2020 CHEVROLET MALIBU Complaints

I am writing to report a serious and dangerous issue that occurred with my 2020 Chevrolet Malibu LT on April 27th 2026. While driving on the interstate after work, my vehicle suddenly experienced a failure that made it extremely unsafe to operate. The brake pedal became extremely hard to press, and the vehicle did not want to slow down or stop properly. This created a very dangerous situation while I was driving at highway speeds. Additionally, I noticed that nearly all of the engine oil was gone, which is extremely concerning and may be related to the failure. Based on these symptoms, it appears the vacuum pump may have failed while the vehicle was in motion. This issue placed me at significant risk of an accident and could have resulted in serious injury. I am requesting an immediate investigation into this matter and assistance with repairs. I would also like to know if there are any recalls, known defects, or extended warranties related to this issue. Please advise on the next steps as soon as possible, as the vehicle is currently unsafe to drive.

When braking, the vehicle experiences a system failure. There is a loud impact, the dashboard shuts down, warning lights activate all gauges go to the left, and the vehicle loses power and enters a reduced speed mode before recovering. This has been ongoing and creates a dangerous driving condition. The dealership has had the vehicle over four months and has not diagnosed or repaired the issue. Please Note: I have attached the invoice sent to me on April 17, 2026, via email. The information in section 3 had been changed while I was sitting there. It originally state, engine repair needed. It said absolutely nothing about the reason I was there, which was what I am now describing. The description in section 3, has been worded incorrectly. It states I said, when coming to a stop, but it is not only when coming to a stop, but even if I am in flowing traffic and have to touch my brakes to slow down at any given time, there is a loud thump sound and a jolt, all of the dash lights come on, all the gauges go to the left, the warning lights are on and it has to sit there, not for a few seconds, but until those lights go back off and then it will move very slowly, until it decides to gain power. You have no warnings as to when it will happen or when the car will regain speed when it does happen. I gave pictures of the dash on April 17, 2026, as well and these pictures have the date December 31, 2025, on them. As I was having the issue while driving it to the dealership for repair. The invoice mentions [XXX] . I do not know her and have never met her. I only spoke with a man. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving approximately 35 MPH, an unknown warning light illuminated, and the vehicle started to lose motive power. The contact stopped at a traffic signal and after depressing the accelerator pedal when the light changed, the vehicle stalled. The vehicle was restarted after several attempts, but the vehicle failed to exceed 5 MPH while accelerating. The contact stopped and the vehicle was towed to an independent mechanic. The vehicle was diagnosed, the battery was replaced, and the system was reset; however, the failure reoccurred and the vehicle was towed to a dealer. The vehicle was diagnosed, and it was determined that the front wiring harness needed to be replaced. The vehicle was repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 23,000.

Reduced Engine Power Light: The car limits acceleration, often accompanied by a check engine light. Stalling or Hesitation: Engine stalls or acts sluggish when accelerating, particularly in traffic. Limp Mode: The vehicle restricts speed, making it difficult to accelerate. The car stop working in the middle of the freeway and I was in the car with my child when it stop acceleration all gages in the car were going crazy, car was shaking bad finally car turn off. I was able to make it to the emergency lane of the freeway. There's similar complaints for 2020 Chevy Malibu but no recall has been done. Per my research it looks like a lot of this type of vehicles have problems with throttle body causing Engine stalls. Do the right thing and open up a vehicle recall, thank you!

While driving the brake pedal became hard to push out of no where. Once the car got to the shop it stopped cranking. The shop is stating that the brake vacuum pump is the cause of the brake pedal messing up, and that it also caused other engine damages estimating $3000.00

The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving approximately 60 MPH on the freeway and depressing the brake pedal to slow down, the brake pedal was difficult to depress, and the vehicle failed to immediately stop. During the failure, the check engine and traction control warning lights were illuminated. The vehicle was slowly driven to the residence and parked. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 85,547.

Several things have been going wrong with this car. I have only had it for about 7 months. Minimal driving. Got the car with 84,000 miles and it now has 88,000 miles. About 2 months ago the check engine light came on. Got it into a shop and they said an oil change may possibly help with this. Got the oil change, cleared the code, drove it around and check engine light came back on. Brought it back to the shop and now the entire valve cover needs replaced. It’s been about 2 weeks since then haven’t had it fixed due to low funds. A couple days ago I was driving with two [XXX] olds in the car and was at a stop light. After about a minute the cars engine turned completely off lost all power including the center screen that displays your settings and radio, all lights, and the screen behind the wheel all with my foot on the break at a stop light. Due to this situation I was unable to turn my hazards on to alert the cars coming up being me at a green light absolutely panicked that we were going to get into an accident. A little while after the car turned back on, but unfortunately when trying to push down on the gas pedal nothing was happening. No revving sound and no movement of the car. Car still in drive. A police officer pulled up behind me to check if we were okay. He stayed to keep us safe until people came to push the car off to the side. During the push the wheel was almost completely locked up as well as the breaks. This is not the first time the breaks have locked up on me. Next day we got the car to a safe area to be parked. A couple days later went to try and turn the car on and immediately the car is shaking violently and making horrible noises. The car is unsafe for me to drive and unsafe for people on the road. This car is completely unable to be driven now also due to the horrible shaking. No recalls were found under my VIN, but all of these signs seem to be a problem for other people. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owned a 2020 Chevrolet Malibu. The contact stated that while driving approximately 65 MPH, the brake pedal became inoperable. There was a warning light illuminated. The contact stated that the brake pedal failed to function properly while attempting to stop the vehicle. Additionally, while the vehicle was parked and turned off, the contact became aware that brake fluid was leaking onto the engine. A mobile independent mechanic inspected the vehicle and determined that the brake vacuum pump had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 118,000.

The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving at various speeds, the vehicle hesitated and failed to properly accelerate while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was taken to a local independent mechanic, who associated the failure with TSB: N222372590. An appointment was scheduled with the dealer to inspect the vehicle. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was approximately 114,000.

I was unaware that when I purchased this vehicle that when the oil is low, the breaks go out and the break power booster shatters. The beaks have gone out on me 2x already and thankfully I’ve only had to replace the break power booster only once. Now once the oil is changed the breaks go back to normal, there is no grinding of any sort heard, so now going forward I pay real close attention to my engine, I listen and pay attention to the feeling and sound of the breaks, once the oil begins to become low knowing it’s time for an oil change around 40% is when I start to feel a bit of the difference in the breaks and I can feel a little bit of grinding, no oil light has come on at this time nor has the oil light or any type of signal has ever come on at anytime to let me know that it was time for an oil change. I’ve checked for recalls, I’ve checked message boards, mechanics have no clue about this problem, but at least my mechanic does now!