2000 CHEVROLET MALIBU Complaints

ENGINE SHUT DOWN WHILE TRAVELING. COASTED TO SHOULDER. AFTER WAITING 10-15 MINUTES CAR STARTED UP AGAIN. OVER NEXT TWO DAYS SOMETIMES CAR WOULD START AND SOMETIMES IT WOULD NOT. WHEN IT FAILED TO START IMMEDIATELY AFTER MULTIPLE ATTEMPTS OVER 10-15 MINUTES CAR WOULD FINALLY START. AFTER THREE DAYS OF THIS SITUATION TOOK CAR IN FOR DIAGNOSIS AND REPAIR,AND IGNITION LOCK CYLINDER WAS FOUND TO BE DEFECTIVE AND REPLACED. MECHANIC ADVISED THIS WAS A COMMON PROBLEM ON ALL CHEVROLET MODELS FOR MANY YEARS. *TR

I WAS DRIVING MY VEHICLE AND IT MADE A LOUD NOISE/ SOUND LIKE IT CAME FROM THE HEATING AND COOLING VENT INSIDE. I WENT TO THE STORE AND THE KEY WAS STUCK IN THE IGNITION. I GOT IT OUT . START THE CARD AFTER I LEFT THE STORE. THE CAR SPEED WAS 10 MPH TO 25 MPH WITH NO METER MOVING FOR THE GAS, THERMOSTAT, THERE WAS NO ELECTRICITY. TRIPLE A PICK UP MY VEHICLE ON FEBRUARY 27, 2014. WEBER CHEVROLET REPLACED CYLINDER AND IGNITION SWITCH. THE TOTAL COST WAS $854.22. I HAD THIS IGNITION SWITCH REPLACED FOR THE 3RD TIME. I WOULD LIKE TO HAVE AND REFUND ON MY IGNITION SWITCH. *TR

BOUGHT THIS CAR AS A PROJECT CAR WITH LOW MILEAGE. GOT BOUGHT AT A USED CAR DEALERSHIP. PISTON SLAP!!! ESPECIALLY COLD. FRONT SUB FRAME ROTTED OUT AND RACK AND PINION DESTROYED NEEDED IMMEDIATE REPLACEMENT. LATER WAS TOLD ROCKER PANELS ARE DESTROYED WITH HUGE HOLES I WAS CLEARLY UPSET ANOTHER MALIBU WITH ANOTHER PROBLEM. COMMON PROBLEM WITH MALIBU'S FROM '98-'02. WAS UNABLE TO SAFETY BECAUSE OF PANELS MISSING A LAYER IN SPOTS (HOLES). REAR QUARTER PANELS SEVERE ROTTING AROUND WHEEL WELLS AND GAS CAP AREA REQUIRING BONDO TO FILL IN HOLES A HORRIBLE PROBLEM WITH MALIBU'S. AIR CONDITIONING CLUTCH GRINDING CONSTANTLY AND HALF THE TIME A/C BOTTOM WORKS. SADLY GM WILL NOT RECALL THESE ISSUES NOW HAVE TO INVEST $7000 TO MAKE INTO A SHOW CAR. GM SHOULD BE ASHAMED OF BODY PROBLEMS AND CONSTANT PISTON SLAPS AND LIFTER KNOCKING. I HAVE TO DO AN OVERHAUL OF $600-800 ON ENGINE. PATHETIC GM LINK TO THE PISTON SLAP ON MY CAR ON YOUTUBE : HTTPS://WWW.YOUTUBE.COM/WATCH?V=MNTTRCTQ5MM&FEATURE=YOUTUBE_GDATA_PLAYER. *TR

THE CAR WILL NOT TURN LEFT. IT MAKES A METAL ON METAL SOUND. MY MECHANIC SAYS THE ENGINE CRADLE IS COMPLETELY RUSTED OUT, AND THE RACK AND PINION STEERING NEEDS REPLACING.HE SAID THE RUST IS CAUSED BY THE HOSE FROM THE AIR CONDITIONING DRIPPING ON THE ENGINE. HE SAID THAT HE SEES THE ENGINE CRADLES RUSTED OUT ALL THE TIME ON CHEVY MALIBUS. I HAVE MAINTAINED THIS CAR AND NEVER KNEW ABOUT THIS RUST UNTIL NOW. THE CAR HAS VERY LOW MILES FOR ITS AGE. THE BODY OF THE CAR IS PERFECT. I WOULD LIKE CHEVY TO REPAIR THIS. IT WOULD BE ABOUT $2000 OR SO TO GET THE CAR REPAIRED WITH A USED ENGINE CRADLE AND A USED RACK AND PINION. I SEE THAT OTHER PEOPLE HAVE TOLD YOU ABOUT THE SAME PROBLEM. *TR

THE RACK AND PINION MOUNTS RUSTED FROM THE FRAME. SHAKING AND ISSUES WITH VEHICLE PULLING TO THE LEFT WHILE DRIVING BEFORE BREAKAGE.

WHEN I PUT THE KEY IN THE IGNITION AND TRY TO TURN IT ON THERE'S NO POWER TO THE FUEL PUMP AND IT ROTATES BUT DOESN'T START I'VE SEEN A LOT OF PROBLEMS PERTAINING TO THIS IGNITION DEFECT ALSO I NEED TO WAIT 30 SECONDS TO SEE THE LIGHTS POWER ON THE ODOMETER AND STILL DOESN'T START. *TR

4-2007 GAS WAS POOLING AROUND ENGINE, REPLACED INTAKE GASKET, NEXT TIME I DROVE CAR , SAME PROBLEM,THEY HAD TO DO OVER ( THEIR DIME) BECAUSE FAILED TO REPLACE O-RING. 9-06-07 WOULD NOT START AT GAS STATION, 9-13-07 PASS LOCK SYS. INSTALLED IGNITION SWITCH LOCK CYLINDER. 11-13-09 TURN SIGNALS, TAIL LIGHTS NOT WORKING, BETWEEN 11-13-09 @ 4-07-2010 , I HAVE BEEN BACK SEVERAL TIMES, BECAUSE SIGNALS FAILED OFF AND ON WHILE DRIVING. TOLD ME, THEY COULD NOT DO ANYTHING UNTIL THEY COULD SEE IT FAIL, WHICH IT DID ON 4-07-2010 WHILE I WAS CLOSE TO SHOP. FLASHER SWITCH/RELAY BAD, REPLACED. 6-10-10 HARMONIC BALANCER WORN AND SERPENTINE BELT & SEAL REPLACED. 2-23-12 WATER PUMP LEAKING, REPLACED. 6-14-12 REPLACED SPARKS PLUGS, WIRES, COMPLETE INJECTION FLUSH. 9-14-2012 STRONG FUEL SMELL (FUMES) INSIDE CAR AND UNDER HOOD, PERFORMED FUEL LEAK TEST, NO VISUAL SIGNS OF FUEL LEAK. CHECKED VENT CANISTER, GAS CAP, NO FUEL CODES. HAVE BEEN FUMES SEVERAL TIMES SINCE BUT BY THE TIME I DROVE TO SHOP COULD NOT SMELL FUMES. 4-22-13 FUMES VERY STRONG INSIDE CAR AND UNDER HOOD, DROVE TO SHOP AND THEY COULD SMELL FUMES , PUT IT UP ON RACK AND CHECKED ALL UNDERNEATH, NO SIGN OF LEAK UNDER CAR OR UNDER HOOD. NO ONE CAN TELL ME WHAT THE PROBLEM IS BUT SAY PROCESS OF ELIMINATION IS ONLY WAY. WHY ON 6-10-2010 NEED TO REPLACE SERPENTINE BELT AND SEAL AND AGAIN ON 2-08-2013 REMOVE AND REPLACE SERPENTINE BELT AND BELT TENSIONER?? WHEN THIS CAR REACHED 62,000 I HAVE HAD NOTHING BUT TROUBLE WITH IT AND NOW I AM AFRAID OF A FIRE, GAS IS LEAKING SOMEWHERE!!!! I ONLY HAVE 97,461 MILES. IS NOT THERE SOME WAY OR SOMEONE WHO CAN FIND ORIGIN OF THE FUEL LEAK?

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE LEFT TURN SIGNAL FAILED. THE CONTACT WOULD TRY TO ACTIVATE THE SIGNAL BUT IT WOULD NOT ENGAGE. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC, WHO STATED THAT THE BULB AND THE CIRCUIT BOARD NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 141,000.

I WAS TRAVELING TO BRIGHTON, CO FROM FT. MORGAN, CO TO SELLER MY 2000 CHEVY MALIBU. OUR INTENDED PURPOSE WAS TO TAKE THE FUNDS FROM THE SELL AND PICK UP 1996 CHEVY S10. PRIOR TO THIS TRIP MY CAR HAD DIFFICULTIES STARTING BUT NEVER FAILED TO START AFTER SEVERAL ATTEMPTS. THE CAR ENGINE STALLED COMING OFF OF THE OFF RAMP AT AROUND 30 MPH. WHEN THE CAR STALLED I HAD TO MANUALLY STEER THE VEHICLE TO GET IT TO THE SHOULDER OF THE ROAD (I JUST HAD CARPOOL TUNNEL SURGERY AND IT WAS PAINFUL TO DO SO). AFTER ABOUT 2 MINUTES I ATTEMPTED TO RESTART THE CAR AND IT RESTARTED AFTER ABOUT THE FORTH ATTEMPT AT TURNING THE KEY ON WAITING 30 SECONDS FOR THE FUEL PUMP AND THEN TURNING THE KEY OVER THE REST OF THE WAY. AFTER ABOUT 2 CITY BLOCKS THE CAR STALLED AGAIN GOING AROUND 20 MPH. THIS TIME IT TOOK MUCH LONGER BEFORE THE CAR WOULD START AGAIN. ABOUT 25 MINUTES, WE LET THE ENGINE COOL AND AGAIN IT TOOK SEVERAL ATTEMPTS TO TURN THE MOTOR OVER BUT IT FINAL DID START. IT TRAVELED ABOUT A MILE AND STALLED AGAIN GOING ABOUT 5 MPH. THIS TIME WE LET THE CAR SIT FOR AN HOUR AND RE ATTEMPTED TO START IT. IT WENT ANOTHER MILE AND STALLED AGAIN. WE CONTACTED A MECHANIC WHO SUGGESTED IT MAY BE THE FUEL REGULATOR OR THE FUEL PUMP. WE HAVE REPLACED THE REGULATOR AND THAT DID NOT WORK WE HAVE TESTED THE FUEL PUMP AND IT IS WORKING FINE. I HAVE READ SEVERAL DOCUMENTS INVOLVING THIS ISSUE AND I AM STILL NO CLOSER TO FIGURING OUT WHAT THE PROBLEM IS. I ONLY KNOW I AM NOT THE ONLY ONE HAVING THIS ISSUE. THIS CAR ALSO HAS A FAULTY CHECK ENGINE LIGHT AND DOES NOT APPEAR TO BE OVER HEATING WHEN IT STALLS. THE THEFT LIGHT COMES ON INTERMITTENTLY BUT I HAVE CHECK THE VIN ON MY CAR WITH CHEVY AND THERE IS NO RECALL FOR MY CAR. WHY IS THIS HAPPENING AT 115K. THIS COULD BE VERY DANGEROUS AND I HAVE HALF A MIND TO CALL A NEWS STATION. I'M SURE CHEVY WOULD LOVE THE NEW ADVERTISING. PLEASE FIX. *TR

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE TURN SIGNALS AND HAZARD WARNING LIGHTS DID NOT ILLUMINATE INTERMITTENTLY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.