1991 CHEVROLET LUMINA Complaints

SLIDING SIDE DOOR OUTSIDE HANDLE BROKE OFF IN CONSUMER'S HAND. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. *AK

SEAT BELT RETRACTOR WILL NOT RETRACT BACK INTO POSITION, WILL NOT HOLD OCCUPANT, CAUSING LOSS OF PROTECTION. *AK

REAR SEAT BELTS AND DRIVER'S SEAT BELT WILL NOT RETRACT. DEALER HAS BEEN NOTIFIED, AND WILL NOT REPAIR. PLEASE PROVIDE FURTHER INFORMATION. *AK

THE FRONT SUBFRAME MOUNTING BOLTS RUSTED CAUSING THE RETAINERS AND FRAME MOUNTS TO SLIP OFF THE BOLTS. THE CAR WAS IN THE YARD WHEN THIS HAPPENED. I DID FIND A RECALL ON THESE BOLTS AND RETAINERS UNDER A 1991 LUMINA. HOWEVER THE DEALERSHIP IN MY AREA (SHEARER CHEVEROLET OF SOUTH BURLINGTON VERMONT) INFORMED ME THAT MY CAR"S VIN NUMBER DID NOT FALL UNDER THAT RECALL. MY QUESTION IS IF MY VIN NUMBER DID NOT FALL UNDER THAT RECALL AND THE SAME THING HAPPENED TO MY CAR AS THE REST OF THEM DOE'S IT NOT MAKE SENSE THAT THERE ARE MORE LUMINA"S OUT THERE THAT THIS COULD HAPPEN TO? AND IF SO HAS IT ALL READY. WHEN THESE MOUNTS POP OFF THE BOLTS THE STEERING HOUSEING COMES APART, AND BELIEVE ME IT COMES APART. I ONLY THANK GOD THAT I WAS BACKING OUT OF MY YARD WHEN THIS HAPPENED TOO ME.AGAIN I ASK THE QUESTION IF MY CAR DID THESAME THING THAT THE RECALL SAID IT WOULD DO IS IT POSSIBLE THAT THERE ARE OTHER LUMINA'S OUT THERE THAT THIS COULD HAPPENED TOO? AND BY THE WAY WHY WON'T THE DEALER HERE LET ME HAVE THE RECALL BOLTS AFTER THIS HAS HAPPEND TO ME INSTEAD OF CHARGING ME FOR THEM? THANKS. LYLE BAXTER *AK

EXHAUST VALVES ARE STICKING, CAUSING THE TIMING BELT TO SLIP. WE HAVE REPLACED THE BELT AND THE PROBLEM IMMEDIATELY RECURRED. GM HAS BEEN AWARE OF THE PROBLEM FOR YEARS, BUT HAS BEEN FAIRLY QUIET ABOUT RESOLVING IT. THEY PRODUCED A NUMBER OF 3.4 ENGINES WITHOUT CHROME PLATED EXHAUST VALVES, AND THE SOFTER VALVES DISTORTING AND STICK, CAUSING THE ENGINE TO JUMP TIMING. THIS IS A SOPHISTICATED DUAL OVERHEAD CAM V-6 AND TOLERANCES ARE CRITICAL. GM ISSUED A DIRECTIVE TO REPLACE THE CYLINDER HEADS ON THE AFFECTED ENGINES, HOWEVER OURS WAS NOT INCLUDED IN THE RECALL, EVEN THOUGH IT WAS BUILT IN THE PLANT THAT PRODUCED THE ENGINES AND IS IN LINE WITH THE SEQUENCE OF ID NUMBERS. GENERAL MOTORS IS DISAVOWING THE PROBLEM, EVEN THOUGH IT IS A KNOWN DEFECT. THEY HAVE REPLACED A NUMBER OF CYLINDER HEADS AND EXHAUST VALVES, AND I BELIEVE THEY SHOULD ACKNOWLEGE THEIR ERROR IN OUR CAR AND REPAIR OUR ENGINE. BECAUSE OF THE SOFT EXHAUST VALVES, THERE IS NO ALTERNATIVE BUT TO MAKE MAJOR REPAIRS, ALL DUE TO IMPROPER MANUFACTURING. *AK

VEHICLE WAS SHIFTED INTO PARKED WHILE STILL RUNNING. CONSUMER GOT OUT AND WENT TO FRONT DOOR. WITHIN MINUTE LATER, VEHICLE JUMPED OUT OF GEAR AND RAN INTO THE REAR END OF A TRUCK. DEALER/MANUFACTURER WAS NOT CONTACTED AT THIS TIME. *AK

WHILE TRAVELING 55 MPH VEHICLE STALLS WITHOUT INDICATION. DEALER HAS BEEN NOTIFIED, CAN' T DUPLICATE PROBLEM. ALSO,ALTERNATOR/BATTERY/COMPUTER, AND FUEL FILTER LINE FAILED AND WERE REPLACED BY DEALER. *AK

CONSUMER NOTICED CORROSION AND RUST ON THE FUEL LINE/BRAKE LINE, AND SUSPENSION COMPONENTS, IN BOTH FRONT AND REAR. IF PARTS RUST ALL THE WAY THROUGH, IT COULD EVENTUALLY LEAD TO LOSS OF CONTROL. ALSO, BOTH REAR CALIPER SLIDE PINS SEIZED, CAUSING PREMATURE BRAKE PAD WEAR. BOTH REAR CALIPERS AND ALL BRAKE PADS HAD TO BE REPLACED. *AK

WENT OUT TO START VEHICLE, HEARD A STATIC NOISE, SMELLED SMOKE AND SAW SMOKE COMING OUT FROM STEERING COLUMN. TRIED TO UNHOOK THE BATTERY, BUT VEHICLE CAUGHT ON FIRE. CONTACTED DEALER. *AK

FRONT ENGINE MOUNTS BROKE WHILE GOING 55MPH. LOST CONTROL ON A 6-LANE HIGHWAY DURING RUSH HOUR TRAFFIC. ALSO, FRONT LEFT TIRES HAD BLOWN OUT. HAD NO WARNING IN THAT REGARD. MANAGED TO GET VEHICLE TO SIDE OF ROAD. VEHICLE WILL BE TOWED TO DEALER. *AK