2002 CHEVROLET MALIBU Complaints

HAD TO REPLACE THE INTAKE MANIFOLD GASKET ON 2002 CHEVY MALIBU. WAS INFORMED BY SEVERAL MECHANICS THAT THIS IS A VERY COMMON PROBLEM. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHILE IDLING AT A TRAFFIC LIGHT, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MADE SEVERAL ATTEMPTS TO RESTART THE VEHICLE, AND FINALLY THE ENGINE TURNED OVER. THE VEHICLE WAS DRIVEN TO HIS RESIDENCE AND TOWED TO AN AUTHORIZED DEALER. THE DEALER REPLACED THE AIR CONDITION COMPRESSOR. PREVIOUSLY, THE ENGINE GASKET WAS REPLACED. RECENTLY, THE VEHICLE BEGAN RIDING ROUGHLY AND WAS TAKEN TO THE AUTHORIZED DEALER. THE SERVICE TECHNICIAN STATED THAT THE FAILURE WAS RELATED TO THE FUEL INJECTOR, WHICH NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

COMPONENT: AIR CONDITIONER DETAILS: I AM BASICALLY HAVING THE SAME TROUBLE WITH MY AIR CONDITIONING. IT WILL KICK OFF. THE AIR RECIRCULATION WILL ALSO KICK OFF AND CHANGE TO FRESH AIR. IT IS DRIVING ME UP A WALL. I LIVE IN GEORGIA AND NOT HAVING AN AIR CONDITIONER IS AWFUL, BUT TO HAVE ONE THAT WILL WORK SOMETIMES, IS AWFUL. I HAD THIS SAME PROBLEM IN 2005. MY CAR WAS STILL UNDER AN EXTENDED WARRANTY. THE DEALER WROTE: C/S AC WILL SWITCH FROM RECIRCULATION TO FRESH AIR BY ITSELF. ALSO SAID AT TIME IT FEELS LIKE THE A/C IS ON WHEN IT'S NOT. HEATER CONTROL HEAD HAS INTERNAL SHORT CAUSING IT TO SWITCH BY ITSELF. INSPECT AND REPLACE HEATER/AC CONTROL HEAD. PARTS $157.48, LABOR $142.50, TAX $11.02. TOTAL $311.80. THIS TIME I ONLY HAD TO PAY $100 DEDUCTIBLE. THIS WAS DONE ON 7/28/05, INVOICE CVCS51146 AT CARTERSVILLE CHEVROLET IN CARTERSVILLE, GA. IS THIS SOMETHING THAT FAILS EVERY 3 YEARS!! IT IS A 2002 AND FAILED THE FIRST TIME IN 2005 AND AGAIN NOW IN 2008!!! WILL CHEVROLET PAY FOR THIS??? THEY SHOULD. *TR

I HAVE A 2002 CHEVY MALIBU THAT LOCKS ON ME BECAUSE OF THE ANTI-THEFT SYSTEM. WHEN I AM DRIVING THE CAR SHUTS OFF AND THE SECURITY LIGHT STAYS ON. SOMETIMES THE CAR WON'T START AT ALL. I USED TO WAIT FOR THE 10 MINUTES TO RESTART THE SYSTEM BUT NOW THE LIGHT JUST STAYS ON. I HAVE TO TAKE A BABY BACK AND FORTH EVERYDAY AND CAN NOT HAVE MY CAR CUTTING OFF IN THE MIDDLE OF THE STREET LIKE THAT. *TR

THE TURN SIGNALS AND HAZARD LIGHTS WORK INTERNITTANTLY ON THIS AND SOMETIMES NOT AT ALL. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 45 MPH, THE TURN SIGNAL MECHANISM FAILED. THE TURN SIGNAL HAS NOT YET BEEN REPAIRED. THE CONTACT PLANS TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER FOR REPAIR. THE CURRENT AND FAILURE MILEAGES WERE 68,961.

RAN SEVERAL ERRANDS AND THE CAR STARTED FINE THREE TIMES THAT MORNING. THE FOURTH TIME IT WOULD CRANK BUT NOT TURN OVER. LET IT SIT FOR 30 MINUTES AND TRIED AGAIN. SAME PROBLEM. LET IT SIT FOR 4 HOURS. SAME PROBLEM. ALSO, CAR MAKING RANDOM TURN SIGNAL NOISES FOR THE PAST MONTH. MECHANICS ARE NOW REPLACING IGNITION CYLINDER AND SWITCH TO THE TUNE OF $600. WISH I WOULD'VE READ ABOUT THIS PROBLEM ONLINE TO TRY OTHER SOLUTIONS FIRST. *TR

I HAVE A 2002 CHEVY MALIBU. IT HAS THE TURN SIGNAL/FLASHER PROBLEM THAT WAS COVERED IN PE05055. THE DEALER INSTALLED THE NEW FLASHER PER THE SERVICE LETTER BUT THIS DID NOT FIX THE PROBLEM. DEALER WANTS $94 TO DIAGNOSE THE REAL PROBLEM PLUS POSSIBLY HUNDREDS TO FIX IT. CHEVY CUSTOMER SERVICE WILL NOT DO ANYTHING UNTIL I PAY FOR THE DIAGNOSIS, EVEN THEN THEY WILL NOT GIVE ANY ASSURANCES. A QUICK INTERNET SEARCH INDICATES THAT MANY OTHERS HAVE HAD SIMILAR EXPERIENCES. I THINK THAT YOU CLOSED YOUR INVESTIGATION PREMATURELY. *TR

INTAKE MANIFOLD GASKET LEAKING,CAUSING CONTAMINATION OF ANTIFREEZE AND MOTOR OIL. REPAIRS COST MR $770 DOLLARS. IT SEEMS TO BE A COMMON PROBLEM ON 2002 CHEVROLET MALIBU'S. *TR

WHEN DRIVING FASTER THAN 40 MILES AN HOUR THE STEERING WHEEL VIBRATES LIKE THE WHEELS ARE OUT OF ALIGNMENT OR THE TIRES HAVE A BROKEN BELT. THE FASTER YOU DRIVE, THE MORE PRONOUNCED THE VIBRATION BECOMES. I GOT NEW TIRES, NOT SAME AS OEM, AND IT'S BETTER, BUT STILL VERY NOTICEABLE AT FREEWAY SPEEDS. *TR