1997 CHEVROLET MALIBU Complaints

INTAKE MANIFOLD GASKET, 1997 CHEVROLET MALIBU (3.1 V6 ENGINE). MY UNDERSTANDING IS THAT THIS IS AN EXTREMELY COMMON PROBLEM WITH GM PRODUCTS, PARTICULARLY THIS ENGINE AND CAR. I ALSO SEARCHED THE COMPLAINTS DADABASE AND I FOUND THAT IT APPEARS TO BE A COMMON PROBLEM. ALSO, THEFT SYSTEM LIGHT COMING AND EXCESSIVE BRAKE PAD WEAR AND ROTOR WARPING APPEARS TO BE A VERY COMMON PROBLEM. THIS WAS FIXED ONCE, THE PROBLEM IS REACCURING. $1200 IN MAJOR REPAIRS SO FAR ON A 1997 CHEVROLET MALIBU, NOT TO MENTION THE OTHER SMALL BUT FREQUENT REPAIRS. I AM DISSATISFIED WITH BOTH OF MY RECENT GM PRODUCTS BECAUSE THEY BOTH HAD SIMILAR PROBLEMS THAT LEAD TO COSTY REPAIRS OR ENGINE FAILURE AT 120,000 MILES ON A 1994 GRAND AM AND 89,000 MILES ON A 1997 MALIBU. I HAVE HAD TO FIX THE RADIO NUMEROUS TIMES (CABLE COMES UNPLUGGED QUITE OFTEN). *AK

EXCESSIVE BRAKE PAD USEAGE WITH THIS CAR. THE INTAKE MANIFOLD HAD TO BE REPLACED AT 88,000 MILES. I AM VERY VERY DISSATISFIED WITH THIS CAR AND DO NOT PLAN ON PURCHASING ANOTHER GM AT THIS TIME. *AK

STEERING WHEEL MAKES A CLICKING NOISE WHEN TURNING. STEERING WHEEL HAS TO BE FULLY ROTATED TWICE BEFORE THE VEHICLE GOES INTO THAT DIRECTION. *AK

WHILE DRIVING 45 MPH, THE STEERING WHEEL LOCKED. THE VEHICLE WAS TAKEN TO A REPAIR SHOP, WHERE THE RACK AND PINION WAS REPLACED. *AK WHILE DRIVING THE VEHICLE HAD BECOME DIFFICULT TO TURN ONE WAY WHILE REMAINING EASY TO STEER IN THE OPPOSITE DIRECTION. THE RACK WAS REPLACED. *SCC *JB

WHILE DRIVING AT 35 MPH, THE CONSUMER HIT A POT HOLE AND THEN SHE LOST CONTROL OF THE VEHICLE. THE FRONT END OF THE VEHICLE IMPACTED A DITCH AND THEN THE VEHICLE BOUNCED ONTO A FIELD. NONE OF THE FRONT AIR BAGS DEPLOYED UPON IMPACT. CONSUMER FRACTURED HER BACK. *AK *SCC

BASICALLY THIS IS TO COMPLAIN ABOUT THE GM 3.1L V6 ENGINE IN MY 1997 CHEVROLET MALIBU. I UNDERSTAND THAT THERE ARE 1100 COMPLAINTS AND WOULD APPRECIATE SOME HELP WITH MY SITUATION ALSO. IN THE LAST COUPLE OF WEEKS MY VEHICLE HAS STARTED TO HAVE A MULTITUDE OF PROBLEMS THAT HAD LED UP TO MY CURRENT FIASCO. ABOUT 2 WEEKS AGO AFTER AN OIL CHANGE, MY 97 MALIBU BEGAN TO HAVE PROBLEMS WITH A LIFTER 'TICKING.' MY MECHANIC SUSPECTS A COLLAPSED LIFTER; THIS HAS NOT BEEN REPAIRED YET. MY CAR ALSO NOW RUNS VERY ROUGH AND DOES NOT HAVE THE POWER IT USED TO HAVE. TODAY, 10/2/03, I WENT TO SEATTLE AND EXPERIENCED A SEVERE HEATING PROBLEM. THE TEMP GAUGE BEGAN TO RISE VERY QUICKLY AS WE ARRIVED AT OUR DESTINATION JUST SOUTH OF SEATTLE, THE NEEDLE WAS PEGGED AND THE TEMP LIGHT ACTUALLY CAME ON. I HAD DEX-COOL ANTI-FREEZE LEAKING ALL OVER THE ENGINE AND ALL OVER THE GROUND. WE WAITED FOR APPROXIMATELY 30 MINUTES BEFORE WE STARTED OUT AGAIN AND YES WERE AFRAID THE ENTIRE WAY HOME THAT WE WOULD GET STRANDED ON THE ROAD SOMEWHERE. I GOT THE CAR TO MY MECHANIC AND HE HAS INFORMED US THAT WE PROBABLY NEED A NEW ENGINE, ON A CAR THAT ONLY HAS 95,000 MILES ON IT. I HAVE READ OTHER COMPLAINTS ON THE INTERNET ABOUT THE FAULTY GASKETS WHICH RESULT IN ANTI-FREEZE LEAKING INTO THE ENGINE CAUSING BAD CAMSHAFTS, BAD BEARINGS AND WHO KNOWS WHAT ELSE. IF I HAD THE RESOURCES TO DUMP THE PIECE OF JUNK I JUST MIGHT, HOWEVER I DO NOT HAVE THE RECOURSES TO DO THAT, I MUST GET IT FIXED. *LA

ABS LIGHT COMES ON AFTER I LOSE BRAKE. CHRONIC PROBLEMS ASSOCIATED WITH THIS YEAR VEHICLE ARE ABS SENSOR, BELT TENSIONER BREAKS AWAY, COOLING SYSTEM HEAT CONTROLS, WIRING TO THE REAR LIGHTS. THESE ARE PROBLEMS THAT THIS YEAR MODEL HAS THAT SHOULD BE RECALLED. ESPECIALLY WHEN THE BREAK SENSOR GOES OUT AND BRAKES ARE LOST. WHY HAS NOTHING BEEN DONE TO FORCE CHEVROLET TO FIX THESE PROBLEMS? IT IS NOT JUST ONE CAR BUT ALL OF 1997 MALIBU THAT HAS THE PROBLEM. IT IS A DEFINITE SAFETY ISSUE. *JB

LOSING WATER FROM RADIATOR RESERVOIR INTO THE INTAKE MANIFOLD GASKET. I HAVE RESEARCHED THIS PROBLEM AND IT SEEMS TO BE VERY COMMON ON 97 CHEVY MALIBU.

SEP.6 2001 &JULY 22, 2003 RECALL WINDSHIELD WIPER PIVOT HOUSING---DEALER SAID I DIDN,T NEED THE RECALL REPLACED AND MERCY FROM G.M. SAID TAKE THE CAR IN ON THAT RECALL STILL NO WORK ON WIPER PIVOT HOUSING----LOTS OF PROBLEMS WITH THIS LOW MILELAGE CAR---32610.*AK

MANY PROBLEMS WITH MY 1997 MALIBU, SUSPENSION NOISE/LEAKY WATER PUMP/KEY AGNITION, AND LOCK COLLAR. 32600 MILES ON THE CAR MANY REPAIRS. *AK