK NEAR THE LEFT REAR TIRE WHICH HAS BEEN HAPPENING WITH OTHER VEHICLES SUCH AS THE COBALT AND OTHER HHR'S. I TOOK IT TO A DEALER AND THEY SAID IT IS GOING TO COST ME $1500 TO REPLACE ALL THE FUEL LINES BECAUSE THEY WERE RUSTED REALLY BAD. THIS SHOULDN'T BE HAPPENING PLUS IT'S NOT VERY SAFE. THIS SHOULD BE A RECALL ITEM. MY VEHICLE ONLY HAS ~156000 MILES ON IT. THANKS

Leaking fuel near the left rear tire I have read online that other individuals are having the same issue. Please advise Thanks

The contact owns a 2007 Chevrolet HHR. The contact stated while exiting the driveway of a restaurant, the steering wheel failed to respond as needed. The contact turned off the vehicle. The contact stated that while attempting to restart the vehicle, the vehicle failed to restart. There were unknown warning lights illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the alternator and battery needed to be replaced. The vehicle was then towed to a second independent mechanic who informed the contact that the key was stuck in the ignition switch and the electrical system was burned. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 144,000.

The contact owns a 2007 Chevrolet HHR. The contact stated while driving at various speeds between 30-65 MPH, the steering wheel became extremely difficult to steer and the vehicle lost electrical power. The contact stated that she would veer to the side of the road or park the vehicle whenever the failure occurred. There was no warning light illuminated. Additionally, the contact stated that upon attempting to restart the vehicle and inserting the key in the ignition switch, the vehicle failed to start. The contact stated that she continually turned the key in the ignition switch until the vehicle restarted. The contact stated that the failure had been reoccurring increasingly and the vehicle failed to restart after several attempts. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The contact stated that the vehicle was previously repaired under an NHTSA Campaign Number: 14V171000 (Electrical System) however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 15,000.

While driving, more specific while turning the powersteering goes out at any given time. It has also done this while switching lanes on the freeway.

Notice a gas smell coming from the car when I would get out of the car after driving it . but could not find the source of the smell at first . Then one day I was parked on a black Asphalt payment and seen a wet spot on the payment I then looked under and seen a small wet spot on the protector where the gas line run through on the left side near the lower rear door wear it opens up I then made a call to my GM car dealer ship to see if it is under warranty or a recall but they said no recall for the Fuel lines that when i looked up if other people are having the same problem . And found over 614,000 having the same problem . Note I am waiting on the parts from my dealer so they can fix it which is over $900.00 I am paying for it .

The power steering keeps going out. This caused my 15 year old daughter to nearly run into a concrete barrier wall on her way to school. It sent her into a panic and scared the life out of her.

The power steering intermittently (but quite regularly) goes out. The "power steering" warning also comes up on the display panel on the dash. If vehicle is restarted, the power steering seems to resolve itself again but only temporarily. This problem is becoming much more frequent. This is a safety issue because without the power steering in working order, the steering wheel becomes difficult to turn and this happens not only on the road but also on the highway as well when the vehicle is going 70 miles per hour. We have not had the vehicle serviced or looked at for this issue. It has been ongoing for several months but seems to be getting worse/more frequent.